Ford Pickup F350 Super Duty (1999-2012) vio/lt blu Wiring diagrams

ALL LOCK RELAY ALL UNLOCK RELAY BATTERY JUNCTION BOX (IN LEFT SIDE OF ENGINE COMPT, ON TOP OF WHEELWELL) BLK WIRE BLK/WHT WIRE BRN WIRE DRIVER UNLOCK RELAY FUSE 26 FUSE 8 GENERIC ELECTRONIC MODULE (BEHIND LOWER LEFT SIDE OF DASH) HEAD HOT AT ALL TIMES LEFT FRONT DOOR LOCK ACTUATOR LEFT POWER DOOR LOCK SWITCH LEFT REAR DOOR LOCK ACTUATOR LOCK LT BLU WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH OFF PARK PARK LAMP RELAY PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED/ORG WIRE RELAY BOX (BEHIND CENTER OF DASH) RIGHT FRONT DOOR LOCK ACTUATOR RIGHT POWER DOOR LOCK SWITCH RIGHT REAR DOOR LOCK ACTUATOR TAN/WHT WIRE UNLK VIO/LT BLU WIRE

ALL LOCK RELAY ALL UNLOCK RELAY BATTERY JUNCTION BOX (IN LEFT SIDE OF ENGINE COMPT, ON TOP OF WHEELWELL) BLK WIRE BLK/WHT WIRE BRN WIRE DRIVER UNLOCK RELAY FUSE 26 FUSE 8 GENERIC ELECTRONIC MODULE (BEHIND LOWER LEFT SIDE OF DASH) HEAD HOT AT ALL TIMES LEFT DOOR LOCK ACTUATOR LEFT POWER DOOR LOCK SWITCH LOCK LT BLU WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH OFF PARK PARK LAMP RELAY PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED/ORG WIRE RELAY BOX (BEHIND CENTER OF DASH) RIGHT DOOR LOCK ACTUATOR RIGHT POWER DOOR LOCK SWITCH TAN/WHT WIRE UNLK VIO/LT BLU WIRE

643 224 306 553 307 (A/T) (M/T) A/C SYSTEM AUX TACH FEED CCS SOL CAM POS SENS BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) I/P RELAY BLOCK BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) PCM POWER DIODE BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT) BRN/ORG WIRE BUS (-) BUS (+) DIESEL FUEL PUMP MOTOR (NEAR FUEL TANK) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION 2 10 13 DATA LINK CONNECTOR (BEHIND CENTER OF DASH) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL HEATER/ WATER IN FUEL SENSOR (ON CENTER OF ENGINE) FUEL PUMP RELAY FUSE 24 113 FUSE 27 106 FUSE 19 112 FUSE 30 GLOW PLUG MON GLOW PLUG MON IDLE VALIDATION GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) IDM POWER RELAY LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MIL IND LOW CURRENT SENS NEUTRAL GEAR SW BRAKE WARNING NCA WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER RELAY PICKUP 648 924 795 PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER TAKE OFF (BODY BUILDER) POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE SPEED CTRL IND STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TO DTR SENSOR (DIAGRAM 4 OF 4) TP SENS SPEED/TACH GRD VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (IN CENTER OF ENGINE) WATER IN FUEL IND TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW WCS SOL DSL ELECT DRV WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (ABOVE CLUTCH PEDAL) OVERDRIVE CANCEL SWITCH CRUISE SET LAMP DK BLU WIRE DK GRN WIRE FUSE FUSE LINK B (12 GA- FUSE LINK D 20 GA- FUSE LINK E 20 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GLOW PLUG RELAY (LEFT SIDE OF ENGINE COMPT) GLOW PLUGS GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HIGH/LOW INDICATOR SWITCH (NEAR DTR SENSOR) HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) IDLE VALIDATION SWITCH (OPEN AT IDLE) (LOWER LEFT SIDE OF DASH) INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER WAIT TO LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION IND MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK/LT GRN WIRE RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/YEL WIRE TACH TAN/LT BLU WIRE TAN/WHT WIRE TCIL TCS VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WATER IN FUEL FUEL RESET LOW WHT LT GRN/ WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

BLK/PNK WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (TOP OF TRANS) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/YEL WIRE SHIELD SHIFT SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (TOP OF TRANS) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE SENSOR (CENTER FRONT OF ENGINE) ANTI-LOCK BRAKE MODULE SYSTEM BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL GAUGE SENDER (PART OF FUEL TANK ASSEMBLY) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUEL PUMP SENDER GLOW PLUG CTRL FUSE 15 FUSE 2 GEM GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAP SENS IDM ENABLE OUT EPC SOL OVERHEAD CONSOLE SYSTEM OVERHEAD CONSOLE, INSTRUMENT CLUSTER PNK/ORG WIRE PNK/YEL WIRE POWER TAKE OFF (BODY BUILDER) POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/ GRY WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS IN VSS OUT WAIT TO START IND PWR IN WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

2 10 13 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 224 306 553 307 (A/T) (M/T) A/C SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING BRN/ORG WIRE BUS (-) BUS (+) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION FUSE 22 FUSE 23 GPCM GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT AT ALL TIMES FUSE 105 IDLE VALIDATION IGNITION SWITCH INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LOW CURRENT SENS LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE NEAR BREAK- NOT USED CCS SOL CAM POS SENS ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER DIODE PCM POWER RELAY PICKUP CUSTOMER ACCESS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SPEED CTRL IND STARTING/CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TP SENS SPEED/TACH GND VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (AT TOP REAR OF ENGINE COMPT) WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WCS SOL DSL ELECT DRV WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

A/T BLK/ORG WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/ORG WIRE BRN/RED WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) CNTL OUT DK GRN WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON FRONT OF ENGINE) FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 40 GLOW PLUGS GLW PLG 1 GLW PLG 2 GLW PLG 3 GLW PLG 4 GLW PLG 5 GLW PLG 6 GLW PLG 7 GLW PLG 8 GPCM GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE LINK C (12 GA FUSE LINK D (12 GA INSTRUMENT CLUSTER SPEED CONTROL SET LAMP INSTRUMENT CLUSTER SYSTEM PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE M/T NCA WIRE O/D OFF IND ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH POWER IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/WHT WIRE TCS VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) AUTOMATIC TRANSMISSION MODULE BLK/LT BLU WIRE BLK/PNK WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (ON TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD SHIFT SHIFT SOLENOID SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) AIR INTAKE HEATER BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM CUSTOMER ACCESS DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUSE 34 FUSE 36 FUSE LINK GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD INTAKE AIR HEATER RELAY (AT TOP RIGHT SIDE OF ENGINE) MAP SENS IDM ENABLE OUT EPC SOL PICKUP PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS OUT WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE