GMC Cab & Chassis Sierra 3500 (2004-2007) transmissions system Wiring diagrams

40 33 (DIESEL) (GAS) ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (M/T) (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DEL TORQUE SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GASOLINE DIESEL GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE POWERTRAIN OR ENGINE CONTROL MODULE (PCM OR ECM) (ON LEFT FRONT OF ENG COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL IND (IF EQUIPPED) TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT OF ENG COMPT) TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRANSFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

61 33 (DIESEL) (GAS) 46 49 ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (M/T) (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DEL TORQUE SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE POWERTRAIN OR ENGINE CONTROL MODULE (PCM OR ECM) (ON LEFT FRONT OF ENG COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL IND (IF EQUIPPED) TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRANSFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

1056 1037 INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM 1796 245 254 1970 (BASE) (UPPER LEVEL) 2353 1382 4040 1732 230 2240 INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM 244 255 1391 193 (BASE) (UPPER LEVEL) (BASE) 5 VOLT REF CLASS 2 SERIAL DATA 812 1140 1969 1080 1353 ANTI-THEFT SYSTEM AIR CONDITIONING SYSTEM 1851 1059 2090 11 ANTI-THEFT SYSTEM INTERIOR LIGHTS SYSTEM HORNS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC POWER STEERING SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FUSE GRY WIRE GRY/BLK WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES I/P FUSE BLOCK I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PARK LAMP SW ON SIG PNK WIRE PNK/WHT WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE TAN/BLK WIRE TBC BATT FUSE TOW/HAUL SW SIG TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK UPPER LEVEL WHT WIRE YEL WIRE

1 2 PNK WIRE ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (MIDDLE OF RIGHT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) F/ PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (ON UNDERHOOD FUSE BLOCK BRACKET) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN PRIMARY FUEL TANK) GRY WIRE HOT AT ALL TIMES HOT IN RUN, START SBA FUSE INTERNAL MODE SWITCH KNOCK SENSOR (BANK 1) (LEFT SIDE OF ENGINE) KNOCK SENSOR BANK 2 (ON RIGHT SIDE OF ENGINE, FORWARD OF STARTER) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PCM B FUSE PNK PNK 2 3 WIRE PNK PNK 27 28 WIRE PNK PNK 4 5 6 7 8 9 10 11 12 13 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL 31 32 33 34 35 36 37 PPL/BLK WIRE PPL/WHT WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) WHT WIRE YEL WIRE

1 2 PNK WIRE BLK WIRE BLK/WHT WIRE BLUNT CUT BLUNT CUT BLUNT CUT) BRK FUSE CRUISE FUSE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (LEFT SIDE OF TIMING COVER) CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN GRY WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) FOG LP FUSE FUEL TANK PRESSURE SENSOR (ON FUEL TANK, INTEGRAL TO FUEL PUMP, SENDER ASSEMBLY) GRY LT GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IND LOGIC LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE, ON INTAKE MANIFOLD) OFF ON SET ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER TAKE OFF RELAY (NEAR UNDERHOOD FUSE BLOCK) POWER TAKE OFF SWITCH PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LP FUSE TAN WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION/ TRANSFER CASE) WHT WIRE YEL WIRE