GMC Savana Camper Special G3500 (1996-2011) hot at all times Wiring diagrams

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

40 21 STOPLAMP SW INPUT IGNITION 44 57 22 54 2 4 6 HI SPD GMLAN + HI SPD GMLAN - TCC BRK SW VSS 61 34 10 CRUISE ON INPUT SET/COAST SIG RESUME/ACCEL SIG ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE ECM/TCM GLO PLUG MDL FUSE 38 ENGINE CONTROL MODULE (ECM) FOH/ECM TCM BATT FUSE 2 GROUND GROUND GROUND 1551 1551 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PNK WIRE PPL PPL 420 1827 PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

+BC BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) CLASS 2 SERIAL DATA COMPOSITE SEALED COMPOSITE+ DIMMER SWITCH SIGNAL DK GRN WIRE FLASH TO PASS SIGNAL FTP FUSIBLE LINK 2 GRY WIRE HDLP- HI BEAM RELAY HDLP- LO BEAM RELAY HEAD HEADLAMP DIMMER SWITCH HEADLAMP ON IND HEADLAMP ON SIGNAL HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HIGH BEAM RELAY CONTROL HOT AT ALL TIMES IGN CLASS 2 INSTRUMENT PANEL CLUSTER LED DIMMING SIGNAL LEFT HI BEAM FUSE 44 LEFT HIGH BEAM HEADLAMP LEFT HEADLAMP LEFT LO BEAM FUSE 43 LEFT LOW BEAM HEADLAMP LOGIC CLASS 2 SERIAL DATA LOW BEAM RELAY CONTROL LT GRN WIRE OFF PARK PNK HEADLAMP ON IND CONTROL WIRE PNK WIRE PNK/WHT WIRE PPL/WHT WIRE RED WIRE RIGHT HEADLAMP RIGHT HI BEAM FUSE 45 RIGHT HIGH BEAM HEADLAMP RIGHT LO BEAM FUSE 42 RIGHT LOW BEAM HEADLAMP SEALED SPLICE PACK TAN WIRE TAN/WHT WIRE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

ANTENNA IN 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DK BLU WIRE DK GRN WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LO GMLAN SERIAL DATA LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT GRN WIRE MUTE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE VOL DOWN VOL UP WHT WIRE YEL WIRE

22 23 PNK WIRE 2755 1551 1670 1666 1551 1668 1665 1174 LOW REF GND 625 1551 START RLY CTRL GND 771 420 776 PRND A SIG STP LP SW SIG PRND P SIG PPL 772 633 410 1020 PRND B SIG CMP SIG ECT SIG IGN 0 VOLT INJ 5 CTRL INJ 8 CTRL ABS SYSTEM B+ CLASS 2 DATA BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENG 1 FUSE 23 ENG 2 FUSE 21 FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) FUSE 39 FUSE 40 GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE INJ 1 CTRL INJ 6 CTRL INJ 3 CTRL INJ 2 CTRL INJ 7 CTRL INJ 4 CTRL INJECTORS KS 1 SIGNAL KS 2 SIG CKP SIG REQ TORQ SIG UART SER DATA UART SER DATA LOW REF LOW REF GND 1551 1671 1667 1551 1669 1664 LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCM BATT FUSE 2 PNK 1 2 3 4 5 WIRE PNK PNK 28 29 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL PPL PPL/WHT WIRE RANGE B RANGE C IGN 1 VOLT B+ LOW REF RED/WHT WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) W/ ACTIVE BRAKE CONTROL WHT WIRE YEL WIRE YEL/BLK WIRE

13 14 PNK WIRE 15 16 17 18 19 20 21 22 PPL 22 23 PNK WIRE 5.3L W/ CA EMISSONS OTHER BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP FUSE 12 FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GAS PASS/CARGO HEAVY DUTY (W/O HD TRUCK TRAILER WIRING) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (BELOW FRONT OF INTAKE MANIFOLD) KNOCK SENSOR 2 (BELOW REAR OF INTAKE MANIFOLD) LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OTHER PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 4 5 WIRE PNK PNK 28 29 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

16 17 18 19 20 21 22 23 PPL 21 22 23 24 25 27 26 28 PPL 24 25 26 PNK WIRE 29 30 31 PNK WIRE AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE CAN VENT FUSE 34 CHMSL VLT CRUISE CONTROL SYSTEM CRUISE ON SW DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IGN IGN 1 VLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 3 4 5 6 WIRE PNK 7 8 WIRE PNK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE RES/ACCEL SET/COAST SIDE OF TRANSMISSION) SIGNAL TAC MTR CNTL TAC MTR CNTL 1 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR 1 THROTTLE POSITION SENSOR 2 TPS 1 SIG TPS 2 SIG UART SER DATA UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 PNK WIRE 22 23 24 25 26 PPL BATT POS VOLT BLK WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CKP SENSOR SIG CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EGR 2 SPLY VOLT EGT SENSOR SIG ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FRP SENSOR SIG FUEL INJ 1 CTRL FUEL INJ 2 CTRL FUSIBLE LINK 1 FUSIBLE LINK 4 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IGN VOLT INTAKE AIR VALVE (ATTACHED TO LEFT SIDE OF INTAKE HOUSING) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 8 9 10 11 12 13 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 22 23 24 PPL/WHT WIRE RED WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE TCC BRAKE SIG TP SENS 1 SIG WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/ WHT WIRE DK GRN/WHT WIRE ECM BATT FUSE 54 ECM IGN FUSE 48 ECM PWR/ TRN FUSE 50 ECM PWR/ TRN FUSE 65 FUEL HEATER FUEL HTR FUSE 4 GLOW PLUG MDL FUSE FUEL PUMP FUSE 2 FUEL PUMP RELAY 72 FUEL RAIL PRESSURE (FRP) SENSOR (ON TOP REAR OF ENGINE) GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE MAF/ CNSTR VENT FUSE 49 NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK PNK 1 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 22 23 24 PWR/ TRN RELAY 76 RED WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE