Wiring diagram engine performance 6.8l bi-fuel for Ford Pickup F350 Super Duty (1999-2012)

39 679 360 648 1145 1143 570 1028 1030 CUSTOMER ACCESS A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND CASE GND IGN COIL 1 IGN COIL 10 COIL ON PLUG CUSTOMER ACCESS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT PNK/ WIRE FUSE FUSE 24 FUSE 30 FUSE 5 FUSE 7 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) IAT FUEL PUMP MON AC HEAD PRESS SW FUEL INJ 10 DATA OUTPUT INDICATOR SWITCH INSTRUMENT CLUSTER KNOCK SENSOR VSS (-) LOW IND MIL IND LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH (A/T) OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND IGN COIL 5 IGN COIL 7 RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND EPROM PWR TACH TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TEMP OUTPUT VSS EGR SOL TACH TO DTR SENSOR (DIAGRAM 6 OF 6) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

A/C CLUTCH RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COLD COLD START HEATER DIODE (RIGHT REAR OF ENGINE COMPT) COLD START HEATER RELAY (RIGHT REAR OF ENGINE COMPT) CRANKSHAFT POSITION (CKP) SENSOR (FRONT CENTER OF ENGINE) DK BLU WIRE DK BLU/ YEL WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMP GUAGE ENGINE COOLANT TEMPERATURE (ECT) SENDER (TOP FRONT OF ENGINE) FUEL LEVEL IN FUEL PUMP RELAY FUSE 19 GRY WIRE GRY/ORG WIRE GRY/RED WIRE HEATER HEATER HARNESS) HOT AT ALL TIMES HOT AT ALL TIMES FUSE LINK K 12 GA (NEAR STARTER MOTOR) I/P RELAY BLOCK (BEHIND DASH, INSTRUMENT CLUSTER LOCK OFF DIODE (COLD START) (RIGHT REAR OF ENGINE COMPT) LOCK OFF SOLENOID (COLD START) (RIGHT REAR OF ENGINE COMPT) LT BLU/ORG WIRE NCA WIRE NEAR INST PANEL) NOT USED ORG/BLK WIRE ORG/YEL WIRE OVERHEAD CONSOLE PNK WIRE PNK/ ORG WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BRN/ORG WIRE BRN/PNK WIRE DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DUAL TANK SWITCH GRY WIRE GRY/RED WIRE INDICATOR LIGHT SWITCH LOCK OFF DIODE LOCK OFF DIODE (FRONT) LOCK OFF SOLENOID (FRONT) LOCK OFF DIODE (REAR) LOCK OFF SOLENOID LOCK OFF SOLENOID (REAR) LPG SENDER LPG SENDER (FRONT) LPG SENDER (REAR) LPG SENDER RELAY 1 (LEFT REAR OF ENGINE COMPT) LPG SENDER RELAY 2 (LEFT REAR OF ENGINE COMPT) LT BLU/ORG WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/YEL WIRE RELAY DIODE SINGLE TANK SWITCH DIODE TAN/LT BLU WIRE TAN/ORG WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

B(+) BI-FUEL POWER RELAY BI-FUEL RELAY MODULE (LEFT REAR OF ENGINE COMPT) FUSE 1 BLK WIRE BRN/ORG WIRE BRN/PNK WIRE BUS - COLD ST COMPUVALVE MODULE (TOP REAR OF ENGINE) COOL S COOLANT SOLENOID D RESET DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE F CUT F LVL F PUMP F SEND FUEL PUMP CUTOFF RELAY FUSE 2 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HIGH FLOW INJECTOR ASSEMBLY HOT AT ALL TIMES IGN IND SW INJ 1 INJ 2 INJ 3 INJ 4 INJ 5 INJ 6 INJ 7 INJ 8 LK OFF LOW FLOW INJECTOR ASSEMBLY LT BLU/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESISTOR SIG RTN TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TPS RTN USED) (NOT VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DASH RESET DASH RESET RELAY (RIGHT REAR OF ENGINE COMPT) DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE EGR CONTROL SOLENOID (ON LEFT SIDE OF ENGINE) ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) INSTRUMENT CLUSTER LT BLU WIRE LT BLU/ORG WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (TOP OF TRANS) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (TOP OF TRANS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1100 331 A/C SYSTEM 199 481 (A/T) (M/T) BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAM POS IN OSS HEGO 21 MAF SENS IN TP SENS IN CAMSHAFT POSITION SENSOR (CMP) (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) GEM CYL HEAD TEMP DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE EVAP CANISTER PURGE VALVE (RIGHT REAR OF ENGINE COMPARTMENT) FROM DTR SENSOR (DIAGRAM 1 OF 6) FUEL INJ 9 A/C CLTCH RLY FUSE 15 VSS FUSE 20 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEATER CTRL HOT AT ALL TIMES HOT IN KNOCK SENSOR (ON REAR OF ENGINE) HEATED OXYGEN SENSOR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MASS AIRFLOW (MAF) SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE