GMC Cab & Chassis Sierra 3500 (2004-2007) yel Wiring diagrams

40 12 17 MIL CONTROL SIGNAL HIGH - FRONT PTO STATUS 73 36 GROUND GROUND 9 18 15 2 1 GROUND IGNITION CLASS 2 SERIAL DATA CAN DATA LO CAN DATA HI ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CAN DATA LO DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (IN ENGINE HARNESS) EXCEPT SEO FUSE GRN DK WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PARK/NEUTRAL SIG PNK 1049 2362 2361 WIRE PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD VEHICLE SPEED SENSOR RED WIRE RED/BLK WIRE REV RUN WIRE SEO SIG HI-FRONT COMPUTER DATA LINES SYSTEM 2361 2470 CAN DATA HI CLASS 2 DATA SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TFT SENSOR TRIM SOLENOIDS TFT SIGNAL TOW/HAUL SWITCH (IF EQUIPPED) TRANS MIL REQUEST TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE CLUTCH CRANK FUSE CRANK VOLTAGE DK GRN WIRE IGN A FUSE IGN B FUSE IGN E FUSE IGNITION SWITCH LEFT BATTERY LOCK OFF NCA WIRE PARK/NEUTRAL POSITION SWITCH (A/T) (ON LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RED WIRE RED/WHT WIRE RIGHT BATTERY RUN WIRE STARTER MOTOR STARTER RELAY STARTER SOLENOID SWITCH (M/T) (ON TOP OF CLUTCH PEDAL BRACKET) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD JUNCTION BLOCK (AT LEFT SIDE OF ENG COMPT) YEL WIRE YEL/BLK WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

10 11 12 13 14 15 16 AUD OUT - DRAIN WIRE AUDIO AMPLIFIER BARE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COAX ANTENNA COMPUTER DATA LINES SYSTEM DIGITAL RADIO ANTENNA DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GROUND R SPK OUT+ GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) L SPK OUT- L SPK OUT+ LEFT FRONT DOOR SPEAKER LEFT FRONT TWEETER SPEAKER LEFT REAR SPEAKER (EXTENDED CAB) LEFT REAR DOOR SPEAKER (EXCEPT EXTENDED CAB) LF AUD + RT AUD + LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MIC SUP VOLT MIC SIG RF AUD SIG- LF AUD SIG- LF AUD SIG+ RF AUD SIG+ DRAIN WIRE NCA WIRE NOISE COMPENSATION MICROPHONE ORG/ WIRE ORG/BLK WIRE R SPK OUT- B+ RADIO AMP FUSE RIGHT FRONT DOOR SPEAKER RIGHT FRONT TWEETER SPEAKER RIGHT REAR SPEAKER (EXTENDED CAB) RIGHT REAR DOOR SPEAKER (EXCEPT EXTENDED CAB) SERIAL DATA SUBWOOFER SPEAKER TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) YEL WIRE

1362 (OR 353) 349 1834 2306 (OR 371) AIRBAG FUSE BLK WIRE BLK/WHT WIRE BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE EXCEPT 10 SERIES/ CREW CAB GROUND GRY WIRE HOT IN RUN OR START HVY I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) I/P RELAY BLOCK IGNITION 1 VOLTAGE INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INFLATABLE RESTRAINT STEERING WHEEL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL KEY SWITCH LEFT INFLATABLE RESTRAINT FRONT END SENSOR (ON LEFT FRONT OF VEHICLE) LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE OFF ORG/ WIRE OTHERS PNK WIRE PNK (OR TAN/BLK) WIRE PNK 1 2 3 4 5 6 7 WIRE PNK W/ FRONT PASSENGER/ CHILD PRESENCE DETECTOR WIRE PNK WIRE PPL PPL PPL RED (OR PNK) WIRE RED WIRE RIGHT FRONT OF VEHICLE BOTTOM OF RADIATOR SUPPORT) RIGHT INFLATABLE RESTRAINT SIDE IMPACT SENSOR RIGHT SIGNAL HIGH CONTROL LOW CONTROL GROUND LOW CONTROL HIGH CONTROL RIGHT VOLTAGE HIGH CONTROL LOW CONTROL LOW REFERENCE LOW CONTROL HIGH CONTROL SHORTING BAR SHORTING BAR SHORTING BAR SIGNAL SIGNAL LOW REFERENCE LOW REFERENCE STAGE 1 INFLATABLE RESTRAINT I/P MODULE (BEHIND RIGHT SIDE OF DASH) STAGE 2 TAN WIRE TAN/BLK WIRE TWISTED PAIR WIRES UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) W/ FRONT PASSENGER/ CHILD PRESENCE DETECTOR WHT WIRE YEL WIRE

AIR BAG BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA DATA LINK CONNECTOR (LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SEAT BELT SWITCH FRONT PASSENGER SEAT BELT SWITCH GRY WIRE I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN IGNITION 1 VOLTAGE INFLATABLE RESTRAINT PASSENGER AIR BAG ON/OFF INDICATOR INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM SENSOR INFLATABLE RESTRAINT PASSENGER SEAT BELT TENSION RETRACTOR SENSOR INSIDE REARVIEW MIRROR INSTRUMENT PANEL CLUSTER IPC CLASS 2 SERIAL DATA LEFT INFLATABLE RESTRAINT SEAT POSITION SWITCH LT BLU WIRE LT GRN WIRE MEMORY SYSTEM OFF PASS SEAT BELT TENS LO REF PPS SENS LO REF PASS SEAT BELT TENS SIG GROUND PPS SENS SIG PNK 1 2 3 4 5 6 7 WIRE PNK SERIAL DATA WIRE PPL RED WIRE RIGHT INFLATABLE RESTRAINT SEAT POSITION SWITCH SPLICE PACK TAN WIRE WHT WIRE YEL WIRE

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRAKE CONTROL BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FRONT PROPSHAFT SPEED SENSOR FUSE GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL FT SHAFT LO FT SHAFT HI PPL/WHT WIRE REAR PROPSHAFT SPEED SENSOR RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

ANL/DRL DEFEAT AUTO BATTERY BATTERY BATTERY BATTERY GROUND BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CREW CAB ONLY FUSE GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HEAD PARK HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ACC, RUN HOT IN ACC, RUN, START HOT IN RUN, START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGNITION KEY ALARM SWITCH LEFT REAR DOOR LATCH ASSEMBLY LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (PART OF PARK BRAKE ASSEMBLY) PARK LAMP ON SIGNAL GROUND DIMMING INPUT PNK WIRE POWER DISTRIBUTION SYSTEM RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW RIGHT REAR DOOR LATCH ASSEMBLY SERIAL DATA TAN WIRE TBC ACCY FUSE TBC BATT FUSE TBC IGN 0 FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

22 3 11 SERIAL DATA LEFT SEAT BELT LOW REFERENCE 22 3 18 SERIAL DATA LOW REFERENCE LEFT DOOR AJAR SW 22 5 20 SERIAL DATA DOOR AJAR SWITCH LOW REFERENCE BASE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER SEAT BELT SWITCH FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) IGN INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT TURN LOGIC LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK 1045 1044 WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) PPL PPL 1132 1036 1037 1047 1046 RADIO RIGHT TURN SEAT BELT SERIAL DATA SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE W/CONVENIENCE PACKAGE COMFORT, DECOR LEVEL 3 W/MEMORY SEATS WHT WIRE YEL WIRE

ACCESSORY VOLTAGE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CHECK WASHER FLUID DK BLU WIRE GROUND LSD HI LO HOT AT ALL TIMES HOT IN RUN AND ACC I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) INSTRUMENT PANEL CLUSTER LO OFF PULSE LOW WASHER FLUID IND SIG MESSAGE CENTER MIST HI MIST WASH OFF ORG/ WIRE PNK WIRE RED WIRE SERIAL DATA TAN WIRE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) W/S WASH FUSE W/S WASH RELAY W/S WIPER FUSE WASHER FLUID LEVEL SENSOR (IN WASHER FLUID RESERVOIR) (EXCEPT 4.3L BASE) WHT WIRE WINDSHIELD WASHER FLUID PUMP (ON WASHER FLUID RESERVOIR) WINDSHIELD WASHER RELAY CNTRL WINDSHIELD WASHER SWITCH SIGNAL WINDSHIELD WIPER HIGH SIGNAL WINDSHIELD WIPER MOTOR MODULE (UNDER WINDSHIELD COWL, BETWEEN WIPER ARMS) WINDSHIELD WIPER MOTOR PARK SIGNAL WINDSHIELD WIPER/ WASHER SWITCH YEL WIRE