GMC Savana G2500 (1996-2013) tan Wiring diagrams

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

4.3L/ 5.3L 4.8L 6.0L AUTOMATIC TRANSMISSION ASSEMBLY AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) BATTERY BATTERY CURRENT SENSOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) GMLAN SERIAL DATA CHARGING CIRCUIT COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRNK RELAY 39 DATA BUS - DK GRN WIRE EXCEPT 4.3L 4.3L ENGINE CONTROL MODULE (ECM) FUSIBLE LINK 2 GRY WIRE IGNITION SWITCH IGNITION VOLTAGE NCA WIRE OFF ORG/BLK WIRE PARK/ DATA NEUTRAL/ BUS (-) SIGNAL PARK/NEUTRAL POSITION (PNP) SWITCH PNK WIRE PPL RED WIRE RUN WIRE STARTER ENABLE RELAY CTRL STARTER MOTOR STRTR SOL FUSE TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL/BLK WIRE

& IGNITION COIL/MODULE 8) 1 2 3 PPL BLK WIRE BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL RAIL PRESSURE (FPR) SENSOR GRY WIRE IGNITION COIL/MODULE 2) IGNITION COIL/MODULE 4 IGNITION COIL/MODULE 6 LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE SPARK PLUG TAN WIRE TAN/WHT WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1786 5985 TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM 2759 3108 2365 2931 6288 419 2927 2366 507 2366 3657 COOLING FANS SYSTEM 7493 2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM 439 492 225 1272 COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 EXHAUST TEMPERATURE SENSOR 5 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK WIRE RED/WHT WIRE REDUCTANT PRESSURE SENSOR REDUCTANT PURGE SOLENOID VALVE STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM 3101 6783 TAN WIRE TAN/BLK WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EXHAUST AFTERTREATMENT FUEL INJECTOR GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MIL SER CTRL DATA NITROGEN OXIDES SENSOR 1 NITROGEN OXIDES SENSOR 2 ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL/WHT WIRE RED/WHT WIRE REDUCTANT INJECTOR REDUCTANT LINE HEATER REDUCTANT PUMP REDUCTANT SENSOR MODULE REDUCTANT TANK HEATER SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND TAN WIRE TAN/BLK WIRE WAIT TO WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BATTERY BLK WIRE BRN WIRE CHARGE AIR COOLER INLET TEMPERATURE SENSOR CHARGE AIR COOLER OUTLET TEMPERATURE SENSOR COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSIBLE LINK 1 FUSIBLE LINK 4 GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - HTR CTRL IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH DIG SIG IAH FDBK SIG IAH HEART BEAT SIG IAH SW ON/OFF SIG IAH TEMP SIG IAH VOLT FEEDBACK SIG IAH VOLT SIG IGN 1 VOLT INTAKE AIR HEATER (BETWEEN INTAKE MANIFOLD TUBE, AIR COOLER OUTLET DUCT) LINE HTR CTRL LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSUE (MAP) SENSOR (ATTACHED TO INTAKE MANIFOLD TUBE) ORG/BLK WIRE ORG/WHT WIRE PLUG 1 CTRL PLUG 2 CTRL PLUG 3 CTRL PLUG 4 CTRL PLUG 5 CTRL PLUG 6 CTRL PLUG 7 CTRL PLUG 8 CTRL PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PUMP HTR CTRL RED WIRE RED/WHT WIRE SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SENS 2 SPLY VOLT TAN WIRE TAN/BLK WIRE UNDERHOOD JUNCTION BLOCK WAKEUP SER DATA YEL WIRE

5 VOLT REF ACT CTRL CLOSE ACT CTRL OPEN BLK/WHT WIRE BRN WIRE BRN/GRY WIRE BRN/WHT WIRE CAC TEMP SENS SIG CKP SENS SIG CMP SENS SIG CTRL CYL 2 CTRL CYL 3 CTRL CYL 5 CTRL CYL 8 DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE ECT SENS SIG EGR VALVE SENS SIG EGRT SENS 1 SPLY VOLT EGRT SENS 2 SPLY VOLT EGRV MTR HIGH SIG EGRV MTR LOW SIG EGT SENS 1 SIG ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 1 FUEL TEMP 1 SIG FUEL TEMP SIG FUEL TEMPERATURE SENSOR 1 FUEL TEMPERATURE SENSOR 2 GRY WIRE GRY/BLK WIRE GRY/WHT WIRE INTAKE AIR VALVE (ATTACHED TO LEFT SIDE OF INTAKE HOUSING) LOW REF LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESSURE SENS SIG ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POS SENS SIG POS SENS SIG 1 PPL/WHT WIRE PRESSURE SENS RTN PRESSURE SENS SIG PRESSURE SW SIG RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP 1 RTN TEMP SENS RTN TEMP SENS SIG WATER IN FUEL SENS SIG WATER IN-FUEL SENSOR WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DIESEL FUEL PUMP FUSE 24 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/GLOW PLUG MDL IGN FUSE 30 ECM PWR/ TRN FUSE 45 EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 2 EXHAUST GAS RECIRCULATION (EGR) VALVE (RIGHT SIDE OF ENGINE ABOVE 1 CYLINDER) FUEL FILTER PRESSURE SWITCH FUEL HTR FUSE 71 FUEL INJECTOR 2 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 3 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 5 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 8 (ON LEFT SIDE OF ENGINE) FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF/ CNSTR FUSE 71 NCA WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/ TRN RELAY 49 RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE

5 VOLT REF ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DFI VOLT CTRL CYL 4 DFI VOLT CTRL CYL 6 DFI VOLT CTRL CYL 7 DFI VOLT CTRL CYL 8 DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE OIL PRESSURE (EOP) SENSOR (LOWER LEFT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 1 FUEL HEATER FUEL INJECTOR 1 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 6 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 7 (ON RIGHT SIDE OF ENGINE) FUEL PRESSURE REGULATOR 1 FUEL PRESSURE REGULATOR 2 GND SOL HIGH SIG GRY WIRE LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PPL PPL/ WHT WIRE PPL/WHT WIRE SENS VOLT REF 5 VOLT REF SHEILD TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION SENSOR (ON TOP OF TURBOCHARGER) VALVE HIGH CTRL SOL SPLY VOLT VALVE LOW CTRL SOL LOW SIG LOW REF LOW REF VEHICLE SPD SIG WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE