Wiring Diagrams for Ford Ranger II facelift (2009-2011)

Heater circuit Manual a/c circuit

Anti-lock brakes circuit

Forced entry circuit Passive anti-theft circuit

Body control modules circuit

Computer data lines circuit

Cooling fan circuit

Cruise control circuit

Wiring diagram engine performance 2.3l

Wiring diagram engine performance 4.0l

Backup lamps circuit Exterior lamps circuit Trailer tow circuit

Ground distribution circuit

Headlights circuit, with drl Headlights circuit, without drl

Horn circuit

Instrument cluster circuit

Courtesy lamps circuit Instrument illumination circuit

Power distribution circuit

Power door locks circuit

Power mirrors circuit

Power windows circuit

Radio circuit

Shift interlock circuit

Charging circuit Starting circuit

Supplemental restraints circuit

2.3l, 4wd circuit 2.3l, a/t circuit

4.0l, 4wd circuit 4.0l, a/t circuit

Chime circuit Tire pressure monitoring circuit

Wiper/washer circuit

A/C COMPRESSOR CLUTCH FIELD COIL ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES, SHIFT INTERLOCK SYSTEMS COMPUTER DATA LINES SYSTEM BATTERY JUNCTION HEADLIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ANTI-LOCK BRAKES SYSTEM LOCK OFF PASSIVE ANTI-THEFT TRANSCEIVER PCM POWER DIODE RLY COIL

BLOWER MOTOR RESISTOR CHECK ENGINE IND DRIVER SIDE FRONT POWER WINDOW MOTOR ENGINE CONTROL SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM HEADLIGHTS SYSTEM IND CHECK ENGINE LEFT FRONT DOOR LOCK ACTUATOR (REAR OF OF ENGINE) PASSENGER SIDE FRONT POWER WINDOW MOTOR REAR OF ENGINE COMPT) RIGHT FRONT DOOR LOCK ACTUATOR STARTER MOTOR TEMPERATURE BLEND DOOR ACTUATOR WINDSHIELD WASHER PUMP MOTOR WINDSHIELD WIPER MOTOR

EGR VACUUM REGULATOR SOLENOID VALVE (TOP LEFT

(REAR LIGHT CONNECTOR HARNESS, (REAR LIGHT CONNECTOR HARNESS, NEAR (REAR LIGHT CONNECTOR HARNESS, NEAR BREAKOUT TRAILER TOW CONNECTOR

CONTROL MODULE

AUDIO UNIT FUEL TANK UNIT PASSENGER AUDIO SIDE DOOR UNIT LOCK SWITCH UNIT)

FUSE 1 FUSE 2 FUSE 2 FUSE 1 FUSE 3 FUSE 4 FUSE 3 FUSE 5 FUSE 5 FUSE 6 FUSE 6 FUSE 7 FUSE 8 FUSE 9 FUSE 9 FUSE 10 FUSE 10 FUSE 11 FUSE 12 FUSE 13 FUSE 13 FUSE 16 FUSE 14 FUSE 16 FUSE 17 FUSE 17 FUSE 12 FUSE 17 FUSE 33 FUSE 29 FUSE 19 FUSE 20 FUSE 21 FUSE 21 FUSE 39 FUSE 22 FUSE 23 FUSE 23 FUSE 25 FUSE 1 FUSE 24 FUSE 25 FUSE 13 FUSE 19 FUSE 43 FUSE 26 FUSE 27 FUSE 28 FUSE 28 FUSE 11 FUSE 29 FUSE 31 FUSE 31 FUSE 24 FUSE 32 FUSE 32 FUSE 19 FUSE 33 FUSE 34 FUSE 30 FUSE 23 FUSE 35 FUSE 38 FUSE 39 FUSE 41 FUSE 42 FUSE 43 FUSE 44 LOW CURRENT BOARD FUSE

CHARGE INDICATOR NEUTRAL TOW INDICATOR

BRAKE IND LAMP FLUID LEVEL IN BRAKE IND LAMP HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INSTRUMENT CLUSTER SYSTEM EXTERIOR LIGHTS SYSTEM INTERIOR EXTERIOR LIGHTS LIGHTS SYSTEM SYSTEM INTERIOR LIGHTS LEFT FRONT FOG LAMP LEFT FRONT PARK/TURN LAMP LEFT FRONT SIDE LAMP LEFT HEAD- LAMP HI LO LEFT HEAD- LAMP LO HI LEFT LICENSE PLATE LAMP LEFT REAR PARK/STOP LAMP LEFT REAR PARK/STOP TURN LAMP LEFT REVERSING LAMP PAD LAMP RIGHT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT FRONT FOG LAMP RIGHT FRONT PARK/TURN LAMP RIGHT FRONT SIDE LAMP RIGHT HEAD- LAMP RIGHT HEAD- LAMP LO HI RIGHT LICENSE PLATE LAMP RIGHT LICENSE PLATE LAMP LEFT LICENSE PLATE LAMP RIGHT REAR PARK/ STOP LAMP RIGHT REAR PARK/STOP TURN LAMP RIGHT REVERSING LAMP SOUND SYSTEMS EXTERIOR LIGHTS SYSTEM

A/C CLUTCH RELAY ACCESSORY HORN INTERIOR RELAY LAMP RELAY RELAY ACCESSORY RELAY ALL LOCK RELAY ALL LOCK RELAY DRV DOOR UNLOCK RLY ALL LOCK RELAY PASS DOOR UNLOCK RLY VOLTAGE SUPPLIED IN START ALL LOCK RELAY, PASSENGER DOOR UNLOCK RELAY BLOWER MOTOR RELAY DRIVER DOOR UNLOCK RELAY DRIVER DOOR UNLOCK RELAY PARK LAMP RELAY DRIVER DOOR UNLOCK RLY ACCESSORY RELAY LOW CURRENT BOARD SENSE ENGINE COOLING FAN RELAY FOG LAMP RELAY FRONT WASHER PUMP RELAY FUEL A/C PUMP CLUTCH RELAY RELAY FUEL PUMP RELAY HI/LO WIPER RELAY HORN RELAY INDICATOR FLASHER RELAY INTERIOR LAMP RELAY INTERIOR LAMP RELAY LOW CURRENT BOARD SENSE LOW CURRENT BOARD SENSE PARK LAMP RELAY PASSENGER DOOR UNLOCK ALL LOCK RELAY RELAY PASSENGER DOOR UNLOCK RELAY PCM FUEL POWER PUMP RELAY RELAY PCM POWER RELAY PCM STARTER POWER RELAY RELAY VOLT SPLY AT ALL TIMES HORN RELAY SWITCH

(2.3L A/T: ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS, NEAR (ENGINE CONTROL SENSOR, FUEL (ENGINE CONTROL SENSOR, FUEL CHARGE (ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS, (ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS, NEAR (ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS, NEAR BREAKOUT (ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS, NEAR BREAKOUT TO BREAKOUT TO HEATED OXYGEN SENSOR 11) CHARGE HARNESS, NEAR BREAKOUT TO HEATED OXYGEN SENSOR 21) DRIVER SEAT POSITION SENSOR FUEL GAUGE SENSOR HALL SENSOR HEATED OXYGEN SENSOR LEFT FRONT TIRE PRESSURE SENSOR LEFT REAR TIRE PRESSURE SENSOR RIGHT FRONT TIRE PRESSURE SENSOR RIGHT REAR TIRE PRESSURE SENSOR SAFETY BELT TENSION SENSOR SEAT PRESSURE SENSOR

LEFT FRONT SPEAKER LEFT REAR SPEAKER RIGHT FRONT SPEAKER RIGHT REAR SPEAKER

AUTO DOWN SWITCH BRAKE FLUID LEVEL SWITCH BRAKE PEDAL BRAKE POSITION SHIFT INTERLOCK SWITCH BRAKE PEDAL POSITION SWITCH CLUTCH PEDAL POSITION SWITCH DEACTIVATOR SWITCH DRIVER SAFETY BELT BUCKLE SWITCH DRIVER SIDE DOOR LOCK SWITCH DRIVER SIDE MASTER DOOR WINDOW LOCK ADJUST SWITCH SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH DRIVER SWITCH EXTERIOR REAR VIEW MIRROR SWITCH FOUR WHEEL DRIVE SWITCH FRONT MAIN CIGAR LIGHT LIGHTER SWITCH HORN SWITCH IGNITION KEY SWITCH IGNITION SWITCH LEFT FRONT DOOR AJAR SWITCH MAIN LIGHT SWITCH MASTER WINDOW ADJUST SWITCH MULTI- EXTERIOR FUNCTION REAR VIEW SWITCH MIRROR SWITCH MULTI- FUNCTION SWITCH MULTI-FUNCTION SWITCH 1) MIST PARKING BRAKE SWITCH PASSENGER SAFETY BELT BUCKLE SWITCH PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH PASSENGER SIDE WINDOW ADJUST SWITCH PASSENGER SWITCH REVERSING LAMPS SWITCH RIGHT FRONT DOOR AJAR SWITCH SET/ RESUME SWITCH SPEED CONTROL ON/OFF SWITCH SPEED CONTROL SET/ RESUME SWITCH SPEED CONTROL SET/RESUME SWITCH

BLK WIRE BLK/ YEL WIRE BLK/BLU WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/LT GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU WIRE DK GRN WIRE DK GRN/VIO WIRE GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/DK BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/VIO WIRE GRY/WHT WIRE GRY/YEL WIRE LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 1 2 3 4 5 6 7 8 9 10 SET IND 1 2 3 4 GND VPWR RX TX 1 2 10 8 12 HS CAN+ HS CAN - VBATT VPWR VPWR 1 2 16 HS CAN + HS CAN - TC OFF 1 2 COMPUTER DATA LINES SYSTEM HIGH BEAM IND 1 2 HS CAN + HS CAN - 1 2 R SPKR + R SPKR - 1 4 3 2 PWR GND CHNL A CHNL B 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 GROUND 2.3L 4.0L 3 4 L SPKR - L SPKR + 4.0L 10 7 LEFT TURN SW RIGHT TURN SW 10 8 12 1 2 VBATT VPWR VPWR CAN+ CAN- 10 9 19 20 HS CAN+ HS CAN- RCS CAN- RCS CAN+ 10 47 48 49 50 GND GND GND GND GND 10 47 48 49 50 GROUND GROUND GROUND GROUND GROUND 11 23 29 45 35 HS CAN+ HS CAN- 11 23 HS CAN+ HS CAN- BPP 14 15 ACCR ACCS 14 15 RX IN TX OUT 18 61 57 58 ECT TPS VREF SIG RTN 23 11 1 CAN- CAN+ VSS 36 8 VPWR BPP 37 24 14 26 RCS CAN+ RCS CAN- HS CAN- HS CAN+ 41 3 SIG RTN OSS 41 58 18 CHT SIGRTN ECT 41 61 57 58 29 CHT TPS VREF SIG RTN TFT 43 16 42 15 45 17 28 44 4 27 11 3 41 SSB 43 16 42 15 45 29 17 28 44 46 4 27 11 3 41 SSB (MAIN HARNESS, (MAIN HARNESS, NEAR (MAIN HARNESS, NEAR BREAKOUT (MAIN HARNESS, NEAR BREAKOUT TO (NEAR BREAKOUT (OR (RIGHT SIDE OF TRANSMISSION (SEAT CONTROL FEED JUMPER (UNDER DRIVER'S (W/ A/C PANEL PANEL/FLOOR OFF A/T M/T AIN IN AIR BAG IND AIR CONDITIONING SYSTEM ANTI- THEFT "ON" IND ANTI-THEFT SYSTEM ANTI-THEFT, DOOR LOCKS SYSTEMS POWER WINDOWS SYSTEM DOOR LOCKS SYSTEM AUDIO INPUT JACK AUTO OFF AUTO OFF PARK AUTO OFF PARK HEAD BRAKE SHIFT INTERLOCK BREAKOUT) BRKS BRKL BTS VREF BTS SIG GND GND CAP IND CHECK FUEL CASE GROUND CDB MAP CDC CDA ECT CHARGE HARNESS, NEAR BREAKOUT CHARGE HARNESS, NEAR BREAKOUT TO FUEL INJECTOR 4) CHARGE IND CHARGING CIRCUIT CLIMATE CONTROL ASSEMBLY CLOCK- SPRING CMP CKP- CKP+ COMPUTER DATA LINES SYSTEM CONTROL CIRCUIT CONTROL GND COOLANT TEMPERATURE GAUGE COOLING FANS SYSTEM CPP-BT CPP-TT CRUISE CONTROL SYSTEM CTRL SENSE DEFROST DEF/FLOOR FLOOR DIFFERENTIAL PRESSURE FEEDBACK EGR DK DK LT LT DK LT DOME DEFEAT DOME DEFEAT DOME DOOR AJAR DOOR AJAR IND DOOR AJAR TRANS NEU DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS DOWN UP DPFE IAT DRIVER'S DOOR DRL DRIVER DRV BUCKLE SW EARLY PRODUCTION EPC OSS SIG RTN EPC TCC EPC TCC SSC EVAPCP FCI EVAPCP LCF DPFE EVR VREF SIGRTN EXCEPT STX EXTERIOR LAMPS CIRCUIT FAILSAFE COOLING IND FEPS HS CAN+ HS CAN- FLASH TO PASS FLUID LEVEL/ PARK BRAKE IND BRKL FOG IND FOUR-DOOR MODEL FRONT CIGAR LIGHTER FRONT INTERIOR/ MAP LAMPS ASSEMBLY FRONT WASH 2) OFF 3) INT 1 4) INT 2 5) INT 3 6) INT 4 7) INT 5 8) LOW 9) HIGH FRONT WIPER FUEL GAUGE IND FUEL INJECTOR 3 FUSIBLE LINK A (10 GA- FUSIBLE LINK A (10 GA-DK FUSIBLE LINK B FUSIBLE LINK B (18 GA- FUSIBLE LINK C (20 GA- FUSIBLE LINK C (20 GA- GND GND VPWR VPWR VBATT RX IN TX OUT CAN+ CAN- SENSE GND HS CAN - GND LOW CURRENT BOARD GND MICRO- PROCESSOR GND MTR CW MTR CCW VBATT VBATT HARNESS, NEAR BREAKOUT TO HAZARD OFF HAZARD RIGHT TURN OFF LEFT TURN RIGHT TURN OFF LEFT TURN HEAD PARK HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM INSTRUMENT CLUSTER SYSTEM HEATED OXYGEN HI LO HIGH BEAM IND HIGH MEDIUM HIGH HIGH MOUNTED STOPLAMP HORNS SYSTEM HORNS SYSTEM STARTING/CHARGING SYSTEM HOT AT ALL TIMES HOT IN HOT IN ON OR START HOT IN RUN HOT IN RUN OR ACC HOT IN RUN OR START HOT IN START OR RUN HS CAN + HS CAN - HS CAN CAN HS CAN+ HS HS CAN+ CAN- HS SENSE HTR-11 HTR-11 HTR 21 HTR-12 ILLUMINATION DIMMER IND AIR BAG IND DOOR AJAR IND FOG LAMPS IND O/D OFF IND SAFETY BELT INJ 1 INJ 3 INJ 2 INJ 4 INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS L SPKR + R SPKR + MS CAN- LATE PRODUCTION LEFT HEADLAMP LEFT RIGHT LEFT RIGHT SELECT LEFT TURN SIGNAL IND LEFT UP LOW BRAKE LOW BRAKE FLUID LEVEL/ PARK BRAKE IND LOW CURRENT BOARD LOW CURRENT BOARD CONTROL LOW CURRENT BOARD HS HS CAN + CAN - SENS LOW CURRENT BOARD LOW CURRENT BOARD LOW CURRENT BOARD SENSE LOW CURRENT BOARD SENSE LOW CURRENT BOARD LOW CURRENT BOARD SENSE LOW CURRENT BOARD SENSE LOW CURRENT BOARD SENSE SENSE LOW HIGH LOW OIL PRESSURE IND LOW SENSE CURRENT BOARD LR SN + LF SN - VPWR M/T A/T MAF MAFRTN MAX A/C MAX A/C DEFROST DEF/FLOOR A/C FLOOR PANEL PANEL/FLOOR OFF MEDIUM LOW GND MICRO- PROCESSOR MS CAN + MS CAN + MA CAN - NEU TOW IND O/D OFF IND O/D OFF IND CAN+ ODOMETER/ TRIPMETER OFF AUTO OFF PANEL/FLOOR PANEL FLOOR A/C FLOOR/DEF MAX A/C DEFROST OFF PANEL/FLOOR PANEL FLOOR FLOOR/DEF A/C MAX A/C DEFROST ON OFF OR RUN OSS ISS OTD ELECTRONICS PARK SENSE PARKING BRAKE POS RTN POWER DISTRIBUTION SYSTEM POWER POINT POWER WINDOWS SYSTEM PTC CIRCUIT PTC CIRCUIT BREAKER R SPKR + R SPKR - L SPKR + L SPKR - R SPKR + R SPKR - L SPKR + L SPKR - SHIELD RCS CAN + RCS CAN + GND RCS CAN - VBATT HS CAN + SASB RCS CAN- RCS CAN+ PASS SIDE SENS RTN PASS SIDE SENS FEED RF SN - RIGHT HEADLAMP RIGHT TURN OFF LEFT TURN RIGHT TURN SIGNAL IND RLY CONTACT RR SN - RUN/ PARK RUN/ PARK WIPER SAFETY BELT IND SASA RF SN + RR SN + LR SN - LF SN + SATELLITE RADIO RECEIVER SEAT) SENS SENS SENS SENSE CTRL SENSE GND SENSE RTN RTN SENSE SENSE SENSE SET- SHIFT INTERLOCK SYSTEM SHORTING BAR SHORTING SHORTING BAR BAR SIG SIG VPWR RTN RTN SIGRTN SSA SSB SSC SSD SIGRTN SSA SSB SSC SSD TCC HTR 12 HTR 22 SMART JUNCTION SMR SMC SOLID STATE SPEED CONTROL SPEED CONTROL IND SPEED CONTROL SERVO SSA TSS SSD SSA TSS SSD TFT SSC ISS SSC TCC ISS STAGE 1 STAGE 2 STARTING/ CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ANTI-THEFT SYSTEM SWS VREF SWS SIG SWS GND TC OFF TCS KAPWR VPWR TCS POWER VBATT TCC POWER BPP TEMPERATURE POTENTIOMETER TFT SSD SSC THERMAL LIMITER TP MAP TPMS GND TRAILER TOW CIRCUIT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM MIRRORS SYSTEM TSS SSA SSD SSB TSS SSB SSA UP DN VBATT DRL DRIVER VBATT GND VBATT HS CAN+ HS CAN- VBATT SENSE VBATT SHIELD L SPKR - R SPKR - VDD OUT VOLT SPLY AT ALL TIMES VOLT SPLY IN START OR RUN VOLTAGE SUPPLIED IN RUN VPWR HS CAN- HS CAN+ VPWR VPWR VREF SIGRTN VS OUT VSS SENSE VREF SIG RTN VPWR W/ KEYLESS W/O KEYLESS 2 2 W/ KEYLESS W/O KEYLESS 5 3 1 1 W/ POWER EQUIPMENT WARNING CHIME WIPER/WASHER SYSTEM XIN GND