GMC Cab & Chassis Sierra 3500 (2004-2007) low ref Wiring diagrams

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE HOSE) BLK WIRE CLASS 2 SER DATA LO PRESS SENS SIG CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC CONTROL MODULE (BEHIND CENTER OF DASH) IGN E FUSE LOGIC LOW REF RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE

10 12 PNK WIRE 16 5 PNK WIRE 8 7 PNK WIRE AIR TEMP SENSOR AIRBAG FUSE AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AMBIENT PHOTO SENSOR BACK UP LAMP VOLTAGE OUTPUT BACK UP VOLTAGE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK COMPASS COMPUTER DATA LINES SYSTEM DK GRN/WHT WIRE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR ELECTRO- CHROMIC ELECTROCHROMIC MIRROR EXCEPT 10 SERIES/ CREW CAB GROUND GRY WIRE HOT IN RUN, START IGN 3 INSIDE REARVIEW MIRROR LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LOW REF LOW REF MIR SIGNAL LT GRN WIRE PNK WIRE RR LIGHT PHOTO SENSOR SELECTOR SWITCH SERIAL DATA SUPPLEMENTAL RESTRAINTS SYSTEM TEMP UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 HALL A SIG HALL B SIG SENS GND POS 2 SIG 5 VOLT REF B+ VOLT B+ VOLT SERIAL DATA BASE BASE CASE GND GND B+ VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE HALL A SIG HALL B SIG SENS GND HALL C SIG HALL C SIG RLY VOLT SENS GND POS 1 SIG 5 VOLT REF HOT AT ALL TIMES HOT IN HOT IN RUN LEFT I/P FUSE BLOCK IGN 3 FUSE I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LOW REF LT BLU WIRE LT GRN WIRE MEGA FUSE MODE IND CTRL LAT ACCEL SIG ORG/ WIRE PHASE A CTRL PHASE B CTRL PHASE C CTRL PNK PNK WIRE PNK WIRE POS A SIG POS B SIG POWER DISTRIBUTION SYSTEM PPL PULSE SIG REAR WHEEL POSITION SENSOR (LEFT REAR OF VEHICLE) REAR WHEEL STEERING CONTROL MODULE (NEAR SPARE TIRE BRACKET) REAR WHEEL STEERING MODE SELECT SWITCH RED WIRE RLY GND RUN WIRE SENS SIG STEERING GEAR MOTOR ASSEMBLY (NEAR SPARE TIRE BRACKET) STEERING WHEEL SPEED/ POSITION SENSOR (ON STEERING COLUMN) TAN WIRE UNDERHOOD FUSE BLOCK UNDERHOOD FUSE HOLDER VSS IGN 3 VOLT YAW SENS SIG MODE SW SIG WHT WIRE YEL WIRE

22 14 SERIAL DATA BATTERY 7 8 SUPPLY VOLT LOW REF AIR CONDITIONING SYSTEM BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR GROUND HOT AT ALL TIMES HVAC CONTROL MODULE (IN CENTER OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) LOW REF ORG/ WIRE PASSENGER DOOR MODULE (PDM) (IN RIGHT FRONT DOOR) PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE R DEF REAR DEFOG SWITCH SERIAL DATA SUPPLY VOLT TAN WIRE WHT WIRE

2 3 3 2 1 1 (DIESEL) (GAS) 5 VOLT REF 5.3L FLEX FUEL BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 DATA COMPUTER DATA LINES SYSTEM DIESEL DIESEL GAS DK BLU WIRE DK DK DK GRN WIRE DK GRN/WHT WIRE DK PPL ENG SPEED SIG ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON OIL PAN) ENGINE OIL PRESSURE SENSOR (REAR OF ENGINE) EXC LUXURY LUXURY EXCEPT 5.3L FLEX FUEL EXCEPT 8.1L 8.1L FUEL LEV SENS FUEL LEVEL SENSOR (PRIMARY) (INSIDE FUEL TANK) FUEL LEVEL SENSOR (SECONDARY) (INSIDE FUEL TANK) GAS GRN WIRE GRY WIRE I/P RELAY BLOCK INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LOW REF LOWER LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOWER RIGHT STEERING WHEEL CONTROL SWITCH ASSEMBLY MIL CTRL NCA WIRE OIL LEV SW SIG OIL PRES SIG ORG/ WIRE PERSONAL- IZATION POWERTRAIN CONTROL MODULE (PCM) (GAS) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL (OR PPL/WHT) WIRE PPL FUEL LEV SENS RADIO SBA SIG SELECT STARTING/CHARGING SYSTEM TAN/WHT WIRE TRIP INFO FUEL INFO VSS W/ DUAL TANKS W/O DUAL TANKS WAIT TO START WATER IN FUEL (WIF) SENSOR (ON FUEL FILTER ELEMENT) WHT WIRE WIF IND YEL WIRE YEL/BLK WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

1694 1478 TRANSMISSION SYSTEM 2755 2530 5425 LOW REF FUEL PRESS VOLT INJ + GROUP 4 INJ 6 INJ 3 2931 6265 LOW REF CMP SENSOR SIG 492 432 MAF SENSOR SIG TURBOCHARGER SIG TUR VANE POS SIG APP SENSOR 2 SIG BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE, NEAR COOLING FAN PULLEY) COOLANT LEVEL SIG COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE SET SW SIG DK BLU WIRE DK BLU/WHT WIRE EGR VAL POS SIG ECT SENSOR SIG ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (TOP OF ENGINE, NEAR OIL FILTER TUBE) ENGINE OIL LEVEL SWITCH (LEFT REAR OF OIL PAN) GRN WIRE GRY WIRE GRY/BLK WIRE IAT SENSOR 2 SIG IAT SENSOR SIG LOW REF LOW REF ENG SHUTOFF SIG CPP SW SIG LOW REF TUR VANE POS INJ + GROUP 3 INJ 5 INJ 4 5930 5423 PPL 845 844 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PTO ON SW SIG CRUISE ON SW SIG LOW REF LOW REF 397 552 CRUISE CONTROL SYSTEM RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTER ENABLE FUEL PRESS INJ + GROUP 2 2834 5422 TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION CONTROL SOLENOID VALVE WATER IN FUEL SENSOR (ON FUEL FILTER ELEMENT) WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 4 5 6 7 8 PNK WIRE 9 10 11 12 13 PNK WIRE AXLE SW SIG BACKUP VOLT BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY RELAY BLOCK BRN WIRE CKP SENSOR SIG CLUTCH PEDAL POSITION SWITCH DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) FRP SENSOR SIG FUEL PRESSURE REGULATOR GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN BRK FUSE HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE IGN 1 INJ 1 INJ 2 INTAKE AIR HEATER FUSE INTAKE AIR TEMPERATURE (IAT) SENSOR 2 (IN AIR INDUCTION TUBE) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK 23 24 25 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 30 31 PPL/WHT WIRE RED WIRE RED/BLK WIRE STOPLAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSMISSION SYSTEM TUR VAN POS UNDER- HOOD FUSE BLOCK (LEFT SIDE ENG COMPT) WATER IN FUEL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE