GMC Cutaway G3500 (2012-2013) tan/blk Wiring diagrams

1 2 PNK IGN VOLT WIRE 149 (OR 690) AMBIENT LIGHT SENS SIG HDLP ON SIG ANTI-LOCK BRAKES SYSTEM EXTERIOR LIGHTS SYSTEM ANTI-THEFT SYSTEM INSTRUMENT CLUSTER SYSTEM BCM 7 FUSE 8 BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CHMSL CTRL COURTESY LAMP CTRL CRUISE CONTROL SYSTEM CRUISE CONTROL, SOUND SYSTEMS CRUISE CTRL SW SIG CURRENT SENS SIG LO REF IGN VOLT DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS, ANTI-THEFT SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS AIR CONDITIONING SYSTEM DRV DOOR LOCK SW UNLOCK SIG DRV DOOR LOCK SW LOCK SIG DRV DR LOCK RLY UNLOCK CTRL DRV DR LOCK RLY UNLOCK CTRL PASS DOOR LOCK SW LOCK CTRL GRY WIRE GRY/BLK WIRE HDLP LOW BEAM RLY CTRL PARK LAMP CTRL HDLP OFF SIG COURTESY LAMPS CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HORN RLY CTRL HORNS SYSTEM HOT AT ALL TIMES IGN VOLT BKUP LP SPLY VOLT HOOD CLD SW SIG PARK BRAKE SW SIG IGNITION SWITCH KEY-IN SWITCH LF DOOR OPEN SW SIG A/C REQUEST SIGNAL LF TURN SIG LAMP CTRL STOP LAMPS CTRL TCC BRAKE SIG LIFTGATE AJAR SW SIG LOW REF WIPER LOW SW SIG LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NAVIGATION SYSTEM OFF ORG/ WIRE ORG/BLK WIRE PARK LAMPS SIG PASS DOOR LOCK SW LOCK CTRL PNK 12 VOLT REF WIRE PNK IGN VOLT L TURN HAZ SW SIG R TURN HAZ SW SIG WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL DEFEAT SW SIG REAR ACCESS OPEN SW SIG RED/WHT WIRE RF DOOR AJAR SW SIG PASS DR LOCK SW UNLOCK CTRL LF DOOR AJAR SW SIG RR DOOR OPEN SW SIG LR DOOR OPEN SW SIG RF DOOR OPEN SW SIG RUN WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CTRL SW SIG BACKUP LAMP RLY CTRL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WIPER SW SIG 2 FRONT WIND WIPER SW HI SIG WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM SOUND SYSTEMS YEL WIRE YEL/BLK WIRE

2 3 11 13 DATA BUS (-) DATA BUS (+) 2 3 DATA BUS (+) DATA BUS (-) 2 3 SERIAL DATA SERIAL DATA 5 4 6 7 157 147 167 177 DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) 6 5 DATA BUS (-) DATA BUS (+) 6.6L 4.8L, 5.3L, 6.0L 4.3L 65 45 DATA BUS (+) DATA BUS (-) ACC WAKE-UP SERIAL DATA BLK/WHT WIRE CHIME MODULE (BEHIND LEFT CENTER OF DASH) CUTAWAY DATA DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DIGITAL RADIO RECEIVER (S-BAND DIGITAL AUDIO SYSTEM) (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT CLUSTER LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LT GRN WIRE LTR/DLC FUSE 73 NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) RADIO REAR PARKING ASSIST CONTROL MODULE (IF EQUIPPED) RED WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/O RADIO W/O W/ UYS UYS WHT WIRE

1 10 SERIAL DATA DATA BUS (+) 16 17 19 DATA BUS (-)) DATA BUS (+) DATA ENABLE 19 26 2501 2500 DATA BUS (-) DATA BUS (+) 2 12 DATA BUS + DATA BUS - 25 18 2500 2501 DATA BUS (+) DATA BUS (-) 37 24 3 13 DATA BUS (+) DATA BUS (-) 4.8L 4.3L, 6.0L, 5.3L 4.8L 6.0L 5.3L 9 8 10 DATA BUS (-) DATA BUS (+) SERIAL DATA ACC WAKE UP SERIAL DATA 11 15 19 7 6 38 37 ACC WAKE-UP SERIAL DATA AUTOMATIC TRANSMISSION (6 SPEED A/T) AUXILIARY HEATER) (ATTACHED TO LEFT INNER FRAME RAIL, NEAR FUEL PUMP ASSEMBLY) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER CONTROL SOLENOID VALUE ASSEMBLY COOLANT HEATER (6.6L W/ FUEL FIRED DATA BUS - DATA BUS - DATA BUS - DATA BUS+ DATA BUS+ DATA BUS- DATA BUS- DATA COMM ENABLE DATA ENABLE DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) DK BLU WIRE DK GRN WIRE EXCEPT 5.3L EXCEPT AUXILIARY 5.3L 5.3L HEATER IGN DATA BUS (+) DATA BUS (-) LT BLU WIRE TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) VEHICLE COMMUNICATION INTERFACE MODULE (VCM) (BELOW STEERING COLUMN) W/ ACTIVE BRAKE CONTROL W/ FUEL FIRED AUXILIARY HEATER W/ FUEL W/O FUEL FIRED FIRED AUXILIARY HEATER W/ VEHICLE COMMUNICATION SYSTEM W/O ACTIVE BRAKE CONTROL W/O FUEL FIRED AUXILIARY HEATER W/O VEHICLE COMMUNICATION SYSTEM

14 13 15 5 BRAKE LOW REF BRAKE SENS SIG 15 5 38 45 61 11 54 26 42 FUEL TEM SIG BRAKE APPLY SEN SIG LOW REF 43 44 28 27 SER DATA BUS(+) SER DATA BUS(-) 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL AUTOMATIC TRANSMISSION (6 SPEED A/T) AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR ASSEMBLY BATT + BCM 2 FUSE 58 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DATA BUS - DATA BUS + VSS LOW SIG VSS HIGH SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ENGINE CONTROL MODULE (ECM) GMLAN GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT STEERING WHEEL CONTROL SWITCH LOGIC LT BLU WIRE LT GRN/BLK WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SET- TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANS- MISSIONS SYSTEM TRANSMISSION CONTROL MODULE (4 SPEED A/T) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

5 6 7 8 PNK (OR PNK) WIRE 5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG COMP SENS SIG MAF SENS SIG LOW REF LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/BLK WIRE ORG/WHT WIRE PNK IGN VOLT WIRE PNK PPL 2 3 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL 13 14 15 16 PNK WIRE 13 14 PNK WIRE BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE LO REF BRAKE SENS SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK 15 16 17 WIRE PNK 17 18 19 20 21 22 23 24 25 26 27 28 29 30 WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 WIRE PNK PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BLU WIRE BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 (MIDDLE OF DIESEL PARTICULATE FILTER) EXHAUST TEMPERATURE SENSOR 4 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK 7 8 WIRE PNK WIRE PPL PPL 1 2 PPL 28 29 PPL PNK 24 25 WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM WHT LT BLU/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER DISPLAY GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT CLUSTER LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MIL SER CTRL DATA NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) ORG/BLK WIRE ORG/WHT WIRE PNK 10 11 WIRE PNK 12 13 14 WIRE PNK PNK 7 8 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 1 2 PPL 28 29 PPL PNK 24 25 WIRE PPL/WHT WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REDUCTANT TANK HEATER SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SENS 2 SPLY VOLT TAN WIRE TAN/BLK WIRE WAIT TO WHT/BLK WIRE YEL WIRE YEL/BLK WIRE