Ford Taurus III (1995-1999) hot in start or run Wiring diagrams

ABS IND CTRL ISO LINK ABS MODULE FUSE ANTI-LOCK BRAKE CONTROL MODULE (LEFT FRONT OF ENG COMPT, BELOW BATTERY) ANTI-LOCK BRAKE INDICATOR BLK WIRE BLK/WHT WIRE BOO BRAKE ON/OFF (BOO) SWITCH (UPPER FRONT SIDE OF BRAKE PEDAL) COMPUTER DATA LINES DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK GRN WIRE ENGINE COMPARTMENT FUSE/RELAY BOX FUSE 12 FUSE 28 FUSE 9 HOT AT ALL TIMES HOT IN START OR RUN HYDRAULIC PUMP MOTOR I/P FUSE PANEL IGN INLET INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT BRAKE SENSOR (IN LEFT FRONT WHEEL WELL, ON BRAKE ASSEMBLY) LEFT FRONT FENDER) LEFT REAR LEFT REAR BRAKE SENSOR (IN LEFT REAR WHEEL WELL, ON BRAKE ASSEMBLY) LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/YEL WIRE OUTLET PNK/BLK WIRE PUMP MOTOR RELAY RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RF WHL SENS LO RIGHT FRONT RIGHT FRONT BRAKE SENSOR (IN RIGHT FRONT WHEEL WELL, ON BRAKE ASSEMBLY) RIGHT REAR RIGHT REAR BRAKE SENSOR (IN RIGHT REAR WHEEL WELL, ON BRAKE ASSEMBLY) RR WHL SENS HI SHORTING BAR (SHORTS PINS 21, 22 WHEN DISCONNECTED) SOLENOID CONTROL VALVES RELAY SOLID STATE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE YEL/BLK WIRE YEL/RED WIRE

14 25 GND GND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE FUSE 12 FUSE 23 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (ATTACHED TO THE UNDERSIDE OF I/P FUSE PANEL) GRY/BLK WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN I/P FUSE PANEL INSTRUMENT CLUSTER LEFT FRONT FENDER) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT, IN COWL) PPL/YEL WIRE PWR (BAT) PWR (START) VSS PWR (START/RUN) RED/YEL WIRE SPEED CONTROL MODULE (LEFT OF MASTER CYLINDER) (ON LEFT KICK PANEL) VAPS CTRL VARIABLE ASSIST POWER STEERING (VAPS) ACTUATOR (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR CENTER OF ENGINE COMPT. ON TRANSAXLE) VSS IN

1 2 3 4 5 6 7 8 HI BEAM IND OUT BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (RIGHT OF MASTER CYLINDER) BRAKE IND DAYTIME RUNNING LAMPS (DRL) MODULE (BELOW LEFT HEADLAMP) DAYTIME RUNNING LAMPS FUSE DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN/ORG WIRE ENGINE COMPARTMENT FUSE/RELAY BOX FUSE 12 FUSE 3 FUSE 4 FUSE 6 GRY/WHT WIRE HEAD HEADLAMP SWITCH HEADLAMPS FUSE (AUTO) HI LOW FTP HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN I/P FUSE PANEL I/P FUSE PANEL FUSE 30 IGNITION SWITCH INSTRUMENT CLUSTER LEFT HEADLAMP LOW FTP LT BLU/BLK WIRE LT GRN WIRE LT GRN/YEL WIRE MULTI- FUNCTION SWITCH OFF OFF LOCK ORG/ WIRE PARK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/YEL WIRE RIGHT HEADLAMP RUN WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID EVAP CANP VALVE FPM EPC SOL TCC IAC TSS SENS CMP SENS A/C PRES FTP SENS FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 PWR GND PWR GND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (BACK OF ENG) HEATED OXYGEN SENSOR #12 (LOWER LEFT SIDE OF ENG) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON AIR INTAKE ASSEMBLY) LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE) VPWR VSS WAC RLY OUT EAM RELAY VPWR WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CHECK ENGINE INDICATOR TACHO- METER CKP FEED CKP RTN CONSTANT CONTROL RELAY MODULE (ON LEFT SIDE OF BATTERY, BEHIND HEADLAMP) COOLING FANS SYSTEM CRANK- SHAFT POSITION SENSOR SHIELD DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX FUEL PUMP FUSE FUEL PUMP RELAY FUEL SENDER DLC PPL FUSE 10 GRY WIRE GRY/RED WIRE HEDF RLY CTRL EVR TACH HEGO POWER FUSE HORN FUSE HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) IGNITION COIL IMRC INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM KAPWR LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE MAF RTN TFT ECT IAT FPM ACCS IMRC NCA WIRE OCTANE ADJUST PLUG (RIGHT REAR OF ENG COMPT, NEAR PCM) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL/ORG WIRE PWR GND GND IGN COIL A SS #1 EDF RLY CTRL TCS OCT ADJ PSP PWR GND IGN COIL B SS #3 RED WIRE RED/BLK WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO SPARK PLUGS TRANSMISSIONS SYSTEM WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR EVAP CANP VALVE FTP SENS FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 FUSE 28 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) INSTRUMENT CLUSTER SYSTEM LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VPWR WAC RLY OUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CHECK ENGINE INDICATOR CKP FEED CKP RTN CONSTANT CONTROL RELAY MODULE (ON LEFT SIDE OF BATTERY, BEHIND HEADLAMP) COOLING FANS SYSTEM CRANK- SHAFT POSITION SENSOR SHIELD DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) DTE EAM AIR PUMP (LEFT FRONT OF VEHICLE, REAR OF BUMPER) EAM RLY EAM SOLID STATE RELAY (LEFT FRONT OF VEHICLE, REAR OF BUMPER) EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX FUEL PUMP FUSE FUEL PUMP RELAY FUSE 10 GND FF SENS GRY WIRE GRY/RED WIRE HEDF RLY CTRL EVR TACH HEGO POWER FUSE HORN FUSE HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) IGNITION COIL INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (DISTANCE TO EMPTY MODULE) PNK/ WIRE KAPWR LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE MAF RTN TFT ECT IAT FPM ACCS NCA WIRE OCT ADJ PSP OCTANE ADJUST PLUG (RIGHT REAR OF ENG COMPT, NEAR PCM) ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL DLC PPL/ORG WIRE PWR GND GND IGN COIL A SS #1 EDF RLY CTRL PWR GND IGN COIL B SS #3 RED WIRE RED/YEL WIRE TACHO- METER TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE THER- MACTOR PUMP FUSE THERMACTOR AIR BYPASS SOLENOID (LEFT FRONT OF ENG COMPT, NEAR IGNITION COIL) TO SPARK PLUGS WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DELTA PRESSURE FEEDBACK EGR SENSOR (RIGHT REAR OF INTAKE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR FPM EPC SOL TCC IAC TSS SENS CMP SENS A/C PRES FTP SENS FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 PWR GND PWR GND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (FRONT OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON AIR INTAKE ASSEMBLY) LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO MANIFOLD) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (BEHIND INAKE MANIFOLD) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE) VPWR VSS WAC RLY OUT EAM RLY VPWR WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CHECK ENGINE INDICATOR COIL PER PLUG #1 COIL PER PLUG #2 COIL PER PLUG #3 COIL PER PLUG #4 COIL PER PLUG #5 COIL PER PLUG #6 COIL PER PLUG #7 COIL PER PLUG #8 RADIO NOISE CAPACITOR #1 (REAR OF ENG, NEAR CPP #4) CONSTANT CONTROL COOLING FANS SYSTEM COOLING FANS SYSTEM TRANSMISSIONS SYSTEM CRANKSHAFT POSITION SENSOR (LOWER RIGHT SIDE OF ENG) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PPL WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) EAM AIR PUMP (LEFT FRONT VEHICLE, REAR OF BUMPER) EAM RLY SS #1 EAM SOLID STATE RELAY (LEFT FRONT OF VEHICLE, REAR OF BUMPER) EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX FUEL PUMP FUSE FUEL PUMP RELAY FUSE 10 GRN WIRE GRY WIRE HEDF RLY CTRL EVR TACH HEGO POWER FUSE HORN FUSE HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) IMRC FUEL SENDER INSTRUMENT CLUSTER KAPWR KNOCK SENS #2 GND LT BLU WIRE LT BLU/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF RTN TFT ECT IAT FPM ACCS IMRC NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/ORG WIRE PWR GND CCP #5 CCP #7 RADIO NOISE CAPACITOR 2 RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY MODULE SS #2 TCIL DLC TACHO- METER TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE THER- MACTOR PUMP FUSE THERMACTOR AIR BYPASS SOLENOID (ABOVE EXHAUST MANIFOLD, REAR OF ENG) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/PPL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR EVAP CANP VALVE FTP SENS FUSE 12 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND CPP #2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/RED WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE