GMC Savana G2500 (1996-2013) hot at all times Wiring diagrams

88 CM FROM RIGHT DOME FLUORESCENT WORK LAMP CONNECTOR BREAKOUT) ACCESS PANEL LEFT SIDE FRONT RELAY CONTROL ACCESS PANEL LEFT SIDE REAR RELAY CONTROL ACCESS PANEL RIGHT SIDE REAR RELAY CONTROL ACCESS PANEL) BETWEEN LEFT SIDE FRONT ACCESS PANEL ACTUATORS) BETWEEN LEFT SIDE REAR ACCESS PANEL ACTUATORS) BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) HOT AT ALL TIMES LEFT FRONT ACCESS PANEL RELAY LEFT FRONT SIDE FRONT ACCESS PANEL ACTUATOR (BEHIND LEFT FRONT ACCESS PANEL) LEFT FRONT SIDE REAR ACCESS PANEL ACTUATOR (BEHIND LEFT FRONT LEFT REAR ACCESS PANEL RELAY LEFT REAR SIDE FRONT ACCESS PANEL ACTUATOR LEFT REAR SIDE REAR ACCESS LT BLU WIRE LT GRN WIRE ORG/ WIRE PANEL ACTUATOR (BEHIND LEFT REAR ACCESS PANEL) PANEL ACTUATOR FUSE PNK WIRE REAR BODY FUSE BLOCK (ON LEFT "B" PILLAR) RIGHT REAR PANEL RELAY RIGHT SIDE FRONT ACCESS PANEL ACTUATOR (BEHIND RIGHT FRONT ACCESS PANEL) RIGHT SIDE REAR ACCESS PANEL ACTUATOR (BEHIND RIGHT REAR ACCESS PANEL) TAN WIRE TAN/BLK WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER CONTROL IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP (6.6L) FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT GRN WIRE MED OFF ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK REAR BLWR FUSE 29 RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS WHT WIRE YEL WIRE

A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR (ON AUXILIARY HVAC ASSEMBLY) AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR (ON AUXILIARY HEATER MOTOR) AUXILIARY HVAC MODULE) AUXILIARY MODE DOOR ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE FROM AUXILIARY BLOWER MOTOR BREAKOUT) FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

12 13 34 28 27 25 8 65 43 44 59 36 63 66 46 PRESS SENS LOW REF 19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 21 22 58 4 24 40 SENS SIG LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY 40 A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPT) COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER WHT (OR RED) WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BREAKOUT) BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP (6.6L) FLOOR MIX BLEND DEF MAX A/C OFF A/C BI-LEV FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GND IGN GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL SWITCH ASSEMBLY LEFT REAR OF ENGINE) (4.3L: RIGHT REAR OF ENGINE) LOGIC 2 1 LT BLU WIRE LT GRN WIRE MAX A/C OFF A/C BI-LEV VENT MED OFF ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK PNK/BLK WIRE PPL PPL/WHT WIRE REAR REAR AUXILIARY HVAC CONTROL ASSEMBLY REAR BLWR FUSE 29 RED WIRE RED/BLK WIRE RED/WHT WIRE RR AUX BLWR MTR CTRL SW FRT AUX BLWR MTR SPLICE BLOCK TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VENT FLOOR DEF MIX BLEND W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS W/ RV UPFITTER W/O RV (ATTACHED TO LOWER RIGHT "B" PILLAR PART OF UPFITTER W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL WIRE

2501 2500 2501 2500 COMPUTER DATA LINES SYSTEM A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR (ON AUXILIARY HVAC ASSEMBLY) AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (ON AUXILIARY AUXILIARY HVAC MODULE) AUXILIARY MODE DOOR ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BLOWER MOTOR BREAKOUT) BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HEATER MOTOR HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 24 40 58 4 21 22 SENS SIG LOW REF 59 36 63 66 46 25 8 65 43 44 12 13 34 28 27 PRESS SENS LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY 40 A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/ AUXILIARY FUEL FIRED HEATER WHT/BLK WIRE YEL WIRE

18 19 20 21 22 23 24 PNK WIRE 2755 1551 1670 1666 1551 1668 1665 REF LOW GND 3-2 SS CTRL REF LOW 439 440 574 PNK WIRE 440 1049 B+ CLS 2 DATA 625 1551 RLY CTRL GND 771 420 776 PRND A SIG BRK SW SIG PRND P SIG PPL 772 633 410 1020 PRND B SIG CMP SIG ECT SIG IGN INJ 2 CTRL INJ 6 CTRL BLK WIRE BLK/WHT WIRE BRN/WHT WIRE CENTRAL SEQUENTIAL FUEL INJECTION (AT TOP OF ENGINE) CKP 1 SIG DK BLU WIRE DK GRN WIRE ENG 1 FUSE 23 ENG 2 FUSE 21 FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) FUSE 39 FUSE 40 GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE 6 INJ 1 CTRL INJ 3 CTRL INJ 4 CTRL INJ 5 CTRL KS 1 SIGNAL LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PCM BATT FUSE 2 PNK 1 2 3 4 5 WIRE PNK PNK 25 26 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL PPL PPL/WHT WIRE RANGE B RANGE C IGN B+ REF LOW RED/WHT WIRE REF LOW REF LOW GND 1551 1671 1667 1551 1669 1653 REF LOW REF LOW STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

10 11 PNK WIRE 12 13 14 15 16 17 18 19 PPL 18 19 20 21 22 23 24 PNK WIRE BLK WIRE BRN/WHT WIRE CARGO/ PASSENGER CUTAWAY DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FUEL PUMP FUSE 12 FUEL PUMP RELAY FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (IN EXH PIPE, REAR OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (IN EXH PIPE, REAR OF CAT CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (ON TOP LEFT REAR OF (ENGINE) LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 4 5 WIRE PNK PNK 25 26 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE TAN WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE

14 15 16 17 18 19 20 21 PPL 20 21 22 23 24 25 26 27 PPL 22 23 24 PNK WIRE 28 29 30 PNK WIRE 8 9 PNK WIRE BLK/WHT WIRE BRN WIRE CAN VENT FUSE 34 DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES IGN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PNK 6 7 WIRE PNK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE SIGNAL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK VEHICLE SPEED SENSOR (ON RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE