GMC Savana G2500 (1996-2013) dk blu Wiring diagrams

1 2 6 8 20 21 22 23 40 42 47 48 51 62 63 GND TCC PWM CTRL PC SOL HI CTRL AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE 6 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PC SOL LO CTRL PPL FRONT LOW SIG FRONT HIGH SIG PCM BATT FUSE 2 PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PRNDL INDICATOR RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TOW/ HAUL SWITCH TOW/HAUL INDICATOR TOW/HAUL SWITCH SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BREAKOUT) BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP (6.6L) FLOOR MIX BLEND DEF MAX A/C OFF A/C BI-LEV FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GND IGN GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL SWITCH ASSEMBLY LEFT REAR OF ENGINE) (4.3L: RIGHT REAR OF ENGINE) LOGIC 2 1 LT BLU WIRE LT GRN WIRE MAX A/C OFF A/C BI-LEV VENT MED OFF ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK PNK/BLK WIRE PPL PPL/WHT WIRE REAR REAR AUXILIARY HVAC CONTROL ASSEMBLY REAR BLWR FUSE 29 RED WIRE RED/BLK WIRE RED/WHT WIRE RR AUX BLWR MTR CTRL SW FRT AUX BLWR MTR SPLICE BLOCK TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VENT FLOOR DEF MIX BLEND W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS W/ RV UPFITTER W/O RV (ATTACHED TO LOWER RIGHT "B" PILLAR PART OF UPFITTER W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL WIRE

2501 2500 2501 2500 COMPUTER DATA LINES SYSTEM A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR (ON AUXILIARY HVAC ASSEMBLY) AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (ON AUXILIARY AUXILIARY HVAC MODULE) AUXILIARY MODE DOOR ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BLOWER MOTOR BREAKOUT) BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HEATER MOTOR HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 24 40 58 4 21 22 SENS SIG LOW REF 59 36 63 66 46 25 8 65 43 44 12 13 34 28 27 PRESS SENS LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY 40 A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/ AUXILIARY FUEL FIRED HEATER WHT/BLK WIRE YEL WIRE

397 552 5929 CRUISE CONTROL SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE) COOLANT LEV SIG HI IDLE SW COOLANT LEVEL SWITCH CRUISE CONTROL SYSTEM CRUISE ON LOW REF LOW REF CRUISE SET DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EGR VAL POS SIG ECT SENSOR SIG ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) ENGINE OIL LEVEL SWITCH (LEFT SIDE OF OIL PAN) FUEL PRESS INJ + GROUP 2 GRY WIRE GRY/BLK WIRE IAT SENSOR 2 SIG IAT SENSOR SIG LOW REF LOW REF CMP SENSOR SIG LOW REF CRANK VOLT PPL LOW REF TUR VANE POS INJ + GROUP 3 INJ 5 INJ 4 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEVEL SW SIG CRUISE RESUME LOW REF OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE PARTIAL PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE STARTING/CHARGING SYSTEM TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE COMPUTER DATA LINES STSYEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUSIBLE LINK 1 GLOW PLUG 1 GLOW PLUG 2 GLOW PLUG 3 GLOW PLUG 4 GLOW PLUG 5 GLOW PLUG 6 GLOW PLUG 7 GLOW PLUG 8 GLOW PLUGS GMLAN DATA GRD GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH SIG IAH TEMP SIG IAH VOLT SIG IGN 0 IGN 1 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE WATER IN-FUEL SENSOR WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

8 9 10 11 12 PNK WIRE A/C REQ SIG A/C SYSTEM BLK WIRE BRN WIRE CKP SENSOR SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM/TCM GLOW PLUG CNTRL MDL IGN 1 FUSE 38 ENG 1 FUSE 23 ENGINE CONTROL MODULE (ECM) FRP SENSOR SIG FUSIBLE LINK 4 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN, START IGN 0 FUSE 6 IGN 1 IGN E FUSE 22 INJ 1 INJ 2 INTAKE AIR TEMPERATURE (IAT) SENSOR 2 (AT FRONT OF TURBOCHARGER) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK 22 23 24 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 25 26 27 28 29 30 PPL/WHT WIRE RED WIRE RED/WHT WIRE STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/WHT WIRE TUR VAN POS UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

8 9 10 11 12 PNK WIRE BLK WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE E.C.M. FUSE 33 ECM ACT FUSE 63 ECM RELAY 62 FOH/ECM TCM BATT FUSE 2 FUEL HEATER FUEL HTR FUSE 25 FUEL INJECTORS FUEL PMP FUSE 12 FUEL PMP RELAY 57 FUEL RAIL PRESSURE (FRP) SENSOR (ON TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK 22 23 24 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 20 21 PPL 25 26 27 28 29 30 PPL/WHT WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRK FUSE 11 BRN WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DK BLU WIRE DK GRN WIRE FUEL PUMP (LEFT CENTER INNER FRAME RAIL) GRY WIRE GRY/BLK WIRE HIGH IDLE SWITCH HOT IN LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (ATTACHED TO INTAKE MANIFOLD TUBE) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL 11 12 PPL 20 21 PPL/WHT WIRE RED WIRE RED/WHT WIRE RUN WIRE TAN WIRE TURBOCHANGER VANE POSITION SENSOR (TOP OF TURBOCHARGER) WHT/BLK WIRE YEL WIRE

1020 2500 COMPUTER DATA LINES SYSTEM 23 1786 1320 6863 STARTING/ CHARGING SYSTEM EXTERIOR LIGHTS SYSTEM 2501 2221 COMPUTER DATA LINES SYSTEM A/C SYSTEM STARTING/ CHARGING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM RELAY ENGINE CONTROL MODULE (ECM) FUEL LEVEL SENSOR (ON LEFT FRAME RAIL) FUEL PUMP FUEL RAIL TEMPERATURE (FRT) SENSOR (TOP LEFT SIDE OF ENGINE) GENERATOR SIG PARK/NEUTRAL SIG CHMSL + LOW REF GMLAN DATA (-) HI REAR SIG GRY WIRE HOT AT ALL TIMES IND INSTRUMENT PANEL CLUSTER IPC FUSE 31 LOW REF MIL CONTROL A/C COMPRESS START ENABLE EGR MOTOR HIGH LOW REF LT BLU WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK IGN 0 + GMLAN DATA (+) WIRE PNK PPL IGN 1 + TCC BRAKE SIG CHARGE IND GENERATOR 2 SIG A/C LO PRESS SW WIRE PNK WIRE PPL PPL 11 12 PPL FUEL LEV SEN SIG RED/WHT WIRE STARTING/ CHARGING SYSTEM A/C SYSTEM 7076 603 TAN WIRE TAN/WHT WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SIG WAIT TO WAIT TO START HI IDLE IND WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE