Ford Windstar I (1994-2003) wht Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 V BATT 2 1 2 3 4 5 6 7 8 9 10 11 12 SCP (-) LFT FRT PRK LMP HOOD AJAR SW LIFTGATE WPR RLY 1318 1310 1319 WIPER/WASHER SYSTEM INSTRUMENT CLUSTER SYSTEM WIPER/WASHER SYSTEM 1333 1332 WIPER/WASHER SYSTEM INTERIOR LIGHTS SYSTEM 1335 1205 HEADLIGHTS SYSTEM 1389 1546 DEFOGGER SYSTEM EXTERIOR LIGHTS SYSTEM AMBIENT AIR SENS RETRN ANTI-THEFT SYSTEM HEADLIGHTS SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/ORG WIRE DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FRONT ELECTRONIC MODULE (FEM) (BELOW LEFT SIDE OF DASH) FUSE 14 FUSE 2 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM LEFT CORNER LAMP LIFTGT WASHR PMP ACC DELAY RELAY LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/WHT WIRE ORG/BLK WIRE ORG/RED WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWER GRD 3 POWER GRD 4 POWER GRD 5 ANTI-THFT HORN LFT HDLP HI BEAM REAR WINDOW DEFROST SW LEFT SIG MIRROR OUT PNK WIRE RED WIRE RED/LT BLU WIRE RT HDLP HI BEAM POWER GRD 6 TAN/BLK WIRE TAN/ORG WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE YEL/WHT WIRE

BLK WIRE CENTRAL JUNCTION BOX FRONT ELECTRONIC MODULE (BELOW LEFT SIDE OF DASH) FUSE 17 HOT AT ALL TIMES INSTRUMENT CLUSTER LEFT POWER SLIDING DOOR MODULE (LEFT REAR QUARTER PANEL) LT BLU WIRE LT BLU/WHT WIRE PARKING AID MODULE (RIGHT REAR OF VEHICLE) PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT SIDE OF DASH, THROUGH FIREWALL) REAR ELECTRONIC MODULE (AT RIGHT REAR QUARTER PANEL) REMOTE KEYLESS ENTRY MODULE (BEHIND RIGHT SIDE OF DASH) RESTRAINT CONTROL MODULE (BEHIND LEFT SIDE OF DASH) RIGHT POWER SLIDING DOOR MODULE (RIGHT REAR QUARTER PANEL) SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPARTMENT) TAN/ORG WIRE VIO WIRE WHT WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CLIMATE CONTROL ASSEMBLY DK GRN WIRE DK GRN/VIO WIRE FRONT ELECTRONIC MODULE (BELOW LEFT SIDE OF DASH) FUSE 10 FUSE 116 FUSE 22 HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT EXTERIOR REAR VIEW MIRROR LT BLU WIRE PNK WIRE REAR WINDOW DEFOGGER GRID REAR WINDOW DEFOGGER RELAY REAR WINDOW DEFOGGER SWITCH RIGHT EXTERIOR REAR VIEW MIRROR TAN/LT BLU WIRE TAN/ORG WIRE VIO WIRE WHT WIRE

1 12 8 4 6 V BATT 4 CTSY LAMPS OUT LF DOOR AJAR LF UNLK SW LF LOCK SW 1 2 DOOR LOCK DOOR UNLK 12 2 1 POWER GROUND SCP BUS (-) SCP BUS (+) 15 14 LIFTGATE DISARM LIFTGATE AJAR SW 19 3 17 KEYPAD IN A BATTERY FEED R SLIDING AJAR 6 1 16 PARK LAMPS OUT V BATT 2 ANTI-THFT HORN ANTI-THEFT HOOD SWITCH ANTI-THEFT SOUNDER BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CTSY LAMPS OUT DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DOOR LOCKS SYSTEM FRONT ELECTRONIC MODULE (BELOW LEFT SIDE OF DASH) FUSE 11 FUSE 113 FUSE 14 FUSE 2 GRY WIRE HEADLAMPS SYSTEM HOT AT ALL TIMES LEFT DISARM SWITCH LEFT FRONT DOOR DISARM SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT LIFTGATE DISARM SWITCH LEFT SLIDING DOOR AJAR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE REAR ELECTRONIC MODULE (AT RIGHT REAR QUARTER PANEL) RED WIRE RED/ORG WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT LIFTGATE DISARM SWITCH RIGHT SLIDING DOOR DISARM SWITCH TAN WIRE TAN/ORG WIRE V BATT 3 VIO WIRE VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS 4 18 1410 1423 SWITCH SIGNAL RETURN AUXILIARY BLOWER SENSE 4 8 14 A/C DEMAND SWITCH A/C INDICATOR REAR WDO DEFROST (ON) IND A/C CLUTCH FIELD COIL A/C CLUTCH RELAY A/C HIGH PRESSURE CUTOUT/FAN SWITCH (CENTER FRONT OF ENGINE COMPARTMENT) A/C SWITCH A/C-HEATER CONTROL SWITCH AUXILIARY BLOWER SPEED 5000 OHMS BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CLIMATE CONTROL SWITCH ASSEMBLY DK BLU WIRE DK BLU/ORG WIRE DRIVER'S TEMPERATURE 5000 OHMS FRONT A/C CTRL SIG FRONT BLOWER MOTOR RELAY OUTPUT FRONT ELECTRONIC MODULE (FEM) (BELOW LEFT SIDE OF DASH) FUSE 19 FUSE 3 GRY WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 10 HOT IN START OR RUN IGNITION GND ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE OFF PANEL/FLOOR VENT FLOOR MIX NORM MAX DEF OFF PANEL/FLOOR VENT FLOOR NORM MIX MAX DEF ORG/ WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, THROUGH FIREWALL) REAR DEFROST SWITCH REAR TEMPERATURE 5000 OHMS RED WIRE RED/BLK WIRE RED/YEL WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO/WHT WIRE W/AUXILIARY AIR CONDITIONING WHT WIRE WHT/BLK WIRE YEL WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR SWITCH BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COOLING FAN DROPPING RESISTOR (ON LOWER LEFT FRONT OF ENGINE COMPARTMENT) DK BLU WIRE ENGINE COOLING FAN MOTOR HIGH SPEED RELAY ENGINE COOLING FAN MOTOR LOW SPEED RELAY FRONT BLOWER MOTOR RELAY FUSE 107 FUSE 120 FUSE 20 HOT AT ALL TIMES HOT IN START OR RUN LEFT ELECTRIC COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) LT BLU WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK WIRE PNK/WHT WIRE RED WIRE RED/ORG WIRE RIGHT ELECTRIC COOLING FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR) WHT WIRE

1 2 3 4 5 6 7 8 REAR ELEC MOD SIG OUT 1 2 3 4 5 6 7 8 REAR ELEC MODULE SIG OUT AUXILIARY A/C BLEND DOOR ACTUATOR (LEFT OF REAR SEAT) AUXILIARY A/C BLOWER RELAY MODULE AUXILIARY A/C MODE DOOR ACTUATOR (LEFT OF REAR SEAT) AUXILIARY BLOWER MOTOR (BEHIND PANEL, LEFT OF REAR SEAT) AUXILIARY BLOWER MOTOR RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND PANEL, LEFT OF REAR SEAT) AUXILIARY BLOWER SPEED RELAY 1 AUXILIARY BLOWER SPEED RELAY 2 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FUSE 11 FUSE 23 FUSE 8 GRY/ORG WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES IGNITION LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/RED WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR AUXILIARY A/C CONTROL REAR ELECTRONIC MODULE (REM) (AT RIGHT REAR QUARTER PANEL) RED WIRE SWITCHED SYSTEM POWER RELAY 4 TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE FUSE 20 GRY/ORG WIRE HOT IN RUN OR START LT GRN WIRE LT GRN/YEL WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) POWERTRAIN CONTROL MODULE (BEHIND RIGHT SIDE OF DASH, THROUGH FIREWALL) RED WIRE STARTER INTERRUPT RELAY WHT WIRE WHT/LT GRN WIRE YEL WIRE

A/C SYSTEM BLK WIRE BLK/PNK WIRE BODY COMPUTER SYSTEM (REAR ELECTRONIC MODULE) BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON TOP RIGHT SIDE OF ENGINE) CANISTER VENT SOLENOID (UNDER DRIVER SIDE MIDDLE OF VEHICLE) CKP SENSOR SHIELD CRANKSHAFT POSITION (CKP) SENSOR (ON TOP FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (ON LEFT REAR OF ENGINE COMPT) DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP REAR OF ENGINE) FUEL PUMP/ FUEL GAUGE SENDER (ON TOP OF FUEL TANK) GRY WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE INERTIA FUEL SHUT- OFF (IFS) SWITCH (IN RIGHT REAR OF LUGGAGE COMPT) LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (IN LEFT SIDE OF ENGINE COMPT) PNK/BLK WIRE PNK/WHT WIRE POWER STEERING PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (TOP OF ENGINE) TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSAXLE) VIO/ORG WIRE VIO/WHT WIRE WHT WIRE YEL/LT GRN WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL CHARGE HARN, NEAR BREAKOUT TO FUEL INJ 1) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY) INTAKE MANIFOLD RUNNER CONTROL (IMRC) SOLENOID (ON TOP FRONT OF ENGINE) LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE