Wiring diagram engine performance 7.3l di turbo diesel for Ford Pickup F350 Super Duty (1999-2012)

224 (A/T) 306 (M/T) A/T AUX TACH FEED AUXILIARY POWERTRAIN CONTROL MODULE (APCM) BLK WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PRESS SW BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CCS SOL CLUTCH PEDAL POSITION (CPP) SWITCH DIESEL FUEL PUMP MOTOR (NEAR FUEL TANK) DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/YEL WIRE EBP SENS ENGINE OIL TEMPERATURE (EOT) SENSOR (TOP FRONT OF ENGINE) EOT FUEL HEATER (ON CENTER OF ENGINE) FUEL HTR FUEL PUMP PWR FUEL PUMP RELAY FUEL RESET IND FUSE 19 FUSE 24 FUSE 27 FUSE 30 BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT) GEN PWR SW GEN SCAN TOOL IN GLOW PLUG MONITOR GRN WIRE GRY WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES FUSE 19 HOT IN RUN OR START JUNCTION BOX FUSE/ RELAY PANEL HOT IN RUN OR START JUNCTION FUSE 30 BOX FUSE/ RELAY PANEL I/P RELAY BOX IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LOWER LEFT SIDE OF DASH) IDM POWER RELAY IND INERTIA FUEL SHUTOFF SWITCH (BEHIND RIGHT KICK PANEL) INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LO CURRENT SENSE LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE M/T MAL- FUNCTION IND MIL IND NCA WIRE NEUTRAL GEAR SW NOT USED ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DIODE PCM POWER RELAY PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER DISTRIBUTION BOX POWER TAKE OFF (SUPPLIED BY BODY BUILDER) PPL PPL 13 10 2 PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SPEED/TACH GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TCIL TCS(A/T)/CPP(M/T) TFT TP SENS WAIT TO WASTEGATE CONTROL SOLENOID (IN CENTER OF ENGINE) WATER IN FUEL IND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

643 224 306 553 307 (A/T) (M/T) A/C SYSTEM AUX TACH FEED CCS SOL CAM POS SENS BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) I/P RELAY BLOCK BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) PCM POWER DIODE BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT) BRN/ORG WIRE BUS (-) BUS (+) DIESEL FUEL PUMP MOTOR (NEAR FUEL TANK) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION 2 10 13 DATA LINK CONNECTOR (BEHIND CENTER OF DASH) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL HEATER/ WATER IN FUEL SENSOR (ON CENTER OF ENGINE) FUEL PUMP RELAY FUSE 24 113 FUSE 27 106 FUSE 19 112 FUSE 30 GLOW PLUG MON GLOW PLUG MON IDLE VALIDATION GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) IDM POWER RELAY LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MIL IND LOW CURRENT SENS NEUTRAL GEAR SW BRAKE WARNING NCA WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER RELAY PICKUP 648 924 795 PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER TAKE OFF (BODY BUILDER) POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE SPEED CTRL IND STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TO DTR SENSOR (DIAGRAM 4 OF 4) TP SENS SPEED/TACH GRD VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (IN CENTER OF ENGINE) WATER IN FUEL IND TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW WCS SOL DSL ELECT DRV WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

A/C HEAD PRES SW ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) ACCL POS SENS ACT SENS AIR CHARGE TEMPERATURE SENSOR (CENTER FRONT OF ENGINE) BARO SENS BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLU WIRE BPP SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (LOWER FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL SYSTEM DATA OUTPUT LINK DIESEL ELECT DRV DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (CENTER REAR OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL PUMP/ SENDER GEN PWR GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM AIR CONDI- TIONING SYSTEM IPR SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (ON RIGHT SIDE OF FIREWALL) MAP SENS NCA WIRE NOT USED ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OSS SENS OUTPUT SHAFT SPEED SENSOR (ON TOP OF TRANS) OVERDRIVE CANCEL SWITCH TCS PCM TO RLY POWER TAKE OFF (SUPP BY BODY BLDR) POWERTRAIN CONTROL MODULE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN SPEED CTRL SW STARTING/ CHARGING SYSTEM TAKE OFF PWR IN TAN/LT GRN WIRE TAN/WHT WIRE TCC TCIL TSS SENS TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANS) VIO WIRE VREF VSS WAIT TO START IND WCS SOL WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (ABOVE CLUTCH PEDAL) OVERDRIVE CANCEL SWITCH CRUISE SET LAMP DK BLU WIRE DK GRN WIRE FUSE FUSE LINK B (12 GA- FUSE LINK D 20 GA- FUSE LINK E 20 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GLOW PLUG RELAY (LEFT SIDE OF ENGINE COMPT) GLOW PLUGS GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HIGH/LOW INDICATOR SWITCH (NEAR DTR SENSOR) HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) IDLE VALIDATION SWITCH (OPEN AT IDLE) (LOWER LEFT SIDE OF DASH) INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER WAIT TO LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION IND MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK/LT GRN WIRE RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/YEL WIRE TACH TAN/LT BLU WIRE TAN/WHT WIRE TCIL TCS VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WATER IN FUEL FUEL RESET LOW WHT LT GRN/ WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECT FEED BACK SIG ELECTRONIC PRESSURE CONTROL SOLENOID FUEL DELIVERY SIG FUEL GAUGE SENDER FUEL INJ FEED FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL INJECTORS FUSE 2 FUSE LINK B (12 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GENERIC ELECTRONIC MODULE (GEM) GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GLOW PLUGS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJ SHIELD GND INJECTOR DRIVER MODULE INSTRUMENT CLUSTER (SPEEDO- METER) JUNCTION BOX FUSE/ RELAY PANEL FUSE 15 JUNCTION BOX FUSE/RELAY PANEL LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, R, 2 P, R, 2, 1 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SIG RTN SIGNAL RETURN SPEED CONTROL SERVO/ AMPLIFIER ASSEMBLY TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

BLK/PNK WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (TOP OF TRANS) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/YEL WIRE SHIELD SHIFT SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (TOP OF TRANS) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE SENSOR (CENTER FRONT OF ENGINE) ANTI-LOCK BRAKE MODULE SYSTEM BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL GAUGE SENDER (PART OF FUEL TANK ASSEMBLY) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUEL PUMP SENDER GLOW PLUG CTRL FUSE 15 FUSE 2 GEM GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAP SENS IDM ENABLE OUT EPC SOL OVERHEAD CONSOLE SYSTEM OVERHEAD CONSOLE, INSTRUMENT CLUSTER PNK/ORG WIRE PNK/YEL WIRE POWER TAKE OFF (BODY BUILDER) POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/ GRY WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS IN VSS OUT WAIT TO START IND PWR IN WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE