GMC Sierra 1500 (2000-2012) computer data lines system Wiring diagrams

13 34 12 59 58 17 27 28 8 65 25 13 5 49 44 43 LOW REF 22 21 4 58 LOW REF ECT SENS SIG 4.8L, 5.3L, 6.2L 4.3L BLK WIRE COMPUTER DATA LINES SYSTEM COOLING FAN DIODE 1 COOLING FAN DIODE 2 DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN-1 FUSE 60 FAN-2 FUSE 62 GRY WIRE HOT AT ALL TIMES LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE ORG/BLK WIRE PWR/ TRN RELAY RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) SENS SIG PWRTRN RLY CTRL FAN RLY CTRL FAN RLY CTRL DATA BUS (-) DATA BUS (+) TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

14 13 15 LOW REF STP CP SW SIG 5 VOLT REF 2501 2500 COMPUTER DATA LINES SYSTEM ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL BATT + BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DIM FUSE 7 DK BLU WIRE DK GRN WIRE ECM BATT FUSE 12 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) GMLAN DATA BUS- GRN/WHT WIRE GROUND GROUND DISTRIBUTION SYSTEM GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (BEHIND STEERING WHEEL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE RED/WHT WIRE RES+ SER DATA SET- SOUND SYSTEMS TAN WIRE TAN/BLK WIRE TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON TRANSFER CASE TAILSHAFT HOUSING) VSS HI SIG VSS LO SIG W/ ACTIVE 2 SPEED PUSH BUTTON CONTROL TRANSFER CASE W/O ACTIVE 2 SPEED PUSH BUTTON CONTROL TRANSFER CASE WHT WIRE WHT/BLK WIRE YEL WIRE

335 5128 54 41 MED SPD FAN RLY HI SPD FAN RLY PPL AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENG FUSE 4 ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP OF ENGINE) FAN 1 FUSE FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN MID 1 RELAY FAN MID 2 RELAY FAN RESISTOR FAN-2 FUSE GMLAN L GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY ENERGIZED HVAC CONTROL MODULE LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LEFT ENGINE COOLING FAN RESISTOR LOGIC LT BLU WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) RIGHT ENGINE COOLING TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

10 11 DATA BUS + DATA BUS - 14 13 15 LOW REF STP LP SW SIG 5 VOLT REF 20 33 47 36 35 49 37 BATT + 66 67 VSS HI SIG VSS LO SIG ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR BATT + BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR BRN WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DIM FUSE 7 DK BLU WIRE DK GRN WIRE ECM BATT FUSE 12 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) GRN/WHT WIRE GROUND GROUND DISTRIBUTION SYSTEM GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (BEHIND STEERING WHEEL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/WHT WIRE OUT SPD SENS (OSS) SIG OUT SPD SENS (OSS) SIG PNK TRANSMISSIONS SYSTEM WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE RED/WHT WIRE RES+ SER DATA SER DATA BUS - SET- SOUND SYSTEMS TAN WIRE TAN/BLK WIRE TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE

17 6 DATA BUS + DATA BUS - 3 2 1 4 GND AIR INLET DRIVE MOTOR BATTERY TEMPERATURE SENSOR AIR OUTLET DRIVE MOTOR BATTERY TEMPERATURE SENSOR AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE BECM FAN FUSE 2 BLK WIRE BLK/YEL WIRE BLU WIRE COMPT) COOL PUMP COMPUTER DATA LINES SYSTEM COOL PUMP FUSE 6 DATA BUS - DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE DRIVE MOTOR BATTERY TEMPERATURE SENSOR 1 DRIVE MOTOR BATTERY TEMPERATURE SENSOR 2 DRIVE MOTOR BATTERY TEMPERATURE SENSOR 3 DRIVE MOTOR BATTERY TEMPERATURE SENSOR 4 DRIVE MOTOR GENERATOR BATTERY (UNDER SECOND ROW SEATS) DRIVE MOTOR GENERATOR BATTERY CONTROL MODULE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) GENERATOR BATTERY VENT FAN GENERATOR BATTERY VENT FAN RELAY GENERATOR CONTROL MODULE TEMPERATURE SENSOR GRN WIRE HOT AT ALL TIMES IN TEMP SENS RTN IN TEMP SENS SIG LEFT GENERATOR CONTROL MODULE COOLANT PUMP LOW REF LOW TEMP COOLING PUMP MTR GND NOT USED NOT USED RLY CTRL ORG/ WIRE OUT TEMP SENS RTN OUT TEMP SENS SIG PNK WIRE PNK/DK BLU WIRE RED WIRE RED/WHT WIRE RELAY RIGHT GENERATOR CONTROL MODULE COOLANT PUMP TAN WIRE TAN/BLK WIRE TEMP SENS RTN 1 TEMP SENS RTN 2 TEMP SENS RTN 3 TEMP SENS RTN 4 TEMP SENS SIG 1 TEMP SENS SIG 2 TEMP SENS SIG 3 TEMP SENS SIG 4 WHT WIRE WHT/GRN WIRE YEL WIRE

10 11 13 14 DATA BUS + DATA BUS - DATA BUS - DATA BUS + 14 13 15 LOW REF STP CP SW SIG 5 VOLT REF 42 26 54 22 58 38 LOW REF BRK APPLY SENS SPLY SUPPLY VOLT 6.0L APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF VSS LO SIG VSS HI SIG PPL AUTOMATIC TRANSMISSION BATT + BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR BRN WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DIM FUSE 7 DK BLU WIRE DK GRN WIRE ECM BATT FUSE 12 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) EXCEPT 6.0L GRN WIRE GRN/WHT WIRE GROUND GROUND DISTRIBUTION SYSTEM GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (BEHIND STEERING WHEEL) INPUT SHAFT SPEED SENSOR (ISS) INPUT SPEED SENSOR (ISS) SIGNAL INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 ISS/OSS SUPPLY VOLTAGE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE OUTPUT SHAFT SPEED SENSOR (OSS) OUTPUT SPEED SENSOR (OSS) SIGNAL PNK PNK WIRE PNK TRANSMISSIONS SYSTEM COLUMN HARNESS) WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SER DATA SET- SOUND SYSTEMS TAN WIRE TAN/BLK WIRE TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ 2 SPEED MANUAL TRANSFER CASE WHT WIRE WHT/BLK WIRE YEL WIRE

13 14 39 DATA BUS (-) DATA BUS (+) 2501 2500 1786 COMPUTER DATA LINES SYSTEM 51 72 GMLAN DATA BUS (-) GMLAN DATA BUS (+) 66 67 REPLICATED TOS SIG VSS SIG AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR SIGNAL BATT + GND BRAKE PEDAL SIG BLK/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALUE ASSEMBLY DK BLU WIRE DK GRN WIRE DRIVE MOTOR GENERATOR POWER INVERTER MODULE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUSE 19 GMLAN HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED IGN INSTRUMENT CLUSTER PANEL (IPC) INTERNAL MODE SW (IMS) GND LEFT I/P JUNCTION BLOCK LOGIC LOW REFERENCE LT BLU/WHT WIRE LT GRN/BLK WIRE MISC-IGN FUSE 43 ORG/BLK WIRE PC SOLENOID 1 CONTROL PC SOLENOID 2 CONTROL PC SOLENOID 3 CONTROL PC SOLENOID 4 CONTROL PC SOLENOID 5 CONTROL PC SOLENOID 6 CONTROL PNK PNK PNK PNK WIRE PNK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE PRESSURE CONTROL (PC) SOLENOID VALVE 1 PRESSURE CONTROL (PC) SOLENOID VALVE 2 PRESSURE CONTROL (PC) SOLENOID VALVE 3 PRESSURE CONTROL (PC) SOLENOID VALVE 4 PRESSURE CONTROL (PC) SOLENOID VALVE 5 PRESSURE CONTROL (PC) SOLENOID VALVE 6 RED/WHT WIRE REPLICATED TOS SIGNAL SERIAL DATA BUS (+) SERIAL DATA BUS (-) SHIFT SOLENOID (SS) 1 CONTROL SHIFT SOLENOID (SS) 2 CONTROL SHIFT SOLENOID (SS) VALVE 1 SHIFT SOLENOID (SS) VALVE 2 STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TCM- BATT FUSE 14 TO AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) (DIAGRAM 2 OF 2) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON TRANSFER CASE TAILSHAFT HOUSING) W/0 ACTIVE TWO SPEED PUSH BUTTON CONTROL TRANSFER CASE WAKE UP SERIAL DATA SERIAL DATA BUS (+) SERIAL DATA BUS (-)

A/T MANUAL SHIFT SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) AUTOMATIC TRANSMISSION SHIFT LEVER BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM FROM AUTOMATIC TRANSMISSION (DIAGRAM 1 OF 2) FTP SWITCH 1 VOLTAGE FTP SWITCH 3 VOLTAGE FTP SWITCH 4 VOLTAGE FTP SWITCH 5 VOLTAGE GMLAN GMLAN SERIAL SERIAL DATA DATA BUS - BUS + GMLAN SERIAL DATA BUS + GRN WIRE GRY WIRE ISS/OSS SUPPLY VOLTAGE NCA WIRE ORG/WHT WIRE OUTPUT SHAFT SPEED SENSOR (OSS) OUTPUT SPEED SENSOR (OSS) SIGNAL PNK WIRE PPL PPL/WHT WIRE RED WIRE TAN WIRE TAN/BLK WIRE TAP UP/ TAP DOWN SW SIG TRANSMISSION CONTROL MODULE (TCM) CONTROL SOLENOID VALVE ASSEMBLY TRANSMISSION RANGE SWITCH SIG A TRANSMISSION RANGE SWITCH SIG B TRANSMISSION RANGE SWITCH SIG C TRANSMISSION RANGE SWITCH SIG P WHT WIRE YEL WIRE

7 3 SUPPLY VOLT LOW REF BATTERY BLK WIRE COMPUTER DATA LINES SYSTEM DDM FUSE 4 DK GRN WIRE DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR GRN WIRE GROUND HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, LOGIC LOW REF ORG/ WIRE PASSENGER DOOR LOCK/WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM REAR DEFOGGER IND REAR DEFOGGER SWITCH RED WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA SUPPLY VOLT WHT WIRE

6399 (OR 821) 822 451 A/C CL CTRL A/C PRESS SIG LO REF AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM 459 3223 3122 ANTI-LOCK BRAKES SYSTEM COOLING FANS SYSTEM AXL SW SIG BANK 1 SENSOR 2 (DOWNSTREAM OF LEFT CATALYTIC CONVERTER) BANK 2 SENSOR 2 (DOWNSTREAM OF RIGHT CATALYTIC CONVERTER) BLK/WHT WIRE BRAKE PEDAL POSITION SENSOR BRK APLY VOLT SENR BRK SW SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID VALVE (UNDER REAR OF VEHICLE) FRONT FUEL PUMP, SENDER ASSEMBLY (IN FRONT FUEL TANK) FUEL CTRL FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL PUMP, SENDER ASSEMBLY) GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN IAT SIG LO REF LO REF LO REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MAF SIG LOW REF MIL CTRL PPL NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL FUEL LVL-PRI CFAN HI CTRL ACC SER DATA PPL LO REF FTP SIG PPL/WHT WIRE RED/WHT WIRE SNSR SIG SNSR SIG GMLAN (-) GMLAN (+) STARTING/ CHARGING SYSTEM STRT RLY CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TOS SIG OR VSS HI SIG VSS LO SIG GND 71 72 73 TRANSMISSIONS SYSTEM VOL SNSR VSS CFAN LO CTRL PWTN RLY CTRL W/ TWO SPEED TRANSFER CASE W/O TWO SPEED TRANSFER CASE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE