GMC Sierra 1500 (2000-2012) hot at all times Wiring diagrams

1 3 2 6 12-VOLT REF LO SERIAL DATA HI SERIAL DATA GROUND 12 13 12-VOLT REF BRAKE SW SIG PARK BRAKE SW SIG PPL 12-VOLT REF ANGLE SENSOR PHASE B CAN BUS LOW SERIAL DATA 12-VOLT REF LF WHEEL SPD SENS SIG 16 17 COMPUTER DATA BUS + DATA BUS - DATA LINES SYSTEM 2501 2501 COMPUTER DATA LINES SYSTEM 5-VOLT REF VEHICLE SPEED SIGNAL CAN BUS HIGH SERIAL DATA ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE COMPUTER DATA LINES SYSTEM DIESEL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT LUXURY GAS GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES I/P MULTI-FUNCTION SWITCH INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 43 (DIESEL) FUSE 46 (GAS) LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LOGIC LOW REF 12-VOLT REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL PPL RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) RIGHT REAR WHEEL SPEED SENSOR (WSS) (ON RIGHT REAR BRAKE BACKING PLATE) SERIAL DATA SERIAL DATA BATTERY POSITIVE VOLTAGE SERIAL DATA BUS (+) SERIAL DATA BUS (+) BATTERY POSITIVE VOLTAGE SERIAL DATA BUS- SERIAL DATA BUS- GROUND SIG STEERING ANGLE SENSOR (ON STEERING COLUMN) STOP LAMP SWITCH (TOP OF BRAKE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH TRACTION CTRL SW SIG VEHICLE SPD SIG RADIO WHT WIRE YAW RATE, LATERAL ACCELERATION SENSOR (UNDER CENTER CONSOLE TRIM PANEL) YEL WIRE YEL/BLK WIRE

12 VOLT REF 12-VOLT REF RF WHEEL SPD SENS SIG GROUND ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR COMPUTER DATA LINES SYSTEM DATA BUS - DIESEL DIESEL GAS DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) EXCEPT LUXURY GAS GRY WIRE GRY/WHT WIRE HEAVY DUTY ABS FUSE 59 (GAS) FUSE 55 (DIESEL) HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 43 (DIESEL) FUSE 46 (GAS) LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LUXURY NCA WIRE NEAR FAN SHROUD) ORG/ WIRE ORG/WHT WIRE PARK BRAKE SW SIG PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SERIAL DATA SIG TAN WIRE TAN/BLK WIRE VEHICLE SPD SIG VEHICLE SPD SIG RADIO YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 B+ 5-VOLT REF 12-VOLT REF 12-VOLT REF LR SIG WHEEL SPD SENS 16 17 DATA BUS+ DATA BUS- 2 4 3 1 SERIAL DATA 12-VOLT SERIAL DATA LOW REF 21 22 23 24 25 26 27 12-VOLT REF LF WHEEL SPD SENS SIG 2500 2500 COMPUTER DATA LINES SYSTEM 2500 2501 COMPUTER DATA LINES SYSTEM 35 36 37 38 SERIAL DATA 6032 (OR 817) ABS INDICATOR ABS-1 FUSE 61 ABS-2 FUSE 9 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE CAN BUS HIGH SERIAL DATA GROUND COMPUTER DATA LINES SYSTEM DATA SERIAL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT LUXURY GAS GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) I/P MULTI-FUNCTION SWITCH (W/ ACTIVE BRAKE CONTROL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 (GAS) FUSE 43 (DIESEL) LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LF WHEEL SPD SENS SIG LOGIC LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PARK BRK SW POWER DISTRIBUTION SYSTEM PPL RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RF SIG WHEEL SPD SENS RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) RIGHT REAR WHEEL SPEED SENSOR (WSS) (ON RIGHT REAR BRAKE BACKING PLATE) SENSOR PHASE A 5-VOLT REF BOOSTER VACUUM SENS SIG SERIES) SIG STEERING ANGLE SENS SIG STEERING ANGLE SENSOR STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH TRACTION CTRL SW SIG 12 13 12-VOLT REF PPL BRAKE SW SIG VEH SPD SIGNAL VEHICLE SPD SIG VEHICLE SPD SIG LOW REF GROUND SERIAL DATA BUS- SERIAL DATA BUS- W/ ACTIVE BRAKE CONTROL W/O ACTIVE BRAKE CONTROL WHT WIRE WHT/ BLK WIRE YAW RATE, LATERAL ACCELERATION SENSOR (W/ ACTIVE BRAKE CONTROL) YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 SENS CTRL PTLAN + PTLAN - PTLAN + PTLAN - GROUND 12-VOLT REF LF SIG WHEEL SPD SENS GROUND 5-VOLT REF 16 17 2500 2501 COMPUTER DATA LINES SYSTEM DATA BUS + DATA BUS - 6 16 CRUISE/ETC/ TCC BRK SIG PARK BRK SW ABS INDICATOR ABS-1 FUSE 61 BLK WIRE BLK/ GRY WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE MASTER CYLINDER PISTON POSITION SENSOR (BOTTOM OF BRAKE MASTER CYLINDER) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRK APPLIED SIG SERIAL DATA COMMUNICATION GROUND IGN VOLT BRN WIRE COMPUTER DATA LINES SYSTEM DATA SERIAL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM MISC IGN IGN FUSE 43 FUSE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT LUXURY EXTERIOR LIGHTS SYSTEM PNK PNK PPL PNK PPL WIRE GRY BLK/ WIRE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEAVY DUTY ABS FUSE 59 HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) HOT W/ RUN/CRNK RELAY ENERGIZED I/P MULTI-FUNCTION SWITCH INSTRUMENT PANEL CLUSTER (IPC) INTERIOR LIGHTS SYSTEM TRACTION CONTROL SWITCH IPC FUSE LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P J/B (LOWER LEFT SIDE OF DASH) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LUXURY NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PNK AIR CONDITIONING SYSTEM WIRE PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWER DISTRI- BUTION SYSTEM PPL RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SIG STEERING ANGLE SENSOR (ON STEERING COLUMN) STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CTRL SW SIG 12 13 812 7062 12-VOLT REF PPL BRAKE SW SIG VEHICLE SPD SIG WHT RED/ WIRE YAW RATE, LATERAL ACCELERATION SENSOR (UNDER CENTER CONSOLE TRIM PANEL) YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 AIR TMP 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 B(+) 5 VOLT REF AMB AIR TMP GMLAN L A/C COMPRESSOR A/C IND A/C ON A/C REFRIGERANT PRESSURE SENSOR ACCM FUSE 3 AMBIENT AIR TEMPERATURE SENSOR (ON LEFT SIDE OF RADIATOR SUPPORT) AMBIENT LIGHT/SUNLOAD SENSOR ASSEMBLY (TOP CENTER OF DASH) AUTO AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) B+ GND GMLAN SERIAL BLK WIRE BLK/WHT WIRE CAB HTR PUMP FUSE 4 CAB HTR PUMP RELAY COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVE MOTOR GENERATOR POWER INVERTER MODULE (RIGHT REAR OF ENGINE COMPT) FAN DN FAN UP FRESH AIR FRNT DFG FRT DEF FSH AIR GROUND DISTRIBUTION SYSTEM GROUND IGN 3 REAR DEFOG GROUND LOW REF GRY WIRE GRY/BLK WIRE HEATER COOLANT PUMP HOT AT ALL TIMES HVAC CONTROL MODULE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT SUNLOAD SENSOR LEFT TEMP CONTROL LF SUNLD L AIR TMP R AIR TMP LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE MODE DN MODE UP OFF ORG/ WIRE PNK COOLING PUMP RLY CTRL WIRE PNK WIRE POWER DISTRIBUTION SYSTEM DEFOGGER SYSTEM PPL REAR DFG RECIR RECIRC RED/WHT WIRE RER DEF RIGHT SUNLOAD SENSOR RIGHT TEMP CONTROL SENS SIG RF SUNLD TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

35 55 21 37 57 51 72 LOW REF ECT SENS SIG LOW REF 54 41 MED SPD FAN HI SPD FAN PPL A/C LOW PRESSURE SENSOR BATT POS VOLT BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENG FUSE 4 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP OF ENGINE) GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY ENERGIZED HVAC BATT FUSE 39 HVAC BLWR FUSE 70 HVAC-IGN FUSE 55 LOW REF LOW SPD FAN LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MTR SPD CTRL ORG/BLK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RLY CTRL RUN/ CRNK RELAY SENS SIG DATA BUS - DATA BUS + TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BLK WIRE BRN WIRE DK BLU WIRE DK GRN WIRE FAN 1 FUSE FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN MID 1 RELAY FAN MID 2 RELAY FAN-2 FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES LEFT AIR TEMPERATURE ACTUATOR (BOTTOM LEFT OF HVAC MODULE) LEFT ENGINE COOLING FAN LEFT ENGINE COOLING FAN RESISTOR LOGIC LOWER LEFT AIR TEMPERATURE SENSOR (LEFT SIDE OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (LOWER LEFT OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT END OF HVAC MODULE) PNK WIRE PPL RECIRCULATION ACTUATOR (TOP RIGHT SIDE OF HVAC MODULE) LOGIC RIGHT AIR TEMPERATURE ACTUATOR (TOP MIDDLE OF HVAC MODULE) RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) RIGHT ENGINE COOLING FAN RESISTOR TAN WIRE WHT/BLK WIRE YEL WIRE

1 5 B(+) GMLAN L 2501 2500 COMPUTER DATA LINES SYSTEM 3340 5060 COMPUTER DATA LINES SYSTEM 4.3L 6.6L EXCEPT 4.3L, 6.6L 4.3L A/C CMPRSR FUSE 17 (EXCEPT 6.6L) FUSE 16 (6.6L) A/C CMPRSR RELAY A/C IND A/C ON A/C REFRIGERANT PRESSURE SENSOR (NEAR COMPRESSOR, ON A/C HIGH PRESSURE HOSE) BLK WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) GROUND GRY WIRE HOT AT ALL TIMES HVAC BATT FUSE 39 (EXCEPT 6.6L) FUSE 36 (6.6L) HVAC CONTROL MODULE LOGIC MANUAL A/C AUTOMATIC A/C ORG/BLK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

19 14 LOW REF A/C REFRIG 5 3 GMLAN L 5 VOLT REF A/C COMPRESSOR A/C IND A/C LOW PRESSURE SENSOR A/C ON A/C REFRIGERANT PRESSURE SENSOR (RIGHT REAR OF ENGINE COMPT) ACCM FUSE 3 AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) B+ GMLAN SERIAL GND BLK/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVE MOTOR GENERATOR POWER INVERTER MODULE (RIGHT REAR OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LOW REF SENS SIG GMLAN - GLMAN + ORG/ WIRE ORG/BLK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE

2 OR MORE OF W/ ONSTAR, AUDIO AMPLIFIER (IF EQUIPPED) (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DATA LINK CONNECTOR (DLC) (LOWER LEFT SIDE OF DASH) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT END OF DASH) DIGITAL RADIO, REAR SEAT, DK GRN WIRE DRIVER DOOR LOCK/WINDOW SWITCH DRIVER'S SEAT EARPHONE JACKS RADIO CONTROL GROUND DISTRIBUTION SYSTEM HEATED SEAT CONTROL MODULE (W/ SPO HEATED SEATS) HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW SPD GMLAN SER DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED SERIAL DATA LTR FUSE 53 (EXCEPT 6.6L) FUSE 50 (6.6L) MEMORY SEAT MODULE (W/ INDIVIDUAL FRONT SEAT) (UNDER FRONT OF NOT USED NOT USED PASSENGER DOOR LOCK/WINDOW SWITCH POWER DISTRIBUTION SYSTEM RADIO REAR OBJECT SENSOR CONTROL MODULE (AT REAR CARGO AREA, BEHIND TRIM PANEL) REAR SEAT AUDIO (RSA) CONTROL REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) TAN WIRE TAN/BLK WIRE THEFT DETERRENT CONTROL MODULE (TDM) (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) W/ DIGITAL RADIO W/ DIGITAL RADIO, REAR SEAT, ONSTAR, EARPHONE JACKS RADIO CONTROL W/ FRONT SEAT, REMOTE CONTROL W/ INDIVIDUAL FRONT SEAT W/ LUXURY EDITION W/ ONSTAR W/ RADIO PROVISIONS W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL W/ REMOTE KEYLESS ENTRY W/O INDIVIDUAL FRONT SEAT W/O LUXURY EDITION W/O RADIO PROVISIONS WHT WIRE