GMC Forward Control P3500 (1985-1999) eng 1 fuse 15 Wiring diagrams

AUXILIARY ENGINE COOLING FAN (MOUNTED ON FRONT OF RADIATOR) BLK WIRE BLU WIRE DK BLU WIRE ENG 1 FUSE 15 FAN CONTROL RELAY (ON TOP OF STEERING COLUMN SUPPORT, BEHIND STEERING COLUMN) FUSIBLE LINK (18 GA- HOT AT ALL TIMES HOT IN RUN, START I/P FUSE BLOCK (BODY BUILDER INSTALLED) (BEHIND DASH PANEL) PNK WIRE RED WIRE

AUXILIARY ENGINE COOLANT FAN (MOUNTED ON FRONT OF RADIATOR) BLK WIRE DK BLU WIRE ENG 1 FUSE 15 FUSIBLE LINK HOT AT ALL TIMES HOT IN RUN, START I/P FUSE BLOCK (BODY BUILDER INSTALLED) (BEHIND DASH PANEL) PNK WIRE RED WIRE

ABS IND. ACCY ACCY ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (INTERNAL TO ELECTRONIC BRAKE CONROL MODULE) BRN/WHT WIRE CHECK GAUGES IND COOLANT TEMPERATURE GAUGE DIESEL DIODE NETWORK (DASH HARN, DK BLU WIRE DK GRN WIRE DOOR AJAR IND DRL IND ECM 1 FUSE 12 ELECTRONIC BRAKE CONTROL MODULE (EBCM) (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG 1 FUSE 15 ENGINE CONTROLS OR STARTING/CHARGING SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM TRANSMISSIONS SYSTEM ENGINE COOLANT LEVEL SWITCH (ON LOWER LEFT END OF RADIATOR SURGE TANK) FOOT BRAKE (PARK BRAKE APPLY OPPTION) FUEL GAUGE FUEL SENDER (ON TOP OF FUEL TANK) GAS GAUGES FUSE 8 GRY WIRE GRY/BLK WIRE HAND BRAKE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START I/P FUSE BLOCK I/P FUSE BLOCK (BODY BUILDER INSTALLED) I/P FUSE BLOCK) INSTRUMENT CLUSTER IGNITION SWITCH ILLUMINATION IN-LINE CONNECTOR PROVISIONS FOR BODY BUILDER INTERIOR LIGHTS SYSTEM WARNING SYSTEMS LEFT TURN IND LOCK LOCK OFF OFF LOW COOLANT IND LT BLU WIRE LT BLU/BLK WIRE LT GRN (OR WHT) WIRE LT GRN WIRE MALFUNCTION IND (MIL) (SERVICE ENGINE SOON IND) NCA WIRE OIL PRESSURE GAUGE PNK 4 13 WIRE PNK WIRE PPL PPL DIESEL PPL GAS PPL RIGHT TURN IND RUN WIRE SEAT BELT IND SERVICE THROTTLE SOON IND SPEEDOMETER TACHOMETER TAN WIRE TAN/WHT WIRE TRANS IND. VEHICLE CONTROL MODULE (ON LEFT SIDE OF RADIATOR SUPPORT) VOLTMETER VSS CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND, UNDER RELAY BRACKET) W/ DRL W/O DRL WAIT TO START IND WATER IN FUEL IND WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.3L A/T ACC BUS AUTOMATIC TRANSMISSION AUXILIARY ENGINE COOLANT FAN RELAY BRN WIRE CAMSHAFT POSITION SENSOR (5.7L) CLUTCH PEDAL POSITION SWITCH COLD ADVANCE SOLENOID AND ENGINE COOLANT TEMPERATURE SWITCH FUEL HEATER CRANK FUSE 18 CRK (START) LOCK ON (RUN) OFF CRK (START) ON (RUN) LOCK OFF CRK (START) ON (RUN) OFF DIESEL DK BLU WIRE ENG 1 FUSE 15 ENGINE SHUT-OFF SOLENOID FUEL SOLENOID DRIVER EVAP CANISTER VENT VALVE (4.3L) EVAPORATIVE EMISSIONS CANISTER PURGE VALVE FROM FUSIBLE LINK GAS GLOW PLUG CONTROLLER HEATED OXYGEN SENSOR BANK 1 SENSOR 1 CAMSHAFT POSITION SENSOR (4.3L) HEATED OXYGEN SENSOR BANK 2 SENSOR 1 HEATED OXYGEN SENSOR BANK 1 SENSOR 2 HEATED OXYGEN SENSOR BANK 2 SENSOR 2 IGNITION SWITCH IN-LINE FUSE BLOCK (NEAR RIGHT SIDE OF STEERING COLUMN) LOCK M/T MASS AIR FLOW SENSOR (4.3L/ 5.7L) ORG/ WIRE PARK/NEUTRAL POSITION AND BACKUP LAMPS SWITCH PNK PNK WIRE PNK WIRE PROVISIONS FOR WINDSHIELD WASHER MOTOR RADIO FUSE 4 RED WIRE TO I/P FUSE BLOCK (DIAGRAM 4 OF 4) TRANS FUSE 17 WATER IN FUEL INDICATOR SENSOR WHT WIRE WINDSHIELD WIPER/ WASHER SWITCH WIPER FUSE 14 YEL WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK GRN/WHT WIRE ECM 2 FUSE 12 ENG 1 FUSE 15 FUEL INJECTOR NO.2 FUEL INJECTOR NO.1 FUEL INJECTOR NO.3 FUEL INJECTOR NO.4 FUEL INJECTOR NO.5 FUEL INJECTOR NO.6 GRY WIRE HEATED OXYGEN SENSOR, BANK 1 SENSOR 2 (EXHAUST PIPE BEHIND CATALYTIC CONVERTER) HOT IN RUN, START I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK PNK 3 4 5 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK PPL 1 2 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE REV TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANS FUSE 17 TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 15 16 17 PPL PPL 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ENG 1 FUSE 15 FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 GRY WIRE HOT IN RUN, START I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 5 6 WIRE PNK PNK 30 31 WIRE PNK PNK PNK 1 2 3 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 8 9 10 11 12 13 14 15 16 17 PPL/ WHT WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE REV TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT WIRE YEL WIRE YEL/BLK WIRE

"SERV THROTTLE SOON" IND 18 19 PNK WIRE A/C ENABLE GROUND GROUND 451 551 ANTILOCK BRAKES SYSTEM BATTERY BATTERY WASTEGATE SOL CTRL ESO SOLENOID CTLR BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENG 1 FUSE 15 ESO CTRL FUEL HEATER (TOP REAR OF ENGINE) FUEL INJECT CTRL FUSIBLE LINK FUSIBLE LINKS GLOW PLUG 1 GLOW PLUG 2 GLOW PLUG 3 GLOW PLUG 5 GLOW PLUG 7 GLOW PLUG 6 GLOW PLUG 4 GLOW PLUG 8 GLOW PLUG OUT GLOW PLUG RELAY (TOP REAR OF INTAKE MANIFOLD) GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK LT GRN WIRE NCA WIRE ORG/ WIRE PNK IGNITION WIRE PNK PNK 439 439 IGNITION IGNITION BATTERY MIL IND CTRL WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL RED WIRE RELAY CTRL WASTEGATE SOLENOID WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

27 28 29 30 31 PPL 5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BLU WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG 1 FUSE 15 ENGINE SHUT-OFF SOLENOID (AT FUEL INJECTION PUMP) FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (ON SIDE OF FUEL INJECTION PUMP) GRN WIRE GRY WIRE HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE LT PPL OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP ASSEMBLY) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE PPL PPL (ENG HARN, APPROX 32 CM FROM BREAKOUT FOR BATTERY JUNCTION BLOCK) PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP/HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC), STOPLAMPS SWITCH (AT BRAKE PEDAL SUPPORT) TRANS FUSE 17 WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T A/T M/T BATTERY FEED BATTERY JUNCTION BLOCK (ON LEFT REAR OF ENG COMPT) BLK WIRE BLU WIRE BRN WIRE CRANK FUSE (UPPER RIGHT SIDE OF STEERING COLUMN SUPPORT) DK BLU WIRE ENG 1 FUSE 15 FUEL HEATER (REAR OF INTAKE MANIFOLD, PART OF FUEL/ WATER SEPARATOR) FUEL INJECTION PUMP COLD ADVANCE SOLENOID (AT FUEL INJECTION PUMP) FUSIBLE LINK FUSIBLE LINK (12 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (22 GA-RUST) FUSIBLE LINKS GLOW PLUG CONTROLLER (LEFT REAR OF ENG, NEAR FIREWALL) GLOW PLUG CTRL GLOW PLUG OUT GROUND HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IDLE SPEED CONTROL ACTUATOR SOLENOID (ON BRACKET ON FRONT FUEL INJECTION PUMP) IGN FEED IND LAMP OUT GROUND IGNITION SWITCH LEFT BANK GLOW PLUGS LOCK OFF LT GRN/BLK WIRE NOT USED STARTER FEED ORG/ WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL PPL PPL S STUD RED WIRE RIGHT BANK GLOW PLUGS RUN WIRE STARTER RELAY (ON ENG FIREWALL RELAY BRACKET, UNDER BATTERY JUNCTION BLOCK) STARTER SOLENOID (ON STARTER, AT LOWER RIGHT SIDE OF ENGINE) STUD WATER IN FUEL INDICATOR SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 PPL AUTOMATIC TRANSMISSION BANK 1 SENSOR 1 (ON LEFT EXHAUST PIPE BEFORE CATALYTIC CONVERTER) BANK 1 SENSOR 2 (ON LEFT EXHAUST PIPE AFTER CATALYTIC CONVERTER) BANK 2 SENSOR 2 (ON RIGHT EXHAUST PIPE AFTER CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ENG 1 FUSE 15 EXHAUST GAS RECIRCULATION VALVE SOLENOID (LEFT SIDE OF INTAKE PLENUM) FLUID TEMPERATURE SENSOR (INTERNAL) FORCE MOTOR FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 5 FUEL INJ 4 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 GRN WIRE GRN/BLK WIRE GRY WIRE HEATED OXYGEN HOT IN RUN AND START I/P FUSE BLOCK IGNITION INTAKE AIR TEMP SENSOR (MOUNTED IN FRESH AIR INTAKE BEHIND AIR FILTER BOX) LT BLU/WHT WIRE LT GRN WIRE NCA WIRE PNK 8 9 10 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE PPL/ WHT WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE SOLENOID 1-2 SOLENOID 2-3 SWITCH PRESSURE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC SOLENOID WHT LT BLU/ WIRE WHT PPL/ WIRE WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE