Ford Taurus IV facelift (2004-2006) tan/org Wiring diagrams

14 6 13 DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 2 BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 22 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM EXCEPT SEDAN EARLY PRODUCTION SEDAN EARLY PRODUCTION FUSE 28 FUSE 36 GROUND SS C TCC B+ B+ GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 17 TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TOP OF ENGINE) TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TSS VREF EEPROM SCP BUS- SCP BUS+ GROUND SS A TFT ECT TURBINE SHAFT SPEED (TSS) SENSOR (LEFT REAR OF ENGINE) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR GROUND GROUND EPC OSS TPS REF VOLT SIG RETURN BPP VPWR GROUND WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE YEL/BLK WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS MODULE ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BPP SWITCH BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) EARLY BUILD FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 GROUND HOT AT ALL TIMES HOT IN HS CAN+ IGNITION LATE BUILD LEFT DUMP VALVES LEFT ISO VALVES LEFT REAR WHEEL SPEED SENSOR (IN LEFT REAR WHEELWELL, MOUNTED ON BRAKE ASSEMBLY) LF WHEEL SENSOR LF WHEEL SENSOR LR WHEEL SENSOR LR WHEEL SENSOR LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/ORG WIRE REAR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR RUN WIRE SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE WAGON SEDAN WHT/ORG WIRE YEL/BLK WIRE YEL/RED WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS MODULE ABS PUMP MOTOR ADAPTIVE DAMPING IND BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BPP SWITCH BRAKE ASSEMBLY) BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU/WHT WIRE EARLY BUILD FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GROUND GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HS CAN+ IGNITION ILLUM INSTRUMENT CLUSTER LATE BUILD LEFT DUMP VALVES LEFT FRONT WHEEL SPEED SENSOR (IN LEFT FRONT WHEELWELL, MOUNTED ON LEFT ISO VALVES LEFT REAR WHEEL SPEED SENSOR (IN LEFT REAR WHEELWELL, MOUNTED ON LF WHEEL SENSOR LF WHEEL SENSOR LR WHEEL SENSOR LR WHEEL SENSOR LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/ORG WIRE REAR RED WIRE RED/ LT GRN WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT FRONT WHEEL SPEED SENSOR (IN RIGHT FRONT WHEELWELL, MOUNTED ON RIGHT ISO VALVES RIGHT REAR WHEEL SPEED SENSOR (IN RIGHT REAR WHEELWELL, MOUNTED ON RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR RUN WIRE SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE TRACTION CONTROL OFF TRACTION CONTROL SWITCH VOLT VPWR MICROPROCESSOR WAGON SEDAN WHT/ORG WIRE YEL/BLK WIRE YEL/RED WIRE

3.0L 2V ENGINE A/C CLUTCH DIODE A/C CLUTCH FIELD COIL A/C CLUTCH RELAY BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE COMPT) DK BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE COOLING FAN 1 ENGINE COOLING FAN 2 ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) EXCEPT 3.0L 2V ENGINE FUSE 10 FUSE 22 18 FUSE 9 FUSE 28 FUSE FUSE 4 GRY WIRE GRY/RED WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN START OR RUN SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 36 LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE OR RUN ORG/ WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR CORNER OF ENGINE COMPARTMENT) RED WIRE RED/ORG WIRE RELAY CENTER BOX 1 (LEFT FRONT OF ENGINE COMPARTMENT) SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) TAN/ORG WIRE VREF VREF VREF SIG RTN WHT/LT BLU WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) 1 2 3 4 5 6 7 8 9 10 CRUISE ON IND ACCEL SET/ AIR BAG SLIDING CONTACT (NEAR BOTTOM OF STEERING COLUMN) BLK WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) COAST DEACTIVATOR SWITCH (BEHIND LOWER SIDE OF BRAKE PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE EARLY PRODUCTION ELECTRIC CLUTCH PWR GND FUSE FUSE 17 FUSE 27 FUSE 32 GRY/BLK WIRE HORN HORN RELAY HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LATE PRODUCTION LT BLU WIRE LT GRN WIRE MICRO- PROCESSOR NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE PILLAR) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REST RESUME RUN WIRE SHIFT INTERLOCK, ENGINE CONTROLS, ANTI-LOCK BRAKES, EXTERIOR LIGHTS SYSTEMS SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) SPEED CONTROL IND SPEED CONTROL SERVO (IN LEFT REAR OF ENGINE COMPT) STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/ORG WIRE VPWR VSS (+) BRAKE APPLIED IN VREF SIG RTN VPWR WHT WIRE YEL WIRE

3.0L 2V ENGINE A/C CLUTCH DIODE A/C CLUTCH FIELD COIL A/C CLUTCH RELAY BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE BLU WIRE DK BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DUAL PRESSURE SWITCH (BEHIND A/C COMPRESSOR) ENGINE COOLING FAN 1 ENGINE COOLING FAN 2 ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) EXCEPT 3.0L 2V ENGINE FUSE 10 FUSE 28 FUSE 36 (UNDER LEFT SIDE OF DASH) FUSE 4 FUSE 9 FUSE 5 GRY/RED WIRE HIGH PRESSURE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT AT ALL TIMES FUSE 22 18 HOT IN START OR RUN LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE NORMAL PRESSURE ORG/ WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR CORNER OF ENGINE COMPARTMENT) RED WIRE RED/ORG WIRE RED/YEL WIRE RELAY CENTER BOX 1 (LEFT FRONT OF ENGINE COMPARTMENT) SMART JUNCTION BOX SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) TAN WIRE TAN/ORG WIRE WHT/LT BLU WIRE

A/C CLUTCH RELAY AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DPFE SENS SENSOR INPUT CANISTER VENT VSS SENS A/C CLUTCH RLY FROM DTR SENSOR (DIAGRAM 1 OF 4) FTP SENS IPS SENSOR INPUT FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 GROUND GROUND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL INJECTORS (TOP OF ENGINE) FUEL PUMP RLY EPC SOL FUSE 17 FUSE 18 FUSE 28 GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR 11 (REAR OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 12 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 1) HEATED OXYGEN SENSOR 21 (FRONT OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 22 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 2) HOT AT ALL TIMES IAC VALVE OSS SENS CAM SENS DUAL PRESS SW LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE MAF SENS TP SENS VREF SIGNAL RETURN BPP SW PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (IGN) POWER (RUN/STRT) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT) RANGE (DTR) SENSOR RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SEDAN EARLY PRODUCTION EXCEPT SEDAN EARLY PRODUCTION SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) SPEED CONTROL SERVO (LEFT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/YEL WIRE TOP OF ENGINE) VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

A/C CLUTCH RELAY FUSE 22 BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UPPER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DPFE SENS SENSOR INPUT CANISTER VENT VSS SENS A/C CLUTCH RLY FROM DTR SENSOR (DIAGRAM 1 OF 4) FTP SENS IPS SENS IN FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL INJECTORS (TOP OF ENGINE) FUSE 17 JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 28 GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR 11 (REAR OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 12 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 1) HOT AT ALL TIMES LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE MAF SENS TP SENS VREF SIGNAL RETURN BPP SW ORG/YEL WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (IGN) POWER (RUN/STRT) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SEDAN EARLY PRODUCTION EXCEPT SEDAN EARLY PRODUCTION SMART TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VSS WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

A/C CLUTCH RELAY AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DPFE SENS SENSOR INPUT CANISTER VENT VSS SENS A/C CLUTCH RLY FROM DTR SENSOR (DIAGRAM 1 OF 4) FTP SENS IPS SENSOR INPUT FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 GROUND GROUND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL INJECTORS (TOP OF ENGINE) FUEL PUMP RLY EPC SOL FUSE 17 FUSE 18 FUSE 28 GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR 11 (REAR OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 12 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 1) HEATED OXYGEN SENSOR 21 (FRONT OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 22 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 2) HOT AT ALL TIMES IAC VALVE OSS SENS CAM SENS DUAL PRESS SW LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE MAF SENS TP SENS VREF SIGNAL RETURN BPP SW PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (IGN) POWER (RUN/STRT) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT) RANGE (DTR) SENSOR RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SEDAN EARLY PRODUCTION EXCEPT SEDAN EARLY PRODUCTION SMART JUNCTION BOX (UNDER LEFT SIDE OF DASH) SPEED CONTROL SERVO (LEFT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/YEL WIRE TOP OF ENGINE) VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE