GMC Savana G2500 (1996-2013) dk blu Wiring diagrams

1 2 B+ GND 1-2 SHIFT SOLENOID (SS) CONTROL 1-2 SHIFT SOLENOID (SS) VALVE 2-3 SHIFT SOLENOID (SS) CONTROL 2-3 SHIFT SOLENOID (SS) VALVE 6 7 8 9 10 11 12 BRAKE SW SIG 6.6L 6.6L AUTOMATIC TRANSMISSION ASSEMBLY AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR BLK/WHT WIRE BRK SW FUSE 13 BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER DISPLAY (DIC) ENGINE CONTROL MODULE (ECM) EXCEPT 6.6L 6.6L EXTERIOR LIGHTS SYSTEM 1786 2501 2500 6399 GMLAN HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IGN INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER LOGIC LOW REFERENCE LT BLU WIRE LT BLU/WHT WIRE ORG/BLK WIRE PC SOLENOID 1 CONTROL PC SOLENOID 2 CONTROL PC SOLENOID 3 CONTROL PC SOLENOID 4 CONTROL PC SOLENOID 5 CONTROL PNK WIRE PRESSURE CONTROL (PC) SOLENOID VALVE 1 PRESSURE CONTROL (PC) SOLENOID VALVE 2 PRESSURE CONTROL (PC) SOLENOID VALVE 3 PRESSURE CONTROL (PC) SOLENOID VALVE 4 PRESSURE CONTROL (PC) SOLENOID VALVE 5 RED/WHT WIRE STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TCM BATT FUSE 32 TCM IGN FUSE 31 TO AUTOMATIC TRANSMISSION ASSEMBLY (DIAGRAM 2 OF 2) TORQUE CONVERTER CLUTCH (TCC) PRESSURE CONTROL (PC) SOLENOID VALVE TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL TOW/HAUL IND TOW/HAUL SWITCH TRANSMISSION CONTROL MODULE (TCM) TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR SIGNAL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1786 5985 TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM 2759 3108 2365 2931 6288 419 2927 2366 507 2366 3657 COOLING FANS SYSTEM 7493 2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM 439 492 225 1272 COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 EXHAUST TEMPERATURE SENSOR 5 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK WIRE RED/WHT WIRE REDUCTANT PRESSURE SENSOR REDUCTANT PURGE SOLENOID VALVE STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM 3101 6783 TAN WIRE TAN/BLK WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EXHAUST AFTERTREATMENT FUEL INJECTOR GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MIL SER CTRL DATA NITROGEN OXIDES SENSOR 1 NITROGEN OXIDES SENSOR 2 ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL/WHT WIRE RED/WHT WIRE REDUCTANT INJECTOR REDUCTANT LINE HEATER REDUCTANT PUMP REDUCTANT SENSOR MODULE REDUCTANT TANK HEATER SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND TAN WIRE TAN/BLK WIRE WAIT TO WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BATTERY BLK WIRE BRN WIRE CHARGE AIR COOLER INLET TEMPERATURE SENSOR CHARGE AIR COOLER OUTLET TEMPERATURE SENSOR COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSIBLE LINK 1 FUSIBLE LINK 4 GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - HTR CTRL IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH DIG SIG IAH FDBK SIG IAH HEART BEAT SIG IAH SW ON/OFF SIG IAH TEMP SIG IAH VOLT FEEDBACK SIG IAH VOLT SIG IGN 1 VOLT INTAKE AIR HEATER (BETWEEN INTAKE MANIFOLD TUBE, AIR COOLER OUTLET DUCT) LINE HTR CTRL LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSUE (MAP) SENSOR (ATTACHED TO INTAKE MANIFOLD TUBE) ORG/BLK WIRE ORG/WHT WIRE PLUG 1 CTRL PLUG 2 CTRL PLUG 3 CTRL PLUG 4 CTRL PLUG 5 CTRL PLUG 6 CTRL PLUG 7 CTRL PLUG 8 CTRL PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PUMP HTR CTRL RED WIRE RED/WHT WIRE SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SENS 2 SPLY VOLT TAN WIRE TAN/BLK WIRE UNDERHOOD JUNCTION BLOCK WAKEUP SER DATA YEL WIRE

5 VOLT REF ACT CTRL CLOSE ACT CTRL OPEN BLK/WHT WIRE BRN WIRE BRN/GRY WIRE BRN/WHT WIRE CAC TEMP SENS SIG CKP SENS SIG CMP SENS SIG CTRL CYL 2 CTRL CYL 3 CTRL CYL 5 CTRL CYL 8 DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE ECT SENS SIG EGR VALVE SENS SIG EGRT SENS 1 SPLY VOLT EGRT SENS 2 SPLY VOLT EGRV MTR HIGH SIG EGRV MTR LOW SIG EGT SENS 1 SIG ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 1 FUEL TEMP 1 SIG FUEL TEMP SIG FUEL TEMPERATURE SENSOR 1 FUEL TEMPERATURE SENSOR 2 GRY WIRE GRY/BLK WIRE GRY/WHT WIRE INTAKE AIR VALVE (ATTACHED TO LEFT SIDE OF INTAKE HOUSING) LOW REF LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESSURE SENS SIG ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POS SENS SIG POS SENS SIG 1 PPL/WHT WIRE PRESSURE SENS RTN PRESSURE SENS SIG PRESSURE SW SIG RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP 1 RTN TEMP SENS RTN TEMP SENS SIG WATER IN FUEL SENS SIG WATER IN-FUEL SENSOR WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DIESEL FUEL PUMP FUSE 24 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/GLOW PLUG MDL IGN FUSE 30 ECM PWR/ TRN FUSE 45 EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 2 EXHAUST GAS RECIRCULATION (EGR) VALVE (RIGHT SIDE OF ENGINE ABOVE 1 CYLINDER) FUEL FILTER PRESSURE SWITCH FUEL HTR FUSE 71 FUEL INJECTOR 2 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 3 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 5 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 8 (ON LEFT SIDE OF ENGINE) FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF/ CNSTR FUSE 71 NCA WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/ TRN RELAY 49 RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE

5 VOLT REF ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DFI VOLT CTRL CYL 4 DFI VOLT CTRL CYL 6 DFI VOLT CTRL CYL 7 DFI VOLT CTRL CYL 8 DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE OIL PRESSURE (EOP) SENSOR (LOWER LEFT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 1 FUEL HEATER FUEL INJECTOR 1 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 6 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 7 (ON RIGHT SIDE OF ENGINE) FUEL PRESSURE REGULATOR 1 FUEL PRESSURE REGULATOR 2 GND SOL HIGH SIG GRY WIRE LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PPL PPL/ WHT WIRE PPL/WHT WIRE SENS VOLT REF 5 VOLT REF SHEILD TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION SENSOR (ON TOP OF TURBOCHARGER) VALVE HIGH CTRL SOL SPLY VOLT VALVE LOW CTRL SOL LOW SIG LOW REF LOW REF VEHICLE SPD SIG WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE

2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BLU WIRE BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 (MIDDLE OF DIESEL PARTICULATE FILTER) EXHAUST TEMPERATURE SENSOR 4 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK 7 8 WIRE PNK WIRE PPL PPL 1 2 PPL 28 29 PPL PNK 24 25 WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM WHT LT BLU/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE