Ford Ranger I (1998-2006) lt grn/org Wiring diagrams

4 DOOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE DRIVER SIDE REAR DOOR AJAR SWITCH (AT BOTTOM REAR OF LEFT REAR DOOR) FRONT INTERIOR/ MAP LAMPS ASSEMBLY INTERIOR LAMP FUSE 13 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL DIMMING MODULE (BEHIND LEFT SIDE OF DASH) INTERIOR LAMP/ BATTERY SAVER RELAY LEFT FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) LOW CURRENT BOARD LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAP LAMP 1 MAP LAMP 2 ORG/ WIRE PASSENGER SIDE REAR DOOR AJAR SWITCH (AT BOTTOM REAR OF RIGHT REAR DOOR) PNK WIRE RED WIRE RIGHT FRONT DOOR AJAR SWITCH (AT REAR OF RIGHT FRONT DOOR) SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (BJB) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BLU WIRE BOX (SJB)) BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ON BRAKE PEDAL SUPPORT) DK GRN WIRE FUSE 17 FUSE 19 FUSE 20 FUSE 38 FUSE 42 GRN WIRE HAZARD HAZARD OFF HAZARD RIGHT TURN OFF LEFT TURN RIGHT TURN OFF LEFT TURN HIGH MOUNTED STOPLAMP HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LEFT LICENSE PLATE LAMP LEFT REAR PARK/STOP TURN LAMP LEFT TURN INDICATOR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT PNK WIRE MICROPROCESSOR MULTI- FUNCTION SWITCH OFF ORG/ WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK WIRE RED/WHT WIRE RIGHT LICENSE PLATE LAMP RIGHT REAR PARK/STOP TURN LAMP RIGHT TURN INDICATOR RIGHT TURN OFF LEFT TURN RUN WIRE SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) TRAILER TOW CONNECTOR (AT CENTER OF REAR BUMPER) WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE

AIR BAG SLIDING CONTACT (AT BOTTOM AUDIO UNIT BLK WIRE BLK/PNK WIRE BLK/WHT WIRE COURTESY LAMPS CIRCUIT DIMMER SWITCH FOG LAMP SWITCH FOUR- WHEEL DRIVE SWITCH FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE FUSE 1 FUSE 7 GROUND STEERING WHEEL ASSEMBLY HEAD HEAD OFF PARK HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION ILLUMINATION (6 BULBS) INSTRUMENT CLUSTER LOW CURRENT BOARD LT BLU/RED WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MICRO- PROCESSOR OF STEERING COLUMN) OFF PARK ON OFF INSTRUMENT PANEL DIMMING MODULE (BEHIND LEFT SIDE OF DASH) ON/OFF SWITCH ORG/BLK WIRE PARK LAMP RELAY RED/BLK WIRE RED/YEL WIRE SET/ RESUME SWITCH SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL WHT/BLK WIRE

1 2 3 4 5 6 7 8 (-) (+) SHIELD ENABLE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GND VPWR 2 LT ANTENNA AUDIO UNIT BATTERY JUNCTION BOX (BJB) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/PNK WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE ENABLE FUSE 2 FUSE 21 FUSE 24 FUSE 6 GND VBATT R FRONT (+) R FRONT (-) GRN WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE PNK/LT GRN WIRE R REAR AUDIO (+) R REAR AUDIO (-) RADIO AMPLIFIER (BEHIND FRONT SEATS) RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER SMART JUNCTION BOX (SJB) (BEHIND RIGHT SIDE OF DASH) SUBWOOFER TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TWISTED PAIR VIO WIRE VIO/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE

A/T BLK WIRE BLK/WHT WIRE BREAK- OUT) BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR STEPPER MOTOR (ON REAR OF ENGINE) FAIL- SAFE COOL IND FOUR WHEEL DRIVE CONTROL MODULE FUEL INJECTORS FUEL LEV SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT IN RUN INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TACH SIG TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) FUSE 21 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON REAR OF ENGINE) CHT SENSOR CANISTER VENT VSS + A/C CLUTCH RLY DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL TANK PRESS MAP SENS TR SENSOR FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE (TOP RIGHT OF ENGINE) ISS SENS LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MAF SENSOR TPS IN REF VOLTAGE SIG RETURN BPP SW ORG/BLK WIRE ORG/YEL WIRE PCM RLY POWER EGR STEP MOTOR EGR STEP MOTOR FUEL INJ 3 FUEL INJ 1 GND GND PCM RLY POWER EGR STEP MOTOR EGR STEP MOTOR FUEL INJ 4 FUEL INJ 2 PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED SENSOR (TSS) VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

21 BREAKOUT) A/T BLK WIRE BLK/WHT WIRE BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND LEFT CENTER OF DASH) FUEL INJECTORS FUEL LEV SIG TACH SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT IN RUN INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LOW IND LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON TOP REAR OF ENGINE) DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES LT BLU/ ORG WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POSITIVE CRANKCASE VENTILATION HEATER POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) PWR GROUND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BREAKOUT) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CHECK FUEL CAP IND DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EVAP EMISSIONS CANISTER VENT VALVE (AT FUEL TANK) FOUR WHEEL DRIVE CONTROL MODULE (IN RIGHT KICK PANEL) FUEL INJECTORS FUEL LEV SIG TACH SIG FUEL PUMP/ FUEL GAUGE SENSOR FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK ASSEMBLY) FUSE 20 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT IN RUN IGNITION TRANSFORM CAPACITOR INERTIA FUEL SHUT-OFF (IFS) SWITCH (IN RIGHT KICK PANEL) INSTRUMENT CLUSTER LOW CURRENT BOARD LOW IND LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MICROPROCESSOR NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL TAN/YEL WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH (ON STEERING COLUMN) TRANSMISSIONS SYSTEM VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

11 BREAKOUT) A/C SYSTEM AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON TOP REAR OF ENGINE) DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 32 GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE (ON TOP LEFT REAR OF ENGINE) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT, THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SMART JUNCTION BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE