GMC Cab & Chassis Sierra 3500 (2004-2007) red/blk Wiring diagrams

1 2 6 8 16 19 20 21 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRK FUSE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT SIDE OF LEFT CYLINDER HEAD) FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID TOW/HAUL SWITCH TRANSFER CASE CIRCUIT TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM 1 FUSE VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN AUTOMATIC TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT SIDE OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TCC PWM SOLENOID THROTTLE ACTUATOR CONTROL MODULE (LEFT REAR OF ENGINE COMPT) TOW/ HAUL TOW/HAUL SWITCH TRANSFER CASE CIRCUIT TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM 1 FUSE VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

A/T ISS SIG LOW VSS SIG LOW ALLISON TRANSMISSION AUTOMATIC TRANSMISSION SHIFT LEVER BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRNK FUSE DATA BUS H DATA BUS L DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SHIFT REQUEST SWITCH FLD PRESS SW SIG 4 TCC PCS LOW FLD PRESS SW SIG 2 TURB SPEED SW SIG FUSE GRD GRD B+ GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MOD MAIN NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK 6 7 8 WIRE PNK 9 10 11 WIRE PNK FLD PRESS SW SIG 1 VSS SIG HIGH WIRE PNK IGN 0 VOLT WIRE PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL CRANK VOLT PPL PPL PPL PPL 1 2 PPL/WHT WIRE PRESS CONTROL SOLE 2 PTO SIG RANGE SW SIG A MAIN PRESS SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERIAL DATA DATA BUS L STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/WHT WIRE TCC PSC TR SW SIG B TFT SENSOR SIG TR SW SIG C TR SW SIG P TRANSFER CASE CIRCUIT TURB SPEED SW UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) TCM B FUSE WHT WIRE YEL WIRE YEL/BLK WIRE

2 4 6 9 GROUND GROUND GROUND CLASS 2 SERIAL DATA 30 44 57 45 MIL CONTROL CAN DATA L CAN DATA H SIGNAL HIGH - FRONT 56 39 PNK IGNITION PARK/NEUTRAL SIG WIRE ALLISON TRANSMISSION AUTOMATIC TRANSMISSION INPUT SPEED SENSOR (IN AUTOMATIC TRANSMISSION) AUTOMATIC TRANSMISSION TURBINE SPEED SENSOR (IN UPPER LEFT OF TRANSMISSION) BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM FUSE GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) INTERNAL MODE SWITCH IPC/DIC FUSE LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PNK 6 7 8 WIRE PNK 9 10 11 WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL PPL PPL PPL 1 2 PPL/BLK WIRE PPL/WHT WIRE PRESSURE SWITCH MANIFOLD PTO STATUS RED WIRE RED/BLK WIRE SPLICE PACK TAN WIRE TAN/WHT WIRE TFT SENSOR TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

A/T ISS SIG LOW VSS SIG LOW ALLISON TRANSMISSION AUTOMATIC TRANSMISSION SHIFT LEVER BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRNK FUSE DATA BUS H DATA BUS L DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SHIFT REQUEST SWITCH FLD PRESS SW SIG 4 TCC PCS LOW FLD PRESS SW SIG 2 TURB SPEED SW SIG FUSE GRD GRD B+ GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MOD MAIN NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK 6 7 8 WIRE PNK 9 10 11 WIRE PNK FLD PRESS SW SIG 1 VSS SIG HIGH WIRE PNK IGN 0 VOLT WIRE PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL CRANK VOLT PPL PPL PPL PPL 1 2 PPL/WHT WIRE PRESS CONTROL SOLE 2 PTO SIG RANGE SW SIG A MAIN PRESS SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERIAL DATA DATA BUS L STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/WHT WIRE TCC PSC TR SW SIG B TFT SENSOR SIG TR SW SIG C TR SW SIG P TRANSFER CASE CIRCUIT TURB SPEED SW UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) TCM B FUSE WHT WIRE YEL WIRE YEL/BLK WIRE

2 4 6 9 GROUND GROUND GROUND CLASS 2 SERIAL DATA 30 44 57 45 MIL CONTROL CAN DATA L CAN DATA H SIGNAL HIGH - FRONT 56 39 PNK IGNITION PARK/NEUTRAL SIG WIRE ALLISON TRANSMISSION AUTOMATIC TRANSMISSION INPUT SPEED SENSOR (IN AUTOMATIC TRANSMISSION) AUTOMATIC TRANSMISSION TURBINE SPEED SENSOR (IN UPPER LEFT OF TRANSMISSION) BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM FUSE GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) INTERNAL MODE SWITCH IPC/DIC FUSE LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PNK 6 7 8 WIRE PNK 9 10 11 WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL PPL PPL PPL 1 2 PPL/BLK WIRE PPL/WHT WIRE PRESSURE SWITCH MANIFOLD PTO STATUS RED WIRE RED/BLK WIRE SPLICE PACK TAN WIRE TAN/WHT WIRE TFT SENSOR TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

A/T ISS SIG LOW VSS SIG LOW ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BRK FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRNK FUSE DATA BUS H DATA BUS L DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SHIFT REQUEST SWITCH AUTOMATIC TRANSMISSION SHIFT LEVER FLD PRESS SW SIG 4 TCC PCS LOW FLD PRESS SW SIG 2 TURB SPEED SW SIG GRD GRD B+ GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN MALFUNC IND LAMP MOD MAIN NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 12 13 14 WIRE PNK FLD PRESS SW SIG 1 VSS SIG HIGH WIRE PNK IGN 0 VOLT WIRE PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL CRANK VOLT TORQUE SIG PPL PPL PPL PPL 1 2 PPL/WHT WIRE PRESS CONTROL SOLE 2 RANGE SW SIG A MAIN PRESS SOLENOID RED WIRE RED/BLK WIRE REQ TORQUE DATA BUS H RUN WIRE SERIAL DATA STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PSC TORQUE SIG PTO SIG TR SW SIG B TFT SENSOR SIG TR SW SIG C TR SW SIG P TRANSFER CASE) TURB SPEED SW UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) TCM B FUSE WHT WIRE YEL WIRE YEL/BLK WIRE

ALLISON TRANSMISSION AUTOMATIC TRANSMISSION INPUT SPEED SENSOR (IN AUTOMATIC TRANSMISSION) AUTOMATIC TRANSMISSION TURBINE SPEED SENSOR (IN UPPER LEFT OF TRANSMISSION) BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM FUSE GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) INTERNAL MODE SWITCH IPC/DIC FUSE LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PNK 12 13 14 WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL PPL PPL PPL 1 2 PPL/BLK WIRE PPL/WHT WIRE PRESSURE SWITCH MANIFOLD RED WIRE RED/BLK WIRE SPLICE PACK TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TFT SENSOR TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

4.3L, 8.1L 4.3L: 10 GA- 4.8L, 5.3L, 6.0L ABS FUSE TBC BATT FUSE AUDIO AMPLIFIER AUXILIARY BATTERY RELAY (RIGHT REAR OF ENGINE COMPT) BATTERY (LEFT) BATTERY (RIGHT) BATTERY CABLE JUNCTION BLOCK BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE CIG LTR FUSE CIGAR LIGHTER COOL FAN FUSE COOL/FAN RELAY 1 COOL/FAN RELAY 2 COOL/FAN RELAY 3 DATA LINK CONNECTOR DIGITAL RADIO RECEIVER DIGITAL RADIO RECEIVER REAR SEAT AUDIO (RSA) CONTROLLER ELECTRONIC BRAKE CONTROL MODULE BODY CONTROL MODULE EMERGENCY VEHICLE ROOF LAMP RELAY EVAPORATIVE EMISSION CANISTER VENT SOLENOID EXCEPT 4.3L EXCEPT LUXURY FUSE FUSIBLE LINK 1 FUSIBLE LINK 4 FUSIBLE LINK 5 FUSIBLE LINK 6 GENERATOR (4.3L, 8.1L) GENERATOR (4.8L, 5.3L, 6.0L) HD TRAILERING EQUIPMENT PROVISIONAL (BLUNT CUT) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN A FUSE STUD 2 FUSE IGN B FUSE STUD 1 FUSE LUXURY MEGA FUSE MOBILE RADIO FUSE BLOCK (RIGHT SIDE OF DASH) NCA WIRE NOT USED NOT USED ORG/ WIRE RADIO AMP FUSE RADIO FUSE REAR SEAT AUDIO (RSA) CONTROLLER RADIO RADIO RED WIRE RED/BLK WIRE RELAY RELAY/ FUSE RTD FUSE S/ROOF FUSE RR WPR FUSE EAP FUSE STARTER STARTER RELAY SUNROOF CONTROL MODULE (BEHIND RIGHT SIDE OF DASH, NEAR "A" PILLAR) TO IGNITION SWITCH (DIAGRAM 5 OF 6) TO IGNITION SWITCH (DIAGRAM 6 OF 6) TO IPC/DIC FUSE (DIAGRAM 2 OF 6) TRAILER CONNECTOR (7 WAY) UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSES/ ECAS FUSE FUSE W/ AUX BATTERY W/ WRECKER EMERGENCY LAMP WHEEL TRAILER WIRING PROVISIONAL (BLUNT CUT) WRECKER RELAY