GMC Savana G3500 (1996-2013) brn Wiring diagrams

22 27 21 6.6L 4.3L EXCEPT 4.3L 55 43 44 9 28 27 BRAKE SIG SER DATA BUS(+) SER DATA BUS(-) 66 46 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL BATT + BCM 2 FUSE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE APPLY SEN SIG BRAKE LOW REF BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRAKE SENS SIG BRAKE SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE ENGINE CONTROL MODULE (ECM) GMLAN SER DATA GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOWER RIGHT FRONT OF ENGINE) LT BLU WIRE LT BLU/WHT WIRE MODULE COIL (AT TOP OF STEERING COLUMN) PNK WIRE PPL RED/WHT WIRE SPLY VOLT TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) (4.8L, 5.3L, 6.0L: ON LEFT SIDE OF THROTTLE BODY) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

24 39 31 16 LOW REF SENS SIG PPL 2759 1589 (OR 6049) 4.3L 4.8L/5.3L/6.0L 6.6L 2 3 44 43 DATA BUS(-) DATA BUS(+) 50 41 36 35 331 2705 4 30 SENS SIG 58 28 1589 2759 PPL 6 7 8 9 PPL PNK WIRE 7 8 PPL 9 10 PPL BLK WIRE BLK/WHT WIRE BLU WIRE BLU/YEL WIRE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE ILLUMI- NATION LEFT SLIDING DOOR AJAR SWITCH (W/ LEFT REAR HINGED DOOR) LOW REF PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION VEHICLE INFO PNK WIRE PNK/BLK WIRE PPL PPL 2 3 RIGHT SLIDING DOOR AJAR SWITCH (W/ CARGO/PASSENGER) SENS SIG SENS SIG LOW REF SET/ RESET SWITCH SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

4.3L 4.8L/5.3L/6.0L 6.6L 2 3 4.3L, 4.8L, 6.0L 5.3L (VIN G) 6.0L (VIN B) 7 8 PPL 9 10 PPL ALTERNATIVE FUEL TANK PRESSURE SENSOR BLK WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CNG CONTROL MODULE (6.0L(VIN B)) (FORWARD OF LEFT REAR SPRING ON FRAME) CNG FUEL VEHICLE ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) FUEL LEVEL SENSOR (ON FUEL TANK) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRN WIRE GRY WIRE HEAVY DUTY LIGHT DUTY LOW REF LPG CONTROL MODULE (6.0L(VIN B)) (ON TANK CONTROL BOX) LPG FUEL VEHICLE W/ 3 TANK LPG FUEL VEHICLE W/ 4 TANK LT BLU/BLK WIRE PPL PPL 2 3 PPL FUEL PUMP RELAY SIG PPL SENSING PRESSING PRIMARY FUEL LEVEL SENSOR PRIMARY SIG FUEL SENDER RED WIRE SECONDARY FUEL LEVEL SENSOR SECONDARY SIG FUEL SENDER TAN WIRE TAN/WHT WIRE W/ BRAKE WARNING INDICATOR SYSTEM WHT WIRE

6.0L (VIN B) 6.0L VIN G 6.0L VIN B A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE BRN WIRE CNG FUEL VEHICLE COMPUTER DATA LINES SYSTEM CUTAWAY LPG FUEL VEHICLE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE ECM IGN/ GLOW PLUG MDL IGN FUSE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSOR FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRANK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK PPL PPL 8 9 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS W/ 3 TANK LPG FUEL VEHICLE W/ 4 TANK WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR/ VENT/ SOL FUSE COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS IGNITION RELAY EVAP SOL CTRL EVAPORATIVE EMISSION VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE FLEX FUEL FUSE FUEL INJECTOR 2 FUEL INJECTOR 4 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/BLK (OR BLK) WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MAF/ CNSTR VENT FUSE MALFUNCTION INDICATOR LAMP (MIL) MIL CTRL ODD IGN/INJ FUSE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK (OR RED) WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PPL 2 3 4 WIRE PNK PPL PNK PNK PPL WIRE PNK PPL PPL 8 9 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED/WHT WIRE SNSR 1 (PRE)/ CLS FUSE SNSR 2 (POST) FUSE TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ 3 TANK W/ 4 TANK WHT WIRE YEL WIRE

13 14 15 16 17 18 PNK WIRE 5 VOLT REF ALTERNATIVE FUEL TANK PRESSURE SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE CNG CUTT-OFF SOLENOID VALVE 2 CNG CUTT-OFF SOLENOID VALVE 3 CNG SOL VLV CTRL DK GRN WIRE DK GRN/WHT WIRE FUEL COMPOSITION SENSOR FUEL INJECTOR 3 FUEL INJECTOR 7 GRN WIRE GRY WIRE IGNITION COIL 1 IGNITION COIL 3 IGNITION COIL 5 IGNITION COIL 7 LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK PNK 11 12 WIRE PNK PNK 8 9 WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PPL PNK 19 20 21 WIRE PNK PPL PNK PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PRESSURE SIG RED WIRE SENSING SPARK PLUG W/ 3 TANK W/ 4 TANK WHT WIRE

13 14 15 16 17 18 PNK WIRE BLK WIRE BRN WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL PUMP RELAY GAS FUEL PUMP FUSE GRY WIRE HOT AT ALL TIMES IGNITION COIL 2 IGNITION COIL 4 IGNITION COIL 6 IGNITION COIL 8 LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEGA FUSE NATURAL GAS REGULAR GAS NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK PNK 11 12 WIRE PNK PNK 3 4 WIRE PNK PNK 6 7 8 WIRE PNK PNK 8 9 WIRE PNK PPL 14 15 WIRE PNK PPL PNK 19 20 21 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE REAR LPG CUT-OFF SOLENOID VALVE SECONDARY FUEL PUMP RED WIRE RED/WHT WIRE REGULAR GAS W/ 3 TANK REGULAR GAS W/ 4 TANK SECONDARY LPG PUMP ASSEMBLY SIDE OF ENGINE COMPT) SPARK PLUG UNDERHOOD FUSE BLOCK (ON LEFT

12 VOLT REF 7 8 9 PNK WIRE BATT POS VOLT BLK WIRE BLU WIRE BRN WIRE FRONT LPG CUT-OFF SOLENOID VALVE FUEL GAUGE SIG FUSE HOLDER LPCM FUSE (REGULAR GAS W/ 3 TANK) FUSE LPCM FUSE HOLDER (REGULAR GAS W/ 4 TANK) GRN WIRE GRY WIRE LPG CONTROL MODULE (REGULAR GAS W/ 4 TANK) (ON TANK CONTROL BOX) LPG PRESSURE, TEMPERATURE SENSOR LPG PURGE SOLE- NOID VALVE LPG TANK SCAVENGE PUMP LT BLU/BLK WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK 2 3 WIRE PNK PNK 3 4 WIRE PNK PNK 5 6 WIRE PNK PNK 6 7 8 WIRE PNK PPL 14 15 WIRE PNK WIRE PNK/BLK WIRE PPL PRIMARY FUEL PUMP, PRIMARY LPG PUMP ASSEMBLY PRIMARY SIG PUMP SIG RED WIRE RED/WHT WIRE RLY SIG SECONDARY SIG STRT LMP W/ 3 TANK W/ 4 TANK WAIT TO START INDICATOR WHT WIRE YEL WIRE

5 VOLT REF 7 8 9 PNK WIRE BATT POS VLT BLK WIRE BRN WIRE DK BLU/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP FUEL CUTOFF SOLENOID VALVE FUEL INJECTOR 1 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 8 FUEL INJECTOR CONTROL MODULE FUEL PUMP FUEL TEMP SIG GRN WIRE GRY WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE ORG/BLK WIRE PMP SIG PNK 5 6 WIRE PNK 7 8 9 WIRE PNK PNK 2 3 WIRE PNK PNK 5 6 WIRE PNK WIRE PNK/BLK WIRE PRESS SIG PRIMARY FUEL LEVEL SENSOR (6.0L VIN B) (FRONT OF PRIMARY FUEL TANK) RED WIRE RED/BLK WIRE RELY VOLT RESISTOR RLY SIG SECONDARY FUEL LEVEL SENSOR (6.0L VIN B) (FRONT OF SECONDARY FUEL TANK) SOL RLY SIG TAN WIRE TAN/WHT WIRE TEMP SENS W/ 3 TANK W/ 4 TANK WHT WIRE YEL WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) ACTUATOR SOLENOID VALVE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE