Ford Pickup F350 Super Duty (1999-2012) dk blu/yel Wiring diagrams

4-WHEEL DRIVE CONTROL, PATS, EATC MODULE ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) APP BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (AT FLOOR, IN LEFT FRONT FOOTWELL) BRN/ORG WIRE BRN/WHT WIRE CCS APP TCS TFT IAT CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK DK DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 36 FUSE 45 GRN WIRE GROUND TCC VBATT OSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR GROUND EPC TSS APP VREF SIG RTN BPP SW VPWR GROUND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVR SOLENOID VALVE (CALIFORNIA) (AT REAR OF ENGINE) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

199 352 1102 91 1100 331 (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 4 TCC SOL KAP B(+) VAPOR VALVE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 NOT USED PWR GND IGN COIL 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION CONTROL MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROLLER FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION) VAPOR MANAGEMENT VALVE (AT REAR ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

199 352 1102 91 1100 331 (CALIF) 2/1 A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CYL HEAD TEMP CANISTER VENT FUEL INJ 9 A/C CLTCH RLY CYLINDER HEAD TEMPERATURE (CHT) SENSOR DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE EXCURSION FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 7 TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T M/T LT MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE NOT USED PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C CLUTCH RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COLD COLD START HEATER DIODE (RIGHT REAR OF ENGINE COMPT) COLD START HEATER RELAY (RIGHT REAR OF ENGINE COMPT) CRANKSHAFT POSITION (CKP) SENSOR (FRONT CENTER OF ENGINE) DK BLU WIRE DK BLU/ YEL WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMP GUAGE ENGINE COOLANT TEMPERATURE (ECT) SENDER (TOP FRONT OF ENGINE) FUEL LEVEL IN FUEL PUMP RELAY FUSE 19 GRY WIRE GRY/ORG WIRE GRY/RED WIRE HEATER HEATER HARNESS) HOT AT ALL TIMES HOT AT ALL TIMES FUSE LINK K 12 GA (NEAR STARTER MOTOR) I/P RELAY BLOCK (BEHIND DASH, INSTRUMENT CLUSTER LOCK OFF DIODE (COLD START) (RIGHT REAR OF ENGINE COMPT) LOCK OFF SOLENOID (COLD START) (RIGHT REAR OF ENGINE COMPT) LT BLU/ORG WIRE NCA WIRE NEAR INST PANEL) NOT USED ORG/BLK WIRE ORG/YEL WIRE OVERHEAD CONSOLE PNK WIRE PNK/ ORG WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BRN/ORG WIRE BRN/PNK WIRE DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DUAL TANK SWITCH GRY WIRE GRY/RED WIRE INDICATOR LIGHT SWITCH LOCK OFF DIODE LOCK OFF DIODE (FRONT) LOCK OFF SOLENOID (FRONT) LOCK OFF DIODE (REAR) LOCK OFF SOLENOID LOCK OFF SOLENOID (REAR) LPG SENDER LPG SENDER (FRONT) LPG SENDER (REAR) LPG SENDER RELAY 1 (LEFT REAR OF ENGINE COMPT) LPG SENDER RELAY 2 (LEFT REAR OF ENGINE COMPT) LT BLU/ORG WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/YEL WIRE RELAY DIODE SINGLE TANK SWITCH DIODE TAN/LT BLU WIRE TAN/ORG WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

B(+) BI-FUEL POWER RELAY BI-FUEL RELAY MODULE (LEFT REAR OF ENGINE COMPT) FUSE 1 BLK WIRE BRN/ORG WIRE BRN/PNK WIRE BUS - COLD ST COMPUVALVE MODULE (TOP REAR OF ENGINE) COOL S COOLANT SOLENOID D RESET DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE F CUT F LVL F PUMP F SEND FUEL PUMP CUTOFF RELAY FUSE 2 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HIGH FLOW INJECTOR ASSEMBLY HOT AT ALL TIMES IGN IND SW INJ 1 INJ 2 INJ 3 INJ 4 INJ 5 INJ 6 INJ 7 INJ 8 LK OFF LOW FLOW INJECTOR ASSEMBLY LT BLU/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESISTOR SIG RTN TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TPS RTN USED) (NOT VIO/ORG WIRE WHT WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DASH RESET DASH RESET RELAY (RIGHT REAR OF ENGINE COMPT) DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE EGR CONTROL SOLENOID (ON LEFT SIDE OF ENGINE) ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) INSTRUMENT CLUSTER LT BLU WIRE LT BLU/ORG WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (TOP OF TRANS) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (TOP OF TRANS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

A/C HEAD PRES SW ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) ACCL POS SENS ACT SENS AIR CHARGE TEMPERATURE SENSOR (CENTER FRONT OF ENGINE) BARO SENS BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLU WIRE BPP SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (LOWER FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL SYSTEM DATA OUTPUT LINK DIESEL ELECT DRV DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (CENTER REAR OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL PUMP/ SENDER GEN PWR GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM AIR CONDI- TIONING SYSTEM IPR SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (ON RIGHT SIDE OF FIREWALL) MAP SENS NCA WIRE NOT USED ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OSS SENS OUTPUT SHAFT SPEED SENSOR (ON TOP OF TRANS) OVERDRIVE CANCEL SWITCH TCS PCM TO RLY POWER TAKE OFF (SUPP BY BODY BLDR) POWERTRAIN CONTROL MODULE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN SPEED CTRL SW STARTING/ CHARGING SYSTEM TAKE OFF PWR IN TAN/LT GRN WIRE TAN/WHT WIRE TCC TCIL TSS SENS TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANS) VIO WIRE VREF VSS WAIT TO START IND WCS SOL WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE