GMC Forward Control P3500 (1985-1999) trans fuse 17 Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS HI IN A/T ISS LO IN A/T OUTPUT SPEED SENSOR ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE BUSS BAR GAUGES FUSE 8 DATA CLASS II DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS TEMP SIG IN TWISTED WIRE PAIR VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS HI IN A/T ISS LO IN A/T OUTPUT SPEED SENSOR ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE BUSS BAR GAUGES FUSE 8 DATA CLASS II DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS TEMP SIG IN TWISTED WIRE PAIR VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS HI IN A/T ISS LO IN A/T OUTPUT SPEED SENSOR ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE BUSS BAR GAUGES FUSE 8 DATA CLASS II DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS TEMP SIG IN TWISTED WIRE PAIR VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

4.3L A/T ACC BUS AUTOMATIC TRANSMISSION AUXILIARY ENGINE COOLANT FAN RELAY BRN WIRE CAMSHAFT POSITION SENSOR (5.7L) CLUTCH PEDAL POSITION SWITCH COLD ADVANCE SOLENOID AND ENGINE COOLANT TEMPERATURE SWITCH FUEL HEATER CRANK FUSE 18 CRK (START) LOCK ON (RUN) OFF CRK (START) ON (RUN) LOCK OFF CRK (START) ON (RUN) OFF DIESEL DK BLU WIRE ENG 1 FUSE 15 ENGINE SHUT-OFF SOLENOID FUEL SOLENOID DRIVER EVAP CANISTER VENT VALVE (4.3L) EVAPORATIVE EMISSIONS CANISTER PURGE VALVE FROM FUSIBLE LINK GAS GLOW PLUG CONTROLLER HEATED OXYGEN SENSOR BANK 1 SENSOR 1 CAMSHAFT POSITION SENSOR (4.3L) HEATED OXYGEN SENSOR BANK 2 SENSOR 1 HEATED OXYGEN SENSOR BANK 1 SENSOR 2 HEATED OXYGEN SENSOR BANK 2 SENSOR 2 IGNITION SWITCH IN-LINE FUSE BLOCK (NEAR RIGHT SIDE OF STEERING COLUMN) LOCK M/T MASS AIR FLOW SENSOR (4.3L/ 5.7L) ORG/ WIRE PARK/NEUTRAL POSITION AND BACKUP LAMPS SWITCH PNK PNK WIRE PNK WIRE PROVISIONS FOR WINDSHIELD WASHER MOTOR RADIO FUSE 4 RED WIRE TO I/P FUSE BLOCK (DIAGRAM 4 OF 4) TRANS FUSE 17 WATER IN FUEL INDICATOR SENSOR WHT WIRE WINDSHIELD WIPER/ WASHER SWITCH WIPER FUSE 14 YEL WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK GRN/WHT WIRE ECM 2 FUSE 12 ENG 1 FUSE 15 FUEL INJECTOR NO.2 FUEL INJECTOR NO.1 FUEL INJECTOR NO.3 FUEL INJECTOR NO.4 FUEL INJECTOR NO.5 FUEL INJECTOR NO.6 GRY WIRE HEATED OXYGEN SENSOR, BANK 1 SENSOR 2 (EXHAUST PIPE BEHIND CATALYTIC CONVERTER) HOT IN RUN, START I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK PNK 3 4 5 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK PPL 1 2 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE REV TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANS FUSE 17 TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG-B FUSE 10 ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) FROM ECT SENSOR BREAKOUT) FROM MAF SENSOR BREAKOUT) FROM TP SENSOR BREAKOUT) FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (IN FRESH AIR INTAKE, BEHIND AIR FILTER BOX) LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT REAR OF ENGINE) MAP MASS AIR FLOW (MAF) SENSOR (IN FRESH AIR INTAKE BEHIND AIR FILTER BOX) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 10 11 12 13 14 15 16 17 WIRE PNK 5 6 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK WIRE PNK WIRE PPL PPL 1 2 PPL 8 9 RED WIRE RED/BLK WIRE REF LO REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (THROTTLE BODY, TOP OF ENGINE) SERVICE ENGINE SOON INDICATOR SPEEDO- METER TACHO- METER TAN WIRE TRANS FUSE 17 WHT WIRE YEL WIRE

5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ENGINE SHUTOFF SOLENOID FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (TOP LEFT OF ENGINE) GRN WIRE GRY WIRE HAZARD FLASHER (INNER LEFT SIDE OF MAIN SUPPORT BRACKET) HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN AND START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL PPL 28 29 30 31 32 PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP-HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TCC/ STOPLAMP SWITCH (AT REAR OF BRAKE PEDAL SUPPORT BRACKET) TRANS FUSE 17 WHT WIRE YEL WIRE YEL/BLK WIRE

27 28 29 30 31 PPL 5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BLU WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG 1 FUSE 15 ENGINE SHUT-OFF SOLENOID (AT FUEL INJECTION PUMP) FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (ON SIDE OF FUEL INJECTION PUMP) GRN WIRE GRY WIRE HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE LT PPL OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP ASSEMBLY) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE PPL PPL (ENG HARN, APPROX 32 CM FROM BREAKOUT FOR BATTERY JUNCTION BLOCK) PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP/HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC), STOPLAMPS SWITCH (AT BRAKE PEDAL SUPPORT) TRANS FUSE 17 WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

"WAIT TO START" GLOW PLUGS 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T AUTOMATIC TRANSMISSION (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK GRN WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 FUEL INJECTION PUMP SHUT-OFF SOLENOID (AT FUEL INJECTION PUMP) FUEL LIFT PUMP (ON INSIDE RIGHT FRAME RAIL) FUEL PUMP RELAY (ON ENGINE FIREWALL BRACKET, UNDER BATTERY JUNCTION BLOCK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE M/T NCA WIRE ORN/ PNK 3 4 5 6 7 8 WIRE PNK WIRE PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE SERVICE TRANS SPEEDO- METER TCC PWM SOLENOID TRANS FUSE 17 TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WATER IN FUEL WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD RELAYS) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) FUEL GAUGE FUEL PUMP AND FUEL TANK SENDER (ON TOP OF FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH (ON TOP LEFT REAR OF ENGINE) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP CENTER FRONT OF ENGINE) MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE COMP, ON AIR INTAKE ASSEMBLY) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 22 23 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE RED WIRE RED/BLK WIRE SPEED METER TACH TAN WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY, TOP OF ENGINE) TRANS FUSE 17 WHT WIRE YEL WIRE