Ford Taurus III (1995-1999) ppl/yel Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VAPS CTRL VAPS CTRL 158 1010 464 70 WARNING SYSTEM DEFOGGER SYSTEM WARNING SYSTEM 871 627 680 684 INSTRUMENT CLUSTER SYSTEM ACCESSORY DELAY RELAY ANTI-THEFT OUT BATTERY SAVER RELAY BATTERY SAVER RELAY CONTROL BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DELAY DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DOOR LOCK IN DOOR UNLOCK IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY DRIVER'S UNLOCK RELAY CTRL ELECTRONIC POWER STEERING SYSTEM FUSE 12 FUSE 2 FUSE 20 FUSE 23 FUSE 8 GEM GEM CHIME/ TONE LOGIC GENERIC ELECTRONIC MODULE (ATTACHED TO I/P FUSE PANEL) GND PWR GND SIG GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HEAD HEADLAMP SWITCH HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN HOT IN RUN OR START I/P FUSE PANEL (LEFT SIDE OF I/P) IGN (RUN/ACC) IGN (START) INTERIOR LAMP RELAY INTERIOR LAMP RELAY CTRL INTERIOR LIGHTS, WARNING SYSTEMS (DOOR AJAR SWITCHES) KEY WARNING SW IN REAR DEFROST SW IN LOW COOLANT IND CTRL DATA LINK LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/YEL WIRE MOTOR SENSE HI MOTOR SWITCH DOWN COMMAND MOTOR LOW SENSE OFF OFF HEAD ONE TOUCH WINDOW DOWN RELAY ORG/ WIRE ORG/RED WIRE PARK PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (RUN/START) HEADLAMP SW IN WIPER/WASHER SIG RTN POWER WINDOWS SYSTEM PPL/YEL WIRE REAR WINDOW DEFROST RELAY REAR WINDOW DEFROST RELAY CTRL RED WIRE RED/YEL WIRE RELAY CTRL REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND INTEGRATED CONTROL PANEL) SEATBELT IND CTRL DOOR AJAR IND CTRL INTV DELAY/WASH WIPER MODE SELECT SHUNT RESISTOR TAN WIRE TAN/RED WIRE VEHICLE SPEED SENSOR (REAR CENTER OF ENGINE COMPT. ON TRANSAXLE) VSS IN WARNING SYSTEM WASHER RELAY WIPER HI/LO RELAY WIPER R/P RELAY LOW COOLANT WHT WIRE WHT/PPL WIRE WINDOW SWITCH UP COMMAND WIPER PARK SENSE GND (SIG) WIPER/WASHER SYSTEM YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

14 25 GND GND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE FUSE 12 FUSE 23 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (ATTACHED TO THE UNDERSIDE OF I/P FUSE PANEL) GRY/BLK WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN I/P FUSE PANEL INSTRUMENT CLUSTER LEFT FRONT FENDER) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT, IN COWL) PPL/YEL WIRE PWR (BAT) PWR (START) VSS PWR (START/RUN) RED/YEL WIRE SPEED CONTROL MODULE (LEFT OF MASTER CYLINDER) (ON LEFT KICK PANEL) VAPS CTRL VARIABLE ASSIST POWER STEERING (VAPS) ACTUATOR (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR CENTER OF ENGINE COMPT. ON TRANSAXLE) VSS IN

1 2 3 4 5 6 7 8 9 10 21 22 23 24 25 26 PWR (BAT) VSS- VSS+ PWR (RUN) ANTI-LOCK BRAKE CONTROL MODULE (BELOW BATTERY) BLK WIRE BLK/WHT WIRE BRN/PNK WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DG GRN/YEL WIRE DK GRN/YEL WIRE ELECTRONIC POWER STEERING SYSTEM (ZF GEAR SOLENOID) ENGINE COMPARTMENT FUSE/RELAY BOX FUSE 14 GRY WIRE GRY/BLK WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE PANEL INSTRUMENT CLUSTER LEFT FRONT FENDER) LEFT FRONT SHOCK ACTUATOR (FRONT OF LEFT WHEEL WELL) LEFT REAR SHOCK ACTUATOR (LEFT REAR OF VEHICLE, NEAR WHEEL WELL) LF HEIGHT SENSOR RF HEIGHT SENSOR LR SHOCK ACTUATOR GND ZF GEAR SOL FEED SENSOR PWR DLC LT BLU/WHT WIRE NCA WIRE ORG/ WIRE PNK/ORG WIRE PPL/LT GRN WIRE PPL/YEL WIRE PWR (BAT) RED/BLK WIRE RF SHOCK ACTUATOR RIGHT FRONT HEIGHT SENSOR (FRONT OF RIGHT FRONT WHEEL) RIGHT FRONT SHOCK ACTUATOR (FRONT OF RIGHT WHEEL WELL) RIGHT REAR SHOCK ACTUATOR (RIGHT REAR OF VEHICLE, NEAR WHEEL WELL) RR SHOCK ACTUATOR LF SHOCK ACTUATOR SEMI-ACTIVE RIDE CONTROL (SARC) MODULE (BEHIND RIGHT REAR SEAT) SEMI-ACTIVE RIDE CONTROL FUSE SENSOR GND GND VSS WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/RED WIRE ZF GEAR SOL RTN

#1 COIL PER PLUG (CPP) #2 COIL PER PLUG (CPP) RADIO NOISE CAPACITOR #3 COIL PER PLUG (CPP) #4 COIL PER PLUG (CPP) RADIO NOISE CAPACITOR #2 #5, #6 IGNITION COIL) 3.OL 24V, 3.4L SHO AIR BAG DIAGNOSTIC MONITOR ANTI- THEFT DISARM SWITCH BATTERY SAVER RELAY BLK WIRE BRAKE ON/ OFF (BOO) SWITCH CIGAR LIGHTER CONSTANT CONTROL RELAY MODULE DATA LINK CONNECTOR DK GRN WIRE EATC FFV ONLY FROM I/P FUSE PANEL FUSE (ENGINE COMPARTMENT FUSE/RELAY BOX) (DIAGRAM 1 OF 3) FROM IGNITION FUSES (ENGINE COMPARTMENT FUSE/RELAY BOX) (DIAGRAM 1 OF 3) FUSE 10 FUSE 11 FUSE 12 FUSE 21 FUSE 22 FUSE 23 FUSE 24 FUSE 25 10 FUSE 26 FUSE 27 FUSE 28 FUSE 29 FUSE 9 GENERIC ELECTRONIC MODULE (GEM) GRY WIRE HEADLIGHTS SYSTEM WITH DRL I/P FUSE PANEL I/P FUSE PANEL TRUNK LID RELEASE RELAY IGNITION COIL HEATED OXYGEN SENSOR) IGNITION SWITCH INSTRU- MENT CLUSTER ANTI-LOCK BRAKE CONTROL MODULE FLEX FUEL SENDER MODULE INSTRUMENT CLUSTER INTEGRATED CONTROL PANEL (ICP) INTERIOR LAMP RELAY LIGHT SENSOR/ AMPLIFIER LOCK OFF LOCK OFF STA LT BLU WIRE LT GRN WIRE LT GRN/PPL WIRE LT GRN/RED WIRE LUGGAGE COMPARTMENT LAMP MULTI- FUNCTION SWITCH PASSIVE ANTI-THEFT SYSTEM PASSIVE ANTI-THEFT SYSTEM (PATS) PNK WIRE POWER ANTENNA LEFT POWER MIRROR SWITCH PPL/YEL WIRE RADIO NOISE CAPACITOR) (OTHERS) (ENGINE HARNESS, NEAR RED WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE REMOTE CLIMATE CONTROL (RCC) MODULE RUN WIRE SEDAN SPEED CONTROL DEACTIVATE SWITCH TAN/BLK WIRE TO FUSES 13, 14, 15 (I/P FUSE PANEL) (DIAGRAM 3 OF 3) TO FUSES 7, 8 (I/P FUSE PANEL) (DIAGRAM 3 OF 3) TRUNK LID RELEASE RELAY W/ ABS ONLY W/ RAP (I/P HARNESS, NEAR BREAKOUT TO CONN W/O RAP WAGON WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE FUSE 26 GRY/RED WIRE HOT AT ALL TIMES I/P FUSE PANEL LT GRN WIRE PNK WIRE PNK/ORG OR BRN/WHT WIRE PNK/ORG WIRE PNK/YEL WIRE PPL/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND INTEGRATED CONTROL PANEL) TRUNKLID AJAR SWITCH/ RELEASE SOLENOID (ON TRUNKLID LATCH MECHANISM) TRUNKLID RELEASE RELAY (UNDER CENTER OF I/P) TRUNKLID RELEASE SWITCH W/ RAP W/O RAP YEL WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID EVAP CANP VALVE FPM EPC SOL TCC IAC TSS SENS CMP SENS A/C PRES FTP SENS FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 PWR GND PWR GND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (BACK OF ENG) HEATED OXYGEN SENSOR #12 (LOWER LEFT SIDE OF ENG) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON AIR INTAKE ASSEMBLY) LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE) VPWR VSS WAC RLY OUT EAM RELAY VPWR WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR EVAP CANP VALVE FTP SENS FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 FUSE 28 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) INSTRUMENT CLUSTER SYSTEM LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VPWR WAC RLY OUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DELTA PRESSURE FEEDBACK EGR SENSOR (RIGHT REAR OF INTAKE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR FPM EPC SOL TCC IAC TSS SENS CMP SENS A/C PRES FTP SENS FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 PWR GND PWR GND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (FRONT OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON AIR INTAKE ASSEMBLY) LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO MANIFOLD) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (BEHIND INAKE MANIFOLD) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE) VPWR VSS WAC RLY OUT EAM RLY VPWR WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/PPL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR EVAP CANP VALVE FTP SENS FUSE 12 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND CPP #2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/RED WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE