Ford Taurus V (2007-2009) hot in run or start Wiring diagrams

28 39 29 47 27 40 35 15 41 SSD SSA TCC TSPC SSB SSC LPC TSS TSS/OSS VPWR 38 20 43 17 18 19 32 45 SSE TFT TFT SIG RTN TR-1 TR-2 TR-3 TR-4 TSS/OSS TR GND 46 54 16 37 38 BOO KAPWR OVERDRIVE CANCEL MS CAN+ MS CAN- ACCELERATOR PEDAL POSITION (APP) SENSOR (TOP OF ACCELERATOR PEDAL ASSEMBLY) BATTERY JUNCTION BLK WIRE BLK/YEL WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM ELECTRONIC THROTTLE CONTROL (ETC) (TOP REAR OF ENGINE) ETCREF TACM- TACM+ FLOOR SHIFTER FUSE 2 FUSE 23 BOX (BJB) (LEFT SIDE OF ENGINE COMPT) FUSE 26 FUSE 30 GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/ORG WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN RUN OR START OSS + POWERTRAIN CONTROL MODULE (PCM) (REAR OF ENGINE COMPT) REV LMPS CTRL REVERSING LAMPS RELAY SMART JUNCTION BOX (SJB) (UNDER LEFT SIDE OF DASH) SSD SSA TCC TSPC SSB SSC LPC TSS TSS/OSS VPWR TPRTN TRANSMISSION CONTROL SWITCH VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE

AMBIENT AIR TEMPERATURE SENSOR (BEHIND CENTER OF FRONT BUMPER) AUTO LAMP SENS IN AUX TEMP DOOR ACT FDBK AUX MODE DOOR ACT FDBK AUX BLWR POT AUX TEMP POT AUXILIARY A/C CIRCUIT BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST REQUEST PASS TEMP ACT FDBK PASS TEMP DOOR CCW PASS TEMP DOOR CW DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) FUSE 15 FUSE 37 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC MODULE (DATC) (BEHIND CENTER OF DASH) MODE DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) ORG/ WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (UNDER RIGHT SIDE OF DASH) RECIRC CCW RECIRC CW RED WIRE RETURN VREF VPWR VBATT SEATS SYSTEM SMART JUNCTION BOX (SJB) (UNDER LEFT SIDE OF DASH) SOLID STATE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

10 11 RETURN VREF 12 13 VPWR VBATT 18 12 13 AUX TEMP DOOR FDBK AUX TEMP DOOR CCW AUX TEMP DOOR CW 20 21 AUX BLWR POT AUX TEMP POT 5 6 3 GND ILLUM AUTOMATIC A/C CIRCUIT AUX BLOWER AUX BLWR SPD RLY 1 AUX TEMP AUXILIARY MODE ACTUATOR (BEHIND LEFT REAR QUARTERPANEL) AUXILIARY TEMPERATURE ACTUATOR (BEHIND LEFT REAR QUARTERPANEL) BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BRN WIRE BRN/WHT WIRE FRONT BLOWER RLY FUSE 15 FUSE 37 FUSE 45 GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START HVAC MODULE (DATC) (BEHIND CENTER OF DASH) REAR AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY RED WIRE SMART JUNCTION BOX (SJB) (UNDER LEFT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE

ACTIVE TORQUE CONTROL COUPLING (ATCC) SOLENOID (UNDER CENTER REAR OF VEHICLE) ALL WHEEL DRIVE (AWD) MODULE (BEHIND RIGHT KICK PANEL) BLK/YEL WIRE BLU WIRE BLU/RED WIRE BRN WIRE COMPUTER DATA LINES SYSTEM FUSE 34 GND SOL - HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (UNDER LEFT SIDE OF DASH) FUSE 11 HOT IN RUN OR START HS CAN + VPWR VBATT HS CAN+ NCA WIRE RED WIRE SOL + VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/VIO WIRE

1) OFF 2) INT 1 3) INT 2 4) INT 3 5) INT 4 6) INT 5 7) LOW 8) HIGH BLK WIRE BLK/GRY WIRE BLU WIRE BRN WIRE COMPT) ELECTRONICS FRONT WASH SWITCH FRONT WASHER RELAY FRONT WIPER FUSE 29 FUSE 45 GRN WIRE GRY WIRE HALL SENSOR HI/LO SPEED RELAY HOT AT ALL TIMES BATTERY JUNCTION FUSE 3 BOX (BJB) (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR ACC HOT IN RUN OR START INSTRUMENT CLUSTER (IC) LOW WASHER MULTI- FUNCTION SWITCH ORG/ WIRE REAR (LEFT FRONT OF WASHER ENGINE COMPT) RELAY REAR WIPER MOTOR ASSEMBLY RED WIRE RELAY RUN/ PARK RUN/PARK WIPER RELAY SMART JUNCTION BOX (SJB) TAURUS SABLE TAURUS X VIO WIRE VPWR WASHER FLUID LEVEL SWITCH WHT WIRE WHT/VIO WIRE WINDSHIELD WASHER PUMP MOTOR WINDSHIELD WIPER MOTOR (LEFT REAR OF ENGINE COMPT) WIPER STATUS YEL WIRE

1 2 3 4 5 VBATT 21 22 23 24 25 26 FUEL RTN 3 4 2 1 VPWR GND COMPASS MOD - COMPASS MOD + ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/BLU WIRE BLU/GRY WIRE BLU/ORG WIRE CLOCK- SPRING (IN STEERING WHEEL) COMPUTER DATA LINES SYSTEM ELECTRONIC COMPASS FUEL LEVEL SENSOR (W/ SADDLE TYPE FUEL TANK) (AWD: IN FUEL TANK) FUEL PUMP MODULE (IN FUEL TANK) FUSE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START SMART JUNCTION BOX (SJB) FUSE 29 IGNITION SWITCH INFO INSTRUMENT CLUSTER KEY IN IGNITION MS CAN - MS CAN + NCA WIRE PATS TX PNK WIRE RESET SETUP SOUND SYSTEMS STEERING WHEEL SWITCH TRACTION CTRL OFF PATS RX VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VPWR FUEL LVL IN 2 FUEL LVL IN 1 FUEL RTN OIL PRESS MESSAGE SIG LOGIC GND W/O MICROPHONE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE

1 2 3 4 BLOWER GND BLOWER SW HI BLOWER SW MED HI BLOWER SW MED LO BLK WIRE BLK/BLU WIRE BLOWER MOTOR RESISTOR (LOWER RIGHT SIDE OF HVAC UNIT) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST REQUEST DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) EVAP TEMP SENS DRV TEMP DOOR FDBK MODE DOOR 1 FDBK FRONT BLOWER MOTOR (LOWER RIGHT SIDE OF HVAC UNIT) FUSE 15 FUSE 37 FUSE 45 (UNDER LEFT SIDE OF DASH) GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START HVAC MODULE (EMTC) (BEHIND CENTER OF DASH) MODE DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) ORG/ WIRE RECIRC DOOR CWW RECIRC DOOR CW RED WIRE RETURN VREF VPWR VBATT SMART JUNCTION BOX (SJB) THERMAL LIMITER VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BRN WIRE COMPUTER DATA LINES SYSTEM FUSE 36 BOX (SJB) (UNDER LEFT SIDE OF DASH) GROUND HOT IN RUN OR START HS CAN+ INSTRUMENT CLUSTER (IC) PASSIVE ANTI-THEFT TRANSCEIVER (TOP OF STEERING COLUMN) POWER SMART JUNCTION VIO/GRY WIRE WHT WIRE WHT/BLU WIRE YEL/ORG WIRE

BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BTS RTN BTS SIG CAN (+) COMPUTER DATA LINES SYSTEM DRIVER SEAT POSITION SENSOR (UNDER DRIVER'S SEAT) DRIVER SIDE IMPACT SENSOR 2 (IN LEFT "C" PILLAR) FUSE 32 FUSE 46 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/YEL WIRE HOT IN RUN OR START LEFT FRONT IMPACT SENSOR (BEHIND LEFT SIDE OF FRONT BUMPER) PASSENGER AIR BAG DEACTIVATION (PAD) INDICATOR PASSENGER SAFETY BELT TENSION SENSOR (UNDER FRONT PASSENGER'S SEAT) PASSENGER SEAT POSITION SENSOR (UNDER FRONT PASSENGER'S SEAT) PASSENGER SIDE AIR BAG MODULE (UNDER FRONT PASSENGER'S SEAT) PASSENGER SIDE IMPACT SENSOR 2 (IN RIGHT "C" PILLAR) RUN/STRT SEAT PRESSURE SENSOR (UNDER FRONT PASSENGER'S SEAT) SMART JUNCTION BOX (SJB) (UNDER LEFT SIDE OF DASH) SNS RTN SWS V-IN SWSV-OUT TAURUS X EXCEPT TAURUS X SHORTING BAR VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE YEL/BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

1) OFF 2) INT 1 3) INT 2 4) INT 3 5) INT 4 6) INT 5 7) LOW 8) HIGH BLK WIRE BLK/GRY WIRE BLU WIRE BRN WIRE COMPT) ELECTRONICS FRONT WASH SWITCH FRONT WASHER RELAY FRONT WIPER FUSE 29 FUSE 45 GRN WIRE GRY WIRE HALL SENSOR HI/LO SPEED RELAY HOT AT ALL TIMES BATTERY JUNCTION FUSE 3 BOX (BJB) (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR ACC HOT IN RUN OR START INSTRUMENT CLUSTER (IC) LOW WASHER MULTI- FUNCTION SWITCH ORG/ WIRE REAR (LEFT FRONT OF WASHER ENGINE COMPT) RELAY REAR WIPER MOTOR ASSEMBLY RED WIRE RELAY RUN/ PARK RUN/PARK WIPER RELAY SMART JUNCTION BOX (SJB) TAURUS SABLE TAURUS X VIO WIRE VPWR WASHER FLUID LEVEL SWITCH WHT WIRE WHT/VIO WIRE WINDSHIELD WASHER PUMP MOTOR WINDSHIELD WIPER MOTOR (LEFT REAR OF ENGINE COMPT) WIPER STATUS YEL WIRE