Ford Ranger I (1998-2006) pnk/blk Wiring diagrams

BLK WIRE BLU WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (AT BOTTOM OF STEERING COLUMN) DK LT DOOR LOCK/ UNLOCK DRIVER DOOR UNLOCK RELAY DRIVER SIDE DOOR LOCK SWITCH FUSE 1 FUSE 13 FUSE 2 FUSE 31 FUSE 35 GRN WIRE GRY WIRE GRY/RED WIRE HORN RELAY HORNS SYSTEM HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM LEFT FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) LEFT FRONT DOOR LOCK ACTUATOR (W/ POWER EQUIPMENT: AT REAR OF LEFT FRONT DOOR) LOCK LOW CURRENT BOARD LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT PNK WIRE MAIN LIGHT SWITCH ORG/ WIRE PARK LAMP RELAY PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH (4 DOOR) (AT BOTTOM REAR RIGHT REAR DOOR) PNK LT WIRE PNK WIRE PNK/BLK WIRE PNK/ORG WIRE RED WIRE RELAY RIGHT FRONT DOOR LOCK ACTUATOR (W/ POWER EQUIPMENT: AT REAR OF RIGHT FRONT DOOR) SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) UNLOCK W/ POWER EQUIPMENT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

ABS IND. AIR BAG IND ANTI- THEFT "ON" IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE CAN (-) CAN (+) CHARGE IND CHECK ENGINE IND CHECK FUEL CAP IND COMPUTER DATA LINES SYSTEM CONN A CONN B DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR DOOR AJAR IND DRIVER SIDE REAR DOOR AJAR SWITCH (FOUR-DOOR MODEL) ENGINE CONTROLS SYSTEM STARTING/CHARGING SYSTEM ENGINE COOLANT TEMPERATURE GAUGE EXTERIOR LIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM FAILSAFE COOLING IND FUEL GAUGE FUEL TANK UNIT (IN FUEL TANK ASSEMBLY) FUSE 33 FUSE 10 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM CRUISE CONTROL SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION (6 BULBS) INSTRUMENT CLUSTER LEFT FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) LEFT TURN SIGNAL IND LOW BRAKE FLUID LEVEL/PARK BRAKE IND LOW CURRENT BOARD LOW FUEL IND VREF VSS TACH LOW OIL PRESSURE IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MICROPROCESSOR O/D OFF IND ODOMETER/ TRIPMETER ORG/BLK WIRE ORG/LT BLU WIRE PARK LMP RLY OUT PARKING BRAKE SWITCH (BELOW LEFT SIDE OF DASH, ON PARK BRAKE ASSEMBLY) PASSENGER SIDE REAR DOOR AJAR SWITCH (FOUR-DOOR MODEL) (AT BOTTOM REAR OF RIGHT PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) PRNDL REAR DOOR) RED WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH (AT REAR OF RIGHT FRONT RIGHT TURN SIGNAL IND SAFETY BELT IND SIG SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL IND SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM ANTI-THEFT SYSTEM INTERIOR LIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE CONTROLS SYSTEM TACHOMETER TAN/YEL WIRE TONE SIG ECT SIG FUEL LVL SIG VPWR STATUS TRANSMISSIONS SYSTEM VBATT VIO/WHT WIRE W/ POWER EQUIPMENT W/O POWER EQUIPMENT WARNING CHIME WARNING SYSTEM WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BLK WIRE BLU WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (AT BOTTOM OF STEERING COLUMN) DK LT DOOR LOCK/ UNLOCK DRIVER DOOR UNLOCK RELAY DRIVER SIDE DOOR LOCK SWITCH FUSE 1 FUSE 13 FUSE 2 FUSE 31 FUSE 35 GRN WIRE GRY WIRE GRY/RED WIRE HORN RELAY HORNS SYSTEM HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM LEFT FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) LEFT FRONT DOOR LOCK ACTUATOR (W/ POWER EQUIPMENT: AT REAR OF LEFT FRONT DOOR) LOCK LOW CURRENT BOARD LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT PNK WIRE MAIN LIGHT SWITCH ORG/ WIRE PARK LAMP RELAY PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH (4 DOOR) (AT BOTTOM REAR RIGHT REAR DOOR) PNK LT WIRE PNK WIRE PNK/BLK WIRE PNK/ORG WIRE RED WIRE RELAY RIGHT FRONT DOOR LOCK ACTUATOR (W/ POWER EQUIPMENT: AT REAR OF RIGHT FRONT DOOR) SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) UNLOCK W/ POWER EQUIPMENT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

1 1 AIR BAG IND CTRL DEDICATED GROUND DRIVER SAFETY BELT RTN AIR BAG INDICATOR AIR BAG SLIDING CONTACT (AT BOTTOM OF STEERING COLUMN) AIR BAG TONE DRIVER BLK WIRE BLK/WHT WIRE BLK/YEL WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (DLC) (AT BOTTOM OF STEERING COLUMN) DRIVER AIR BAG UNIT (IN STEERING WHEEL) DRIVER SAFETY BELT FEED DRIVER SAFETY BELT RETRACTOR PRETENSIONER (AT LEFT REAR OF VEHICLE FLOOR) FUSE 8 FUSE 9 GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN OR START IGNITION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MICROPROCESSOR NCA WIRE ON OFF ORG/ WIRE ORG/YEL WIRE PASS SAFETY BELT FEED PASS SAFETY BELT RTN PASSENGER AIR BAG DEACTIVATION (PAD) SWITCH PASSENGER AIR BAG MODULE (BEHIND RIGHT SIDE OF DASH) PASSENGER SAFETY BELT RETRACTOR PRETENSIONER (AT RIGHT REAR OF VEHICLE FLOOR) PNK WIRE PNK/BLK WIRE PRETENSIONER RESTRAINTS CONTROL MODULE (UNDER FRONT OF CENTER CONSOLE) SAFETY BELT IND SHORTING BAR SMART JUNCTION BOX (CJB) (BEHIND RIGHT SIDE OF DASH) TONE SIG UNBUCKLED BUCKLED WARNING CHIME WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/T BLK WIRE BLK/WHT WIRE BREAK- OUT) BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR STEPPER MOTOR (ON REAR OF ENGINE) FAIL- SAFE COOL IND FOUR WHEEL DRIVE CONTROL MODULE FUEL INJECTORS FUEL LEV SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT IN RUN INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TACH SIG TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) FUSE 21 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON REAR OF ENGINE) CHT SENSOR CANISTER VENT VSS + A/C CLUTCH RLY DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL TANK PRESS MAP SENS TR SENSOR FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE (TOP RIGHT OF ENGINE) ISS SENS LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MAF SENSOR TPS IN REF VOLTAGE SIG RETURN BPP SW ORG/BLK WIRE ORG/YEL WIRE PCM RLY POWER EGR STEP MOTOR EGR STEP MOTOR FUEL INJ 3 FUEL INJ 1 GND GND PCM RLY POWER EGR STEP MOTOR EGR STEP MOTOR FUEL INJ 4 FUEL INJ 2 PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED SENSOR (TSS) VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

21 BREAKOUT) A/T BLK WIRE BLK/WHT WIRE BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND LEFT CENTER OF DASH) FUEL INJECTORS FUEL LEV SIG TACH SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT IN RUN INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LOW IND LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON TOP REAR OF ENGINE) DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES LT BLU/ ORG WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POSITIVE CRANKCASE VENTILATION HEATER POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) PWR GROUND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BREAKOUT) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EVAP EMISSIONS CANISTER VENT VALVE (AT FUEL TANK) FOUR WHEEL DRIVE CONTROL MODULE (IN RIGHT KICK PANEL) FUEL INJECTORS FUEL LEV SIG TACH SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT IN RUN IGNITION TRANSFORM CAPACITOR INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LOW IND LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL TAN/YEL WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

11 BREAKOUT) A/C SYSTEM AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON TOP REAR OF ENGINE) DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE (ON TOP LEFT REAR OF ENGINE) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE