Geo Metro I (1989-1997) instrument panel cluster assembly Wiring diagrams

BATT FUSE BATTERY BLK WIRE BLK/WHT WIRE BLU/BLK WIRE CHARGE INDICATOR DAYTIME RUNNING LAMPS CONTROL MODULE FROM BULKHEAD GROMMET) FUSE BOX (LEFT SIDE OF ENGINE COMPT, BEHIND BATTERY) GENERATOR GRN WIRE IG FUSE IGNITION SWITCH INSTRUMENT PANEL CLUSTER ASSEMBLY JUNCTION BLOCK (LEFT SIDE OF DASH, BELOW CLUSTER) JUNCTION BLOCK (LEFT SIDE OF I/P, BELOW CLUSTER) LOCK NCA WIRE RUN WIRE STARTER SOLENOID WHT WIRE WHT/RED WIRE

AUDIO ALARM MODULE AUXILIARY DATA LINK CONNECTOR BLK WIRE BREAKOUT (1995), BREAKOUT (1996)) BRN WIRE CIGAR LIGHTER CIGAR LIGHTER CONNECTOR BREAKOUT) COMBINATION SWITCH CONNECTOR BREAKOUT) DATA LINK CONNECTOR DATA LINK CONNECTOR ON-BOARD DIAGNOSTIC II DIAG SW CONNECTOR FROM DLC-OBD II BREAKOUT) FROM RADIO CONNECTOR BREAKOUT) FRONT WIPER/ WASHER SWITCH IGNITION SWITCH ILLUMINATION CONTROLLER INSTRUMENT PANEL CLUSTER ASSEMBLY JUNCTION BLOCK RADIO REAR DEFOGGER SWITCH TURN/ HAZARD FLASHER

A/C CONDENSER FAN AT RIGHT REAR OF TRUNK) BLK WIRE BLU WIRE BREAKOUT) CENTER HIGH MOUNTED STOP LAMP CONNECTOR BREAKOUT) DATA LINK CONNECTOR ON-BOARD DIAGNOSTIC II DUAL PRESSURE SWITCH DUTY CHECK DATA LINK CONNECTOR EARLY FUEL EVAPORATION HEATER FROM BULKHEAD GROMMET AT CENTER OF SAFETY WALL) FROM CENTER CONSOLE BRANCH BREAKOUT) FUEL GAGE SENDING UNIT FUEL PUMP GRN WIRE IGNITER INSTRUMENT PANEL CLUSTER ASSEMBLY LEFT BACKUP LAMP LEFT LICENSE PLATE LAMP LEFT REAR COMBINATION LAMP LEFT REAR COMBINATION LAMP CONNECTOR BREAKOUT) LEFT SIDE MARKER LAMP LEFT TAIL/ STOP LAMP LEFT TURN SIGNAL NOISE SUPPRESSOR FILTER REAR DEFOGGER REAR OF TRUNK) REAR WIPER MOTOR RED WIRE RIGHT BACKUP LAMP RIGHT FRONT TURN LAMP RIGHT PARKING LAMP RIGHT REAR COMBINATION LAMP RIGHT RIGHT LICENSE PLATE LAMP RIGHT SIDE MARKER LAMP RIGHT TAIL/ STOP LAMP RIGHT TURN SIGNAL SEAT BELT SW CONN BREAKOUT) SEAT BELT SWITCH SEAT BELT SWITCH SHIFT LOCK SOLENOID SHIFT LOCK SOLENOID WHT WIRE WITH A/C

BLK WIRE BLK/WHT WIRE BRAKE IND BRN/YEL WIRE BULKHEAD GROMMET NEAR MASTER CYLINDER) COIL CONNECTOR BREAKOUT) FROM STOPLAMP SWITCH CONNECTOR BREAKOUT) DAYTIME RUNNING LAMPS CONTROL MODULE (LEFT SIDE OF I/P) DAYTIME RUNNING LAMPS IND DAYTIME RUNNING LAMPS RESISTOR (LEFT FRONT FENDER) DIMMER SWITCH DIODE NO 3 GROMMET, NEAR MASTER CYLINDER) H/L LH FUSE H/L RH FUSE HEAD HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN ON AND START IG FUSE INSTRUMENT PANEL CLUSTER ASSEMBLY JUNCTION BLOCK (LEFT SIDE OF DASH, BELOW INSTRUMENT CLUSTER) LEFT HEADLAMP LIGHT 2 RELAY RELAY BOX LIGHT SWITCH COMBINATION SWITCH ORG/WHT WIRE PARK OFF PARKING BRAKE SWITCH PASS POWER INPUT GROUND DRL IND BRAKE IND LIGHT SW SIG PPL RED WIRE RED/ BLU WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RIGHT HEADLAMP STARTING/ CHARGING SYSTEM (GENERATOR) WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/RED WIRE

1.0L VIN 6 ONLY 1.3L VIN 9 ONLY ABS ACTIVE IND. ABS IND. ACCY OFF ON AIR BAG IND ANTI-LOCK BRAKES SYSTEMS BLK WIRE BLK/BLU WIRE BLK/WHT WIRE BLU WIRE BLU/ORG WIRE BLU/YEL WIRE BRAKE FLUID LEVEL SWITCH (IN BRAKE FLUID RESERVOIR) BRAKE IND BREAKOUT) BRN WIRE BRN/BLK WIRE BULB TEST CHARGE IND CONNECTOR BREAKOUT) CTRL DAYTIME RUNNING LAMPS CONTROL MODULE (LEFT SIDE OF I/P) DRL IND DUTY CYCLE DATA LINK CONNECTOR (NEAR LEFT FRONT STRUT TOWER) ELECTRONIC BRAKE CONTROL MODULE (RIGHT SIDE OF I/P) ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ANTI-LOCK BRAKES SYSTEM ENGINE COOLANT TEMPERATURE GAGE ENGINE COOLANT TEMPERATURE SENSOR (THERMOSTAT HOUSING) EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FROM BULKHEAD GROMMET, NEAR MASTER CYLINDER) FUEL GAGE SENDING UNIT (IN FUEL TANK) FUEL GAUGE FUEL LVL SIG GRN WIRE GRN/RED WIRE GRN/YEL WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN ON AND START IG FUSE IGNITION SWITCH ILLUMINATION (2 BULBS) IND CTRL INSTRUMENT PANEL CLUSTER ASSEMBLY INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM JUNCTION BLOCK JUNCTION BLOCK (BEHIND LEFT SIDE OF I/P) LEFT TURN IND LOCK LT BLU WIRE MALFUNCTION IND NEAR CENTER OF SAFETY WALL) OIL PRESSURE IND OIL PRESSURE SWITCH (BEHIND EXHAUST MANIFOLD) ORG/ WIRE ORG/WHT WIRE PARKING BRAKE SWITCH (BEHIND MANUAL SELECTOR) POWERTRAIN CONTROL MODULE (RIGHT SIDE OF I/P) PPL SIGNAL PPL/RED WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/GRN WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT IND SENSOR GROUND STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACHOMETER UPSHIFT IND (M/T) VEHICLE SPEED SENSOR WARNING SYSTEM WHT/BLU WIRE WHT/RED WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE YEL/WHT WIRE

4 DOOR AUDIO ALARM MODULE (LEFT SIDE OF I/P) BLK WIRE BLK/BLU WIRE BLK/RED WIRE BLK/YEL WIRE BREAKOUT) BRN WIRE CENTER CONSOLE BRANCH BREAKOUT) COMBINATION SWITCH LIGHT SWITCH CONSOLE BRANCH BREAKOUT) DIODE NO 1 (NEAR AUDIO ALARM MODULE) DOME LAMP GRN WIRE GROMMET, NEAR MASTER CYLINDER) GROUND HEAD OFF PARK HEATER CONTROL UNIT ILLUMINATION LAMP HOT AT ALL TIMES TAIL FUSE ILLUMINATION CONTROLLER BULBS INSTRUMENT PANEL CLUSTER ASSEMBLY JUNCTION BLOCK (BEHIND LEFT SIDE OF I/P) LEFT REAR DOOR JAMB SWITCH LIGHT 1 RELAY (RELAY BOX) LUGGAGE COMPARTMENT LAMP LUGGAGE COMPARTMENT LAMP SWITCH MANUAL SELECTOR LEVER ILLUMINATION LAMP (A/T) OFF DOOR POWER RADIO REAR DEFOGGER SWITCH REAR WIPER/WASHER SWITCH RED WIRE RED/GRN WIRE RED/YEL WIRE RIGHT FRONT DOOR JAMB SWITCH LEFT FRONT DOOR JAMB SWITCH RIGHT REAR DOOR JAMB SW CONN BREAKOUT) RIGHT REAR DOOR JAMB SWITCH WARNING SYSTEM (I/P HARNESS, APPROX WHT WIRE YEL WIRE

2 3 (M/T) (A/T) A/C 1 RELAY A/C 2 RELAY A/C FUSE ABS FUSE (NOT USED) ANTILOCK BRAKE SYSTEM ENABLE RELAY AUXILIARY DATA LINK CONNECTOR BATT FUSE BATTERY BLK WIRE BLK/BLU WIRE BULKHEAD GROMMET NEAR MASTER CYLINDER) COMBINATION SWITCH CONNECTOR BREAKOUT) DATA LINK CONNECTOR DAYTIME RUNNING LAMPS DIODE DOME LAMP DOOR LOCK FUSE ELECTRONIC BRAKE CONTROL MODULE ENGINE CONTROL MODULE FI FUSE FROM DLC BREAKOUT) FROM IGNITION COIL CONNECTOR BREAKOUT) FUSE BOX (LEFT SIDE OF ENGINE COMPT, BEHIND BATTERY) GENERATOR BAT GRN WIRE H/L LH FUSE H/L RH FUSE HAZ FUSE HAZARD SWITCH HORN RELAY IG FUSE IGNITION KEY WARNING SWITCH INSTRUMENT PANEL CLUSTER ASSEMBLY INSTRUMENT PANEL CLUSTER ASSEMBLY (MAIN HARNESS, APPROX LAMP FUSE LEFT HEADLAMP LIGHT 1 RELAY LUGGAGE COMPARTMENT LAMP MAIN RELAY NCA WIRE POWER DOOR LOCK CONTROL MODULE PTC FUSE PTC RELAY RADIO RDTR FAN RELAY RDTR FUSE RED/WHT WIRE RELAY BOX RELAY BOX (LEFT SIDE OF ENGINE COMPT, BEHIND BATTERY) RIGHT HEADLAMP STARTER SOLENOID BAT STOP FUSE STOPLAMP SWITCH TAIL FUSE TO IGNITION SWITCH (DIAGRAM 2 OF 2) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WHT/YEL WIRE

A/C 1 RELAY A/T AIRBAG FUSE BOX (LEFT SIDE OF DASH) ANTILOCK BRAKE SYSTEM ENABLE RELAY AUDIO ALARM MODULE A/C AMPLIFIER BACK FUSE BACKUP LAMP SWITCH OR TRANSAXLE RANGE SWITCH BLK WIRE BLK/ WHT WIRE BLK/RED WIRE BLK/WHT WIRE BLOCK BREAKOUT) BLOWER SPEED SELECTOR SWITCH BLU/BLK WIRE BLU/RED WIRE BREAKOUT TO I/P HARNESS) BULKHEAD GROMMET NEAR MASTER CYLINDER) CIGAR LIGHTER CLUSTER CONN BREAKOUT) CLUTCH PEDAL POSITION SWITCH COMBINATION SWITCH DAYTIME RUNNING LAMPS CONTROL MODULE ELECTRONIC BRAKE CONTROL MODULE FROM BREAKOUT TO GROUND) FROM DLC BREAKOUT) FROM JUNCTION BLOCK (DIAGRAM 1 OF 2) FROM JUNCTION BLOCK CONNECTOR BREAKOUT) FROM SIR HARNESS BREAKOUT) FRONT WIPER MOTOR FRONT WIPER/ WASHER SWITCH FUEL PUMP RELAY FUSE FUSE BOX BRANCH BREAKOUT) GEN. BREAKOUT) GENERATOR GRN/ YEL WIRE HARNESS BREAKOUT) HAZARD SWITCH HEATED OXYGEN SENSOR HTR FUSE DEF FUSE IG FUSE IGNITION COIL IGNITION SWITCH INSTRUMENT PANEL CLUSTER ASSEMBLY LAMP DRIVER RELAY LOCK LT GRN WIRE M/T MAIN RELAY NCA WIRE NOISE SUPPRESSOR FILTER PPL/ WHT WIRE RADIO RDTR FAN RELAY REAR DEFOGGER SWITCH REAR WIPER MOTOR REAR WIPER/ WASHER SWITCH RED WIRE RED/YEL WIRE RELAY BOX (LEFT SIDE OF ENGINE COMPT, BEHIND BATTERY) RUN WIRE SENSING DIAGNOSTIC MODULE SIR IG FUSE SIR ST FUSE TRANSAXLE CONTROL MODULE TRANSAXLE RANGE SWITCH WHT WIRE WHT/BLK WIRE WIP FUSE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

1995 VFTC BLK WIRE BLK/BLU WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR FUEL INJECTOR FUEL INJECTOR RESISTOR (LEFT REAR OF ENGINE COMPARTMENT) FUEL PUMP (IN FUEL TANK) FUEL PUMP RELAY FUSE AND RELAY BOX (LEFT FRONT OF ENGINE COMPARTMENT) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/GRN WIRE GRY/RED WIRE GRY/WHT WIRE GRY/WTH WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES FUSE BOX FI FUSE HOT IN ON OR START IDLE SPEED CONTROL (ISC) MOTOR (TOP OF ENGINE, ON THROTTLE BODY) IDLE SWITCH IG FUSE INSTRUMENT PANEL CLUSTER ASSEMBLY INTAKE AIR TEMPERATURE (IAT) SENSOR ISCA RELAY (IN RELAY BOX) JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN RELAY MALFUNCTION INDICATOR LAMP MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT REAR OF ENGINE COMPARTMENT) NCA WIRE ORG/GRN WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL/YEL WIRE RED WIRE RED/GRN WIRE RELAY BOX (LEFT FRONT OF ENGINE COMPARTMENT) THROTTLE POSITION (TP) SENSOR (REAR OF ENGINE ABOVE GENERATOR) UPSHIFT INDICATOR (M/T ONLY) WHT WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC BLK WIRE BLK/BLU WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/WHT WIRE BRN/BLK WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR FEDERAL FUEL INJECTOR FUEL INJECTOR RESISTOR (LEFT REAR OF ENGINE COMPARTMENT) FUEL PUMP (IN FUEL TANK) FUEL PUMP RELAY FUSE AND RELAY BOX (LEFT FRONT OF ENGINE COMPARTMENT) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/GRN WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES FUSE BOX FI FUSE HOT IN ON OR START IDLE SPEED CONTROL (ISC) MOTOR (TOP OF ENGINE, ON THROTTLE BODY) IDLE SWITCH IG FUSE INSTRUMENT PANEL CLUSTER ASSEMBLY INTAKE AIR TEMPERATURE (IAT) SENSOR ISCA RELAY (IN RELAY BOX) JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN RELAY MALFUNCTION INDICATOR LAMP MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT REAR OF ENGINE COMPARTMENT) NCA WIRE ORG/ WIRE ORG/GRN WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL/YEL WIRE RED WIRE RED/GRN WIRE RELAY BOX (LEFT FRONT OF ENGINE COMPARTMENT) THROTTLE POSITION (TP) SENSOR (REAR OF ENGINE ABOVE GENERATOR) TRANSAXLE CONTROL MODULE (TCM) (LEFT SIDE OF I/P, NEAR STEERING COLUMN) UPSHIFT INDICATOR (M/T ONLY) WHT WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE