GMC Rally G3500 (1985-1996) solid state Wiring diagrams

1995 VFTC BLK WIRE BLU WIRE BUS BAR GROUND FUSE BLOCK INSTR LPS FUSE GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN START OR RUN HOT WITH HEADLIGHT SWITCH IN PARK OR HEADLIGHT LEFT DEFOGGER GRID OFF ON INDICATOR ORG/ WIRE PANEL LAMPS PNK LT WIRE PNK WIRE PPL PPL/WHT WIRE PWR/ACC CIRCUIT BREAKER REAR DEFOGGER SWITCH RIGHT DEFOGGER GRID SOLID STATE TIMER RELAY (ON BRAKE PEDAL SUPPORT BRACKET) WHT WIRE

AIR BAG IND ANTI-LOCK BRAKES SYSTEM ENGINE CONTROLS SYSTEM ANTI-LOCK BRAKES WARNING IND BAT IND BLK WIRE BLK/WHT WIRE BRAKE IND IN PARK BRAKE IN BRAKE PRESSURE DIFFERENTIAL SWITCH (PART OF ELECTRONIC BRAKE CONTROL MODULE) BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER DIESEL ONLY EXTERIOR LIGHTS SYSTEM DIODE DIODE-I DK BLU WIRE DK GRN WIRE DRL LAMP IND (W/ DRL) FUEL GAUGE GAUGES FUSE 4 GRY WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUMIN- ATION LAMPS INSTRUMENT CLUSTER LEFT TURN IND LOCK LOW COOLANT IND. (DIESEL) LOW ENGINE COOLANT LEVEL INDICATOR MODULE (DIESEL ONLY) (LEFT SIDE OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF OIL PRESS GAUGE PARK/NEUTRAL POSITION, BACKUP LAMP SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 WIRE PNK IGN FEED IND CTRL GND WIRE PNK WIRE PPL PPL/WHT WIRE PRNDL CIRCUIT BOARD RIGHT TURN IND RUN WIRE SAFETY BELT IND SERVICE ENGINE SOON IND SERVICE THROTTLE SOON IND (DIESEL) SOLID STATE SPEEDOMETER/ ODOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/WHT WIRE TEMP GAUGE UNDERHOOD FUSE-RELAY CENTER (LEFT FENDER) UNDERHOOD FUSE-RELAY CENTER (LEFT FENDER) ENG-I MINI FUSE VOLT- METER W/ DRL W/ DRL ONLY W/O DRL W/O DRL W/ DRL WAIT IND (DIESEL) WARNING SYSTEM ENGINE CONTROLS SYSTEM DIESEL ONLY WATER IN FUEL IND. (DIESEL) WATER-IN-FUEL SENSOR (DIESEL ONLY) (REAR OF INTAKE MANIFOLD) WHT (OR LT GRN) WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BRN WIRE DK GRN WIRE FRONT DOME LAMP FUSE BLOCK- I/P FUSE BLOCK: I/P INSTR LPS FUSE GRY WIRE HEAD- LIGHT SWITCH DOME SWITCH HEADLIGHT SWITCH HIGH DIM HORN/DM FUSE HOT AT ALL TIMES I/P DIMMER SWITCH INSTRUMENT CLUSTER LEFT DOOR JAMB SWITCH LIGHT SWITCH OFF HEAD PARK ORG/ WIRE PROVISIONS FOR REAR DOME LAMP RADIO SOLID STATE TAIL LPS FUSE TRANS- MISSION RANGE INDICATOR LAMP HEATER CONTROL LAMP WHT WIRE

1995 VFTC BLK WIRE FUSE 19 HOT AT ALL TIMES I/P FUSE BLOCK ORG/ WIRE PNK WIRE POWER ANTENNA ASSEMBLY RADIO SOLID STATE

1995 VFTC BLK WIRE BRN WIRE FUSE BLOCK HI MIST LO HOT IN ACC OR RUN MIST HI MIST OFF OFF 6 8 0 3 0 6 8 OFF LO PULSE PULSE 6 8 0 OFF ON 4 3 0 5 0 PPL PPL WINDSHIELD WASHER/ WIPER SWITCH RED WIRE SOLID STATE WASHER SWITCH WINDSHIELD WASHER PUMP MOTOR (ENGINE COMPT, IN COWL) WINDSHIELD WIPER MOTOR WIPER FUSE 11 WIPER SWITCH YEL WIRE

A/C COMPRESSOR CLUTCH RELAY BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (PART OF DISTRIBUTOR, TOP REAR OF ENGINE) COIL DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE DK PNK WIRE EGR SOL OUTPUT SIGNAL SIGNAL SIGNAL SIGNAL FUEL INJ OUT NO.1 SHIFT SOL B OUTPUT GRN WIRE GRY WIRE KNOCK SENS SIGNAL KNOCK SENSOR (TOP REAR OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT LT LT PPL MAP SENS SIGNAL SIGNAL SENSOR SIGNAL SENSOR SIGNAL 472 410 NCA WIRE PNK 12 13 14 15 16 WIRE PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL PPL PPL RETURN RETURN SIGNAL SIGNAL PPL/WHT WIRE RED/BLK WIRE RETURN RETURN RETURN RETURN RETURN SHIFT SOL A OUTPUT TCC SOL OUTPUT SIGNAL IGNITION FUEL INJ OUT NO.8 PNK WIRE SOLENOID OUTPUT SHIFT SOLENOID OUTPUT SOLID STATE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL OUTPUT UNDERHOOD FUSE-RELAY CENTER VEHICLE CONTROL MODULE (ENGINE COMPARTMENT, LEFT FENDER) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VSS SIGNAL WHT WIRE YEL WIRE YEL/BLK WIRE

19 20 PNK WIRE 5-VOLT REFERENCE 999 999 SERVICE CIRCUIT POWER SERVICE CIRCUIT POWER A/C SIGNAL A/T INPUT SPEED SENSOR BATTERY BATTERY PRESSURE SW SIGNAL PRESSURE SW SIGNAL BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CRUISE CONTROL MODULE (FRONT OF ENGINE COMPARTMENT NEAR LEFT FENDER) CRUISE CTRL SIG-ENG CYL. NO.1 CYL. NO.8 CYL. NO.2 CYL. NO.4 CYL. NO.5 CYL. NO.3 CYL. NO.6 CYL. NO.7 DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT FRAME RAIL NEAR CENTER OF VEHICLE) FORCE MOTOR FEED RETURN SIGNAL ELEC SPARK TIMING FUEL PUMP RLY FEED 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 GRY WIRE GVW OVER 8500 LBS. GVW UNDER 8500 LBS HIGH VOLTAGE COIL WIRE HOT IN RUN I/P FUSE BLOCK IGNITION IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION COIL DRIVER (TOP RIGHT SIDE OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PNK IGNITION WIRE PNK PNK 1 2 3 4 5 6 7 8 9 10 11 WIRE PNK WIRE PPL PPL 420 PPL PPL PPL PPL 420 1807 BRAKE SWITCH INPUT SERIAL DATA PRESSURE SW SIGNAL 5 VOLTS REFERENCE RADIO RED WIRE RED/BLK WIRE SENSOR GROUND SERIAL DATA SIGNAL FORCE MOTOR RETURN GROUND GROUND SENSOR GROUND SOLID STATE SPARK PLUGS SPEED SENSOR INPUT VCM SIGNAL STOPLAMP SWITCH INPUT TAN/WHT WIRE TCC SIGNAL TRANSMISSION ONLY) (LEFT SIDE OF TRANSMISSION) VEHICLE CONTROL MODULE (ENGINE COMPARTMENT, LEFT FENDER) VSS SIGNAL VSS SIGNAL OUTPUT VSS SIGNAL OUTPUT MAL FUNC LP OUTPUT 389 419 WHT WIRE WHT/BLK WIRE

1226 1225 RANGE MODE SEL C RANGE MODE SEL B RANGE MODE SEL A 27 28 29 30 31 PPL 3/2 SHIFT SOL. FORCE MOTOR 7 8 9 10 12 13 14 15 VSS RTN GROUND A/C SYSTEM A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION NEAR FRONT) ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK PNK/ PNK WIRE ECT TEMP SENS IN GRN WIRE GRY WIRE GRY/BLK WIRE HEAVY DUTY ELECTRONIC 4-SPD AUTOMATIC OVERDRIVE TRANSMISSION INTAKE MAN AIR TEMP SENS TPS NO.2 SIG GLOW PLUG RELAY FORCE MTR LOW LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS INPUT FORCE MTR HI ORG/ WIRE ORG/BLK WIRE PCS LOW PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P, ABOVE BLOWER MOTOR) PPL PPL BRAKE SW IN BRAKE SWITCH INPUT CRUISE CTRL SW ENGAGE PPL SENSOR RETURN A/C REQUEST SIG PPL/WHT WIRE RADIO RED WIRE RED/BLK WIRE RESUME SENSOR GND SET- SHIFT SOL. SHIFT SOL. RANGE MODE SELECTOR SOLID STATE TAN WIRE TAN/BLK WIRE TIMING STEPPER MTR (LOW) TIMING STEPPER MTR (LOW) TRANSMISSION SPEED INPUT TRANSMISSION TEMP INPUT TRANSMISSION TEMPERATURE SENSOR VEHICLE SPEED SENSOR (ON TRANSMISSION, LEFT REAR SIDE) VEHICLE SPEED SENSOR BUFFER (BELOW LEFT SIDE OF I/P) VSS SIG VSS SIG VSS HI VSS LO SECOND VSS SIG WHT WIRE YEL WIRE YEL/BLK WIRE