Ford Pickup F350 Super Duty (1999-2012) hot in Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 ESOF SOL 1 PNK/ WIRE 7 PNK WIRE ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 19 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VEHICLE SECURITY MODULE VIO/YEL WIRE VSS NEUT SENS LO TO HI HI TO LO ESOF SOL IGN (ST) REF VOLT ISO BUS VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 ESOF SOL 1 PNK/ WIRE 7 PNK WIRE ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 19 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TC NEUT SIG TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VEHICLE SECURITY MODULE VIO/YEL WIRE VSS NEUT SENS LO TO HI HI TO LO ESOF SOL IGN (ST) REF VOLT ISO BUS VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

1908 1909 3600 3601 3602 HI SPD CAN+ HI SPD CAN - BRK PRESS SIG RTN BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BLOCK (LEFT REAR OF ENG COMPT) FUSE 20 BLK WIRE BLK/LT GRN WIRE BRAKE PRESSURE TRANSDUCER BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) CHASSIS CAB COMPUTER DATA LINES SYSTEM DIESEL DK BLU WIRE DK GRN WIRE EXCEPT CHASSIS CAB FUSE 101 FUSE 107 FUSE 20 FUSE 28 FUSE 8 GASOLINE HI CURRENT RTN HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN RUN OR START LT GRN WIRE ORG/ WIRE PCM POWER DIODE PCM POWER RELAY PNK VOLT SPPLY WIRE PNK WIRE RED WIRE RED/WHT WIRE RUN WIRE TAN/YEL WIRE TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR (CENTER OF DASH) TRAILER ELECTRONIC BRAKE CONTROL MODULE (CENTER OF DASH) TRAILER TOW REVERSING LAMP RELAY VIO WIRE VIO/ORG WIRE VOLT SPPLY (RUN) W/ BRAKE CONTROL MODULE W/O BRAKE CONTROL MODULE WHT WIRE WHT/RED WIRE YEL WIRE

ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) AIR BAG SLIDING CONTACT (IN STEERING COLUMN) BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (ON BRAKE MASTER CYLINDER) BRN/WHT WIRE CAN (+) COAST CANCEL SET/ ACCELERATE DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE FUSE 12 FUSE 34 FUSE 45 GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN HOT AT ALL TIMES CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) HOT IN HOT IN START OR RUN INTERIOR HORNS LIGHTS SYSTEM SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE OFF ON RESUME ORG/ WIRE OSS SENS SIG PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) RED WIRE RED/LT GRN WIRE RUN WIRE SIG RTN SPEED CTRL SW IN SPEED CTRL SW RTN STEERING WHEEL/SPEED CONTROL SWITCH TAN WIRE TAN/LT BLU WIRE VREF VSS WHT WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1908 1909 3600 3601 3602 HI SPD CAN+ HI SPD CAN - BRK PRESS SIG RTN BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BLOCK (LEFT REAR OF ENG COMPT) FUSE 20 BLK WIRE BLK/LT GRN WIRE BRAKE PRESSURE TRANSDUCER BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) CHASSIS CAB COMPUTER DATA LINES SYSTEM DIESEL DK BLU WIRE DK GRN WIRE EXCEPT CHASSIS CAB FUSE 101 FUSE 107 FUSE 20 FUSE 28 FUSE 8 GASOLINE HI CURRENT RTN HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN RUN OR START LT GRN WIRE ORG/ WIRE PCM POWER DIODE PCM POWER RELAY PNK VOLT SPPLY WIRE PNK WIRE RED WIRE RED/WHT WIRE RUN WIRE TAN/YEL WIRE TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR (CENTER OF DASH) TRAILER ELECTRONIC BRAKE CONTROL MODULE (CENTER OF DASH) TRAILER TOW REVERSING LAMP RELAY VIO WIRE VIO/ORG WIRE VOLT SPPLY (RUN) W/ BRAKE CONTROL MODULE W/O BRAKE CONTROL MODULE WHT WIRE WHT/RED WIRE YEL WIRE

14 6 22 46 25 32 FAN CLUTCH CTRL FAN CLUTCH SIG SIG RTN VREF SIG RTN SENS SIG 359 3076 (IN ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS) 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH FIELD COIL A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C PRESS SWITCH SIG BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DUAL PRESSURE SWITCH (RIGHT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (DIESEL) (FRONT OF ENGINE) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (6.0L: FRONT OF ENGINE) EXCEPT DIESEL FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT REAR OF ENGINE COMPT) FUSE 17 FUSE 2 FUSE 22 FUSE 23 FUSE 27 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATER BLOWER MOTOR HOT AT ALL TIMES HOT IN HOT IN START OR RUN LT BLU/PNK WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (TOP CENTER OF DASH) TAN/LT GRN WIRE TAN/RED WIRE VACUUM PUMP MOTOR (DIESEL) (RIGHT SIDE OF ENGINE COMPT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH FIELD COIL (ON A/C COMPRESSOR) A/C CLUTCH RELAY A/C PRESS SWITCH SIG RTN BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CONTROL HARNESS, NEAR BREAKOUT COOLING FAN SPEED SIG DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DUAL PRESSURE SWITCH (RIGHT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (DIESEL) (FRONT OF ENGINE) ELECTRONIC FAN CLUTCH CTRL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (6.0L: FRONT OF ENGINE) EXCEPT DIESEL EXCEPT DIESEL DIESEL FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 17 FUSE 2 FUSE 22 FUSE 23 FUSE 24 FUSE 27 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATER BLOWER MOTOR HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN HOT IN START OR RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) ILLUMINATION LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF VENT MODE SWITCH NCA WIRE NORMAL MAX ORG/ WIRE ORG/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (DIESEL) (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN TAN WIRE TAN/LT GRN WIRE TAN/RED WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 MOTOR- 1 2 3 4 VPWR BATTERY BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLOWER MOTOR (RIGHT END OF HVAC UNIT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF HVAC ASSEMBLY) BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/WHT WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/RED WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE DOOR ACTUATOR (LEFT SIDE OF HVAC ASSEMBLY) EVAP TEMP SENSOR EVAPORATOR TEMPERATURE SENSOR (ON EVAPORATOR) FUSE 23 FUSE 37 FUSE 46 FUSE 50 GND FRONT BLOWER RLY MSCAN+ MSCAN- GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE HIGH CURRENT BATTERY JUNCTION BOX (BJB) (RIGHT SIDE OF ENGINE COMPT) MEGA FUSE HOT AT ALL TIMES HOT IN HOT IN START OR RUN HS CAN + HS CAN - HVAC MODULE MODE 1 ACT FDBK MODE DR 1 CCW MODE DR 1 CW MOTOR NCA WIRE OR RUN ORG/ WIRE PASS TEMP DR CCW PASS TEMP DR CW PASS TEMP ACT FDBK PWM GND RED WIRE RETURN VREF DEFROST REQUEST RIGHT SIDE TEMPERATURE BLEND DOOR ACTUATOR (TOP MIDDLE OF HVAC ASSEMBLY) VBAT VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE

BLK LT BLU/ WIRE BLK WIRE BLK/ORG WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) CHECK ENGINE IND COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (ON THROTTLE BODY) FROM PCM POWER RELAY (DIAGRAM 5 OF 5) FUEL LVL FUEL PUMP DRIVER MODULE (LEFT REAR FRAME RAIL) FUEL PUMP RELAY FUSE 24 FUSE 34 FUSE 40 FUSE 45 HEATED OXYGEN SENSOR HOT AT ALL TIMES HOT IN HOT IN ON OR START HS CAN+ INERTIA FUEL SHUT-OFF (IFS) SWITCH (RIGHT KICK PANEL) INSTRUMENT CLUSTER KNOCK SENSOR 1 (ON RIGHT CYLINDER HEAD) KNOCK SENSOR 2 (TOP LEFT REAR OF ENGINE) LT BLU/ BLK WIRE LT BLU/ORG WIRE NCA WIRE PNK/BLK WIRE RED WIRE RED/ LT GRN WIRE RED/LT GRN WIRE RED/YEL WIRE RETURN RUN WIRE TAN/WHT WIRE TAN/YEL WIRE TOW/HAUL SWITCH VARIABLE CAMSHAFT TIMING (VCT) SOLENOID 2 (LEFT BANK) (LEFT FRONT TOP OF ENGINE) VIO/LT GRN WIRE VPWR W/ NARROW FRAME W/ WIDE FRAME WHT WIRE WHT/BLK WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

1100 331 A/C SYSTEM 199 481 (A/T) (M/T) BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAM POS IN OSS HEGO 21 MAF SENS IN TP SENS IN CAMSHAFT POSITION SENSOR (CMP) (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) GEM CYL HEAD TEMP DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE EVAP CANISTER PURGE VALVE (RIGHT REAR OF ENGINE COMPARTMENT) FROM DTR SENSOR (DIAGRAM 1 OF 6) FUEL INJ 9 A/C CLTCH RLY FUSE 15 VSS FUSE 20 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEATER CTRL HOT AT ALL TIMES HOT IN KNOCK SENSOR (ON REAR OF ENGINE) HEATED OXYGEN SENSOR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MASS AIRFLOW (MAF) SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE