Manual a/c circuit for Ford Pickup F350 Super Duty (1999-2012)

8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH FIELD COIL (ON A/C COMPRESSOR) A/C CLUTCH RELAY A/C PRESS SWITCH SIG RTN BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CONTROL HARNESS, NEAR BREAKOUT COOLING FAN SPEED SIG DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DUAL PRESSURE SWITCH (RIGHT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (DIESEL) (FRONT OF ENGINE) ELECTRONIC FAN CLUTCH CTRL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (6.0L: FRONT OF ENGINE) EXCEPT DIESEL EXCEPT DIESEL DIESEL FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 17 FUSE 2 FUSE 22 FUSE 23 FUSE 24 FUSE 27 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATER BLOWER MOTOR HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN HOT IN START OR RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) ILLUMINATION LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF VENT MODE SWITCH NCA WIRE NORMAL MAX ORG/ WIRE ORG/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (DIESEL) (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN TAN WIRE TAN/LT GRN WIRE TAN/RED WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 MOTOR- 1 2 3 4 VPWR BATTERY BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLOWER MOTOR (RIGHT END OF HVAC UNIT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF HVAC ASSEMBLY) BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/WHT WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/RED WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE DOOR ACTUATOR (LEFT SIDE OF HVAC ASSEMBLY) EVAP TEMP SENSOR EVAPORATOR TEMPERATURE SENSOR (ON EVAPORATOR) FUSE 23 FUSE 37 FUSE 46 FUSE 50 GND FRONT BLOWER RLY MSCAN+ MSCAN- GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE HIGH CURRENT BATTERY JUNCTION BOX (BJB) (RIGHT SIDE OF ENGINE COMPT) MEGA FUSE HOT AT ALL TIMES HOT IN HOT IN START OR RUN HS CAN + HS CAN - HVAC MODULE MODE 1 ACT FDBK MODE DR 1 CCW MODE DR 1 CW MOTOR NCA WIRE OR RUN ORG/ WIRE PASS TEMP DR CCW PASS TEMP DR CW PASS TEMP ACT FDBK PWM GND RED WIRE RETURN VREF DEFROST REQUEST RIGHT SIDE TEMPERATURE BLEND DOOR ACTUATOR (TOP MIDDLE OF HVAC ASSEMBLY) VBAT VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE

1 2 3 4 5 VPWR VBPWR 28 4 ECT SIG RTN 30 32 CHT E-SIGRTNE 6.2L 6.8L, 6.2L 62 38 62 38 KAPWR PCMRC A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH FIELD COIL (A/C COMPRESSOR) A/C PRESSURE TRANSDUCER (RIGHT FRONT OF ENGINE COMPT) AIR INLET MODE BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/VIO WIRE BLK/YEL WIRE BLU WIRE BLU/GRY WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FAN COOLING FAN (6.2L) (BEHIND RADIATOR) CYLINDER HEAD TEMPERATURE (CHT) SENSOR DOOR ACTUATOR (RIGHT SIDE OF HVAC UNIT) ECT SENSOR ENGINE CONTROLS SYSTEM EXCEPT 6.7L 6.7L FCV FSS FCV VPWR PWRGND FSS PWRGND FUSE 35 FUSE 47 FUSE 72 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES NCA WIRE ORG/ WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED WIRE VBPWR VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE W/ POWER MIRRORS W/O POWER MIRRORS W/ WINDOW ONE TOUCHUP W/O WINDOW ONE TOUCHUP WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE