Ford Ranger II (2006-2009) (under driver's seat) Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 GND ABS CONTROL MODULE (ON LEFT FRONT OF ENGINE COMPT) ABS PUMP MOTOR (AT LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT REAR SIDE OF ENGINE COMPT) FUSE 17 BLK WIRE BLK/YEL WIRE BLU/ORG WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ON BRAKE PEDAL SUPPORT) BRKL BRKS BRN/GRN WIRE COMPUTER DATA LINES SYSTEM EBDWL VBATT FLUID LEVEL STATUS FUSE 20 FUSE 32 FUSE 33 GRN/VIO WIRE GROUND PWR GRY WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER ISO ABS WL GND LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LOW BRAKE FLUID LEVEL/ PARK BRAKE IND MICRO- PROCESSOR ABS IND NCA WIRE REAR AXLE SPEED SENSOR (TOP OF REAR DIFFERENTIAL) RED WIRE RF SN+ RF SN- LF SN+ LF SN- RIGHT FRONT WHEEL SPEED SENSOR RR SN - SENSE SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) VBATT VIO WIRE VIO/RED WIRE VIO/WHT WIRE VPWR RR SN+ WHT WIRE WHT/BRN WIRE WHT/RED WIRE YEL WIRE YEL/GRY WIRE YEL/VIO WIRE

ALL LOCK RELAY PASS DOOR UNLOCK RLY ALL LOCK RELAY PASS DOOR UNLOCK RLY VOLTAGE SUPPLIED IN START ANTI-LOCK BRAKES, SHIFT INTERLOCK SYSTEMS COMPUTER DATA LINES SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/RED WIRE BRN/YEL WIRE CRUISE CONTROL SYSTEM TRANSMISSIONS SYSTEM CRUISE CONTROL SYSTEM WIPER/WASHER SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS ENGINE CONTROLS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM WIPER/WASHER SYSTEM FUSE 1 FUSE 3 FUSE 5 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BRN WIRE GRY/RED WIRE GRY/VIO WIRE HEADLIGHTS SYSTEM INSTRUMENT CLUSTER SYSTEM HEADLIGHTS SYSTEM WIPER/WASHER SYSTEM HORNS SYSTEM STARTING/CHARGING SYSTEM HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS LOW CURRENT BOARD LOW CURRENT BOARD CTRL LOW CURRENT BOARD SENSE LOW CURRENT BOARD SENSE LOW CURRENT BOARD CTRL ORG/ WIRE PARK LAMP RELAY LOW CURRENT BOARD CTRL RED WIRE SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) SOUND SYSTEMS EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM MIRRORS SYSTEM VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE VOLT SPLY AT ALL TIMES VOLT SPLY AT ALL TIMES HORN RELAY SWITCH VOLT SPLY IN START OR RUN VOLTAGE SUPPLIED IN RUN WHT WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE

1 2 CAN+ CAN- 10 9 CAN+ CAN- 11 44 23 CAN+ FEPS CAN- 18 17 CAN+ CAN- 18 9 CAN+ CAN- ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) BLK/WHT WIRE BLK/YEL WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND LEFT CENTER OF DASH) FUSE 29 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER ISO LOW CURRENT BOARD CAN OCCUPANT CLASSIFICATION SENSOR (OCS) MODULE (UNDER PASSENGER`S SEAT) OF CENTER CONSOLE) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RESTRAINTS CONTROL MODULE (UNDER FRONT OF CENTER CONSOLE) SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) WHT WIRE WHT/BLU WIRE

1 2 3 4 5 6 7 8 9 10 SET IND A/T BLK WIRE BLK/GRY WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ON BRN WIRE BRN/GRN WIRE CLOCKSPRING (IN STEERING WHEEL) COAST DEACTIVATOR SWITCH (UNDER LEFT SIDE OF DASH) DK DK LT LT DK GRN WIRE DK LT FUSE FUSE 20 FUSE 26 FUSE 32 GND MICRO- PROCESSOR GRN WIRE GRN/BRN WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN ILLUMINATION INSTRUMENT CLUSTER LOW CURRENT BOARD LT BLU WIRE M/T ON OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE REST RESUME RUN WIRE SENSE SENSE GND SET- SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) SPEED CONTROL IND SPEED CONTROL ON/OFF SWITCH SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPARTMENT) SPEED CONTROL SET/ RESUME SWITCH VBATT VIO WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE VSS VSS SENSE VREF SIG RTN VPWR WHT WIRE YEL WIRE YEL/VIO WIRE

ALL LOCK RELAY BLK WIRE BLU WIRE BLU/GRN WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DRIVER DOOR UNLOCK RELAY DRIVER SIDE DOOR LOCK SWITCH FUSE 11 FUSE 13 FUSE 2 FUSE 1 FUSE 31 FUSE 35 GRN WIRE GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HORN RELAY HORNS SYSTEM HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM LEFT FRONT DOOR AJAR SWITCH LEFT FRONT DOOR LOCK ACTUATOR (REAR OF DRIVER'S DOOR) LOCK LOW CURRENT BOARD ORG/ WIRE PARK LAMP RELAY PASSENGER DOOR UNLOCK RELAY PASSENGER SIDE DOOR LOCK SWITCH RIGHT FRONT DOOR AJAR SWITCH (REAR OF PASSENGER'S DOOR) RIGHT FRONT DOOR LOCK ACTUATOR (REAR OF PASSENGER'S DOOR) SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) UNLOCK UNLOCK VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE

BATTERY JUNCTION BOX (BJB) (LEFT REAR SIDE OF ENGINE COMPT) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) BLK WIRE BLK/GRY WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CONTROL CIRCUIT DEFROST DEF/FLOOR FLOOR DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 13 FUSE 27 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE HIGH MEDIUM HIGH HOT AT ALL TIMES HOT IN RUN ILLUMINATION MAX MEDIUM LOW LOW NORMAL VENT FLOOR/VENT OFF OFF FLOOR VENT A/C MIX RED WIRE SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) TEMPERATURE POTENTIOMETER THERMAL LIMITER VIO WIRE VIO/GRY WIRE VIO/ORG WIRE YEL WIRE YEL/GRN WIRE

14 15 ACCR ACCS 2.3L EXCEPT 2.3L 41 58 18 CHT SIGRTN ECT A/C CLUTCH FIELD COIL (LEFT FRONT OF ENGINE) A/C CLUTCH RELAY A/C COMPRESSOR CYCLING SWITCH (RIGHT REAR OF ENGINE COMPT) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX BATTERY JUNCTION BOX (BJB) (LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CONTROL CIRCUIT CYLINDER-HEAD TEMPERATURE SENSOR (2.3L) (RIGHT SIDE OF CYLINDER HEAD) DEFROST MAX ENGINE CONTROLS SYSTEM ENGINE COOLING FAN MOTOR 1 (RIGHT FRONT OF ENGINE COMPT) ENGINE COOLING FAN RELAY (2.3L) FCI FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 11 FUSE 19 FUSE 25 FUSE 13 FUSE 27 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE HEATER BLOWER MOTOR (RIGHT REAR OF ENGINE COMPT) HIGH MEDIUM HIGH HOT AT ALL TIMES HOT IN HOT IN START OR RUN ILLUMINATION MAX DEFROST DEF/FLOOR NORMAL FLOOR VENT FLOOR/VENT OFF MEDIUM LOW LOW NCA WIRE OFF FLOOR VENT A/C MIX ORG/ WIRE PCM POWER DIODE PCM POWER RELAY POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED WIRE RUN WIRE SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) PTC TEMPERATURE POTENTIOMETER THERMAL LIMITER VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE

10 8 12 1 2 VBATT VPWR VPWR CAN+ CAN- 14 15 RX IN TX OUT ANTI- THEFT "ON" IND BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BREAKER COMPUTER DATA LINES SYSTEM FUSE 10 FUSE 33 FUSE 9 GND VPWR RX TX GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (BOTTOM OF STEERING COLUMN) PCM POWER DIODE PTC CIRCUIT RED WIRE SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE WHT WIRE WHT/BLU WIRE YEL WIRE YEL/ORG WIRE

A/T M/T BLK/YEL WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ON BRAKE PEDAL SUPPORT) BRN/GRN WIRE BRN/YEL WIRE DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) EPC FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 FUSE 32 GRN/BRN WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES HOT IN RUN NCA WIRE OSS ISS POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) SIGRTN SSA SSB SSC SSD TCC HTR 12 SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) TFT TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TSS V VIO/GRN WIRE VIO/GRY WIRE VIO/RED WIRE VIO/WHT WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

A/T M/T BLK/YEL WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ON BRAKE PEDAL SUPPORT) BRN/GRN WIRE BRN/YEL WIRE DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) FUSE 20 FUSE 32 GRN/BRN WIRE GRY WIRE GRY/ORG WIRE GRY/VIO GRY/VIO WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES HOT IN RUN NCA WIRE OSS ISS PCA POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) SIGRTN SSA SSB SSC SSD TCC HTR 12 HTR 22 SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) TFT TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TSS VIO/GRY WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE