Ford Pickup F350 Super Duty (1999-2012) fuse 2 Wiring diagrams

14 6 22 46 25 32 FAN CLUTCH CTRL FAN CLUTCH SIG SIG RTN VREF SIG RTN SENS SIG 359 3076 (IN ENGINE CONTROL SENSOR, FUEL CHARGE HARNESS) 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH FIELD COIL A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C PRESS SWITCH SIG BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DUAL PRESSURE SWITCH (RIGHT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (DIESEL) (FRONT OF ENGINE) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (6.0L: FRONT OF ENGINE) EXCEPT DIESEL FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT REAR OF ENGINE COMPT) FUSE 17 FUSE 2 FUSE 22 FUSE 23 FUSE 27 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATER BLOWER MOTOR HOT AT ALL TIMES HOT IN HOT IN START OR RUN LT BLU/PNK WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (TOP CENTER OF DASH) TAN/LT GRN WIRE TAN/RED WIRE VACUUM PUMP MOTOR (DIESEL) (RIGHT SIDE OF ENGINE COMPT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH FIELD COIL (ON A/C COMPRESSOR) A/C CLUTCH RELAY A/C PRESS SWITCH SIG RTN BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CONTROL HARNESS, NEAR BREAKOUT COOLING FAN SPEED SIG DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DUAL PRESSURE SWITCH (RIGHT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (DIESEL) (FRONT OF ENGINE) ELECTRONIC FAN CLUTCH CTRL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (6.0L: FRONT OF ENGINE) EXCEPT DIESEL EXCEPT DIESEL DIESEL FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 17 FUSE 2 FUSE 22 FUSE 23 FUSE 24 FUSE 27 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATER BLOWER MOTOR HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN HOT IN START OR RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) ILLUMINATION LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF VENT MODE SWITCH NCA WIRE NORMAL MAX ORG/ WIRE ORG/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (DIESEL) (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN TAN WIRE TAN/LT GRN WIRE TAN/RED WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

ADJUSTABLE PEDAL SWITCH (W/O MEMORY) AUXILIARY RELAY BOX 1 (BEHIND LEFT CENTER OF DASH) BATTERY BATTERY II (DIESEL) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/PNK WIRE DK BLU/ORG WIRE DRIVER SIDE FRONT HEATED SEAT RELAY ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE EXTERIOR REAR VIEW MIRROR SWITCH FROM FUSE 10 (DIAGRAM 1 OF 5) FROM FUSE 16 (DIAGRAM 1 OF 5) FRONT CIGAR LIGHTER FUSE 1 FUSE 10 FUSE 11 FUSE 111 (NOT USED) FUSE 114 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 18 FUSE 19 FUSE 2 FUSE 20 FUSE 21 FUSE 34 FUSE 4 FUSE 6 FUSE 602 (NOT USED) FUSE 7 FUSIBLE LINK A FUSIBLE LINK B GRY WIRE INDICATOR FLASHER RELAY INSTRU- MENT PANEL POWER POINT INSTRUMENT CLUSTER LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH NCA WIRE ORG/LT GRN WIRE PASSENGER SIDE FRONT SEAT ADJUST SWITCH PNK WIRE PNK/WHT WIRE RADIO RED WIRE RED/ LT GRN WIRE RED/BLK WIRE RED/LT BLU WIRE STARTER MOTOR TAN/WHT WIRE TO FUSE 1 (DIAGRAM 5 OF 5) TO FUSE 12 (DIAGRAM 1 OF 5) TO FUSIBLE LINKS (DIAGRAM 2 OF 5) TRAILER BRAKE CONTROL MODULE W/ POWER EQUIPMENT W/ REMOTE KEYLESS ENTRY WHT LT BLU/ WIRE

A/C CLUTCH RELAY ABS CONTROL MODULE AUXILIARY RELAY BOX 3 (EXCEPT DIESEL: LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT REAR OF ENGINE COMPT) BLK WIRE BLOWER MOTOR RELAY DAYTIME RUNNING LAMPS RESISTOR DIESEL DK GRN WIRE EVAP CANISTER VENT CONTROL SOLENOID FROM FUSIBLE LINK B (DIAGRAM 1 OF 5) FUEL INJECTOR CONTROL MODULE (FICM) RELAY (DIESEL) FUSE 1 FUSE 10 FUSE 13 FUSE 14 (NOT USED) FUSE 16 (NOT USED) FUSE 17 FUSE 18 FUSE 18 SHUNT FUSE 19 (NOT USED) FUSE 2 FUSE 22 FUSE 23 FUSE 3 FUSE 4 (NOT USED) FUSE 5 FUSE 6 (NOT USED) FUSE 7 (NOT USED) FUSE 9 GASOLINE LEFT TURN TRAILER TOW RELAY LT GRN WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) RED WIRE RIGHT TURN TRAILER TOW RELAY TAN WIRE TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VIO WIRE WHT WIRE WINDSHIELD WIPER MOTOR YEL WIRE

AIR BAG SLIDING CONTACT (IN STEERING COLUMN) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DRIVER SIDE FRONT DOOR AJAR SWITCH (IN DRIVER'S DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (W/ CREW CAB) FUSE 2 FUSE 33 FUSE 45 HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER KEY WARNING SWITCH LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE PASSENGER SIDE FRONT DOOR AJAR SWITCH (IN FRONT PASSENGER'S DOOR) PASSENGER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE RED WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (BEHIND CENTER OF DASH) SAFETY BELT BUCKLE SWITCH (IN DRIVER'S SEAT BELT BUCKLE) W/ POWER EQUIPMENT W/O POWER EQUIPMENT YEL WIRE

AIR BAG SLIDING CONTACT (IN STEERING COLUMN) AUTO PARK BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DRIVER SIDE FRONT DOOR AJAR SWITCH (IN DRIVER'S DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (W/ CREW CAB) FUSE 102 FUSE 19 FUSE 2 FUSE 33 FUSE 45 FUSE 7 GRY WIRE GRY/RED WIRE HEAD OFF HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER KEY WARNING SWITCH LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE ORG/ WIRE PASSENGER SIDE FRONT DOOR AJAR SWITCH (IN FRONT PASSENGER'S DOOR) PASSENGER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (BEHIND CENTER OF DASH) SAFETY BELT BUCKLE SWITCH (IN DRIVER'S SEAT BELT BUCKLE) VEHICLE SECURITY MODULE (VSM) (BEHIND LEFT SIDE OF DASH) W/ POWER EQUIPMENT W/O POWER EQUIPMENT WHT WIRE YEL WIRE YEL/BLK WIRE

B(+) BI-FUEL POWER RELAY BI-FUEL RELAY MODULE (LEFT REAR OF ENGINE COMPT) FUSE 1 BLK WIRE BRN/ORG WIRE BRN/PNK WIRE BUS - COLD ST COMPUVALVE MODULE (TOP REAR OF ENGINE) COOL S COOLANT SOLENOID D RESET DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE F CUT F LVL F PUMP F SEND FUEL PUMP CUTOFF RELAY FUSE 2 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HIGH FLOW INJECTOR ASSEMBLY HOT AT ALL TIMES IGN IND SW INJ 1 INJ 2 INJ 3 INJ 4 INJ 5 INJ 6 INJ 7 INJ 8 LK OFF LOW FLOW INJECTOR ASSEMBLY LT BLU/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESISTOR SIG RTN TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TPS RTN USED) (NOT VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECT FEED BACK SIG ELECTRONIC PRESSURE CONTROL SOLENOID FUEL DELIVERY SIG FUEL GAUGE SENDER FUEL INJ FEED FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL INJECTORS FUSE 2 FUSE LINK B (12 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GENERIC ELECTRONIC MODULE (GEM) GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GLOW PLUGS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJ SHIELD GND INJECTOR DRIVER MODULE INSTRUMENT CLUSTER (SPEEDO- METER) JUNCTION BOX FUSE/ RELAY PANEL FUSE 15 JUNCTION BOX FUSE/RELAY PANEL LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, R, 2 P, R, 2, 1 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SIG RTN SIGNAL RETURN SPEED CONTROL SERVO/ AMPLIFIER ASSEMBLY TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE SENSOR (CENTER FRONT OF ENGINE) ANTI-LOCK BRAKE MODULE SYSTEM BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL GAUGE SENDER (PART OF FUEL TANK ASSEMBLY) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUEL PUMP SENDER GLOW PLUG CTRL FUSE 15 FUSE 2 GEM GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAP SENS IDM ENABLE OUT EPC SOL OVERHEAD CONSOLE SYSTEM OVERHEAD CONSOLE, INSTRUMENT CLUSTER PNK/ORG WIRE PNK/YEL WIRE POWER TAKE OFF (BODY BUILDER) POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/ GRY WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS IN VSS OUT WAIT TO START IND PWR IN WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE