GMC Cab & Chassis Sierra 3500 (2004-2007) red Wiring diagrams

40 12 17 MIL CONTROL SIGNAL HIGH - FRONT PTO STATUS 73 36 GROUND GROUND 9 18 15 2 1 GROUND IGNITION CLASS 2 SERIAL DATA CAN DATA LO CAN DATA HI ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CAN DATA LO DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (IN ENGINE HARNESS) EXCEPT SEO FUSE GRN DK WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PARK/NEUTRAL SIG PNK 1049 2362 2361 WIRE PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD VEHICLE SPEED SENSOR RED WIRE RED/BLK WIRE REV RUN WIRE SEO SIG HI-FRONT COMPUTER DATA LINES SYSTEM 2361 2470 CAN DATA HI CLASS 2 DATA SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TFT SENSOR TRIM SOLENOIDS TFT SIGNAL TOW/HAUL SWITCH (IF EQUIPPED) TRANS MIL REQUEST TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

61 33 (DIESEL) (GAS) 46 49 ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (M/T) (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DEL TORQUE SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE POWERTRAIN OR ENGINE CONTROL MODULE (PCM OR ECM) (ON LEFT FRONT OF ENG COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL IND (IF EQUIPPED) TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRANSFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 HALL A SIG HALL B SIG SENS GND POS 2 SIG 5 VOLT REF B+ VOLT B+ VOLT SERIAL DATA BASE BASE CASE GND GND B+ VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE HALL A SIG HALL B SIG SENS GND HALL C SIG HALL C SIG RLY VOLT SENS GND POS 1 SIG 5 VOLT REF HOT AT ALL TIMES HOT IN HOT IN RUN LEFT I/P FUSE BLOCK IGN 3 FUSE I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LOW REF LT BLU WIRE LT GRN WIRE MEGA FUSE MODE IND CTRL LAT ACCEL SIG ORG/ WIRE PHASE A CTRL PHASE B CTRL PHASE C CTRL PNK PNK WIRE PNK WIRE POS A SIG POS B SIG POWER DISTRIBUTION SYSTEM PPL PULSE SIG REAR WHEEL POSITION SENSOR (LEFT REAR OF VEHICLE) REAR WHEEL STEERING CONTROL MODULE (NEAR SPARE TIRE BRACKET) REAR WHEEL STEERING MODE SELECT SWITCH RED WIRE RLY GND RUN WIRE SENS SIG STEERING GEAR MOTOR ASSEMBLY (NEAR SPARE TIRE BRACKET) STEERING WHEEL SPEED/ POSITION SENSOR (ON STEERING COLUMN) TAN WIRE UNDERHOOD FUSE BLOCK UNDERHOOD FUSE HOLDER VSS IGN 3 VOLT YAW SENS SIG MODE SW SIG WHT WIRE YEL WIRE

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRAKE CONTROL BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FRONT PROPSHAFT SPEED SENSOR FUSE GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL FT SHAFT LO FT SHAFT HI PPL/WHT WIRE REAR PROPSHAFT SPEED SENSOR RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE DIESEL: ENGINE CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DIESEL (ECM) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FT SHAFT LO FT SHAFT HI FUSE GAS (PCM) GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TRANSMISSION SYSTEM TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

ACCESSORY VOLTAGE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CHECK WASHER FLUID DK BLU WIRE GROUND LSD HI LO HOT AT ALL TIMES HOT IN RUN AND ACC I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) INSTRUMENT PANEL CLUSTER LO OFF PULSE LOW WASHER FLUID IND SIG MESSAGE CENTER MIST HI MIST WASH OFF ORG/ WIRE PNK WIRE RED WIRE SERIAL DATA TAN WIRE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) W/S WASH FUSE W/S WASH RELAY W/S WIPER FUSE WASHER FLUID LEVEL SENSOR (IN WASHER FLUID RESERVOIR) (EXCEPT 4.3L BASE) WHT WIRE WINDSHIELD WASHER FLUID PUMP (ON WASHER FLUID RESERVOIR) WINDSHIELD WASHER RELAY CNTRL WINDSHIELD WASHER SWITCH SIGNAL WINDSHIELD WIPER HIGH SIGNAL WINDSHIELD WIPER MOTOR MODULE (UNDER WINDSHIELD COWL, BETWEEN WIPER ARMS) WINDSHIELD WIPER MOTOR PARK SIGNAL WINDSHIELD WIPER/ WASHER SWITCH YEL WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CFAN LO RLY INJ 7 CTRL INJ 4 CTRL COOLING FANS SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA FUEL INJECTORS FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (IN UNDERHOOD FUSE BLOCK) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE SBA FUSE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE