Ford Pickup F250 Super Duty (1999-1999) hot in run or start Wiring diagrams

AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 24 BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND PWR GND TCIL EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CIRCUIT DATA DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK LT DLC (-) DLC (+) PWR GND ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GEM, RABS MODULE, SHIFT LOCK ACTUATOR, RAP MODULE, CLUTCH PEDAL POSITION SWITCH GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TCSS RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS (SS) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSFER CASE SPEED SENSOR (LEFT REAR OF TRANS) TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

5.4L AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CIRCUIT COAST CLUTCH CONTROL CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DLC (-) DLC (+) CCS TCS ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 24 FUSE 29 FUSE 30 GEM, RABS MODULE, SHIFT LOCK ACTUATOR, RAP MODULE, CLUTCH PEDAL POSITION SWITCH GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR OR NGV TIMER INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NGV MODULE (FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIN 3 FOR 5.4L NGV PNK PNK PNK WIRE PNK TCSS WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE SHIFT CONTROL 1 SHIFT CONTROL 2 TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA TFT IAT TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 24 BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND TCIL EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CIRCUIT CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DATA DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DK PNK/ PNK WIRE DLC (-) DLC (+) TCS ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GEM, RABS MODULE, SHIFT LOCK ACTUATOR, RAP MODULE, CLUTCH PEDAL POSITION SWITCH GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS (SS) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCSS TFT IAT TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

5.4L AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CIRCUIT COAST CLUTCH CONTROL CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DLC (-) DLC (+) CCS TCS ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 24 FUSE 29 FUSE 30 GEM, RABS MODULE, SHIFT LOCK ACTUATOR, RAP MODULE, CLUTCH PEDAL POSITION SWITCH GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR OR NGV TIMER INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NGV MODULE (FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIN 3 FOR 5.4L NGV PNK PNK PNK WIRE PNK TCSS WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE SHIFT CONTROL 1 SHIFT CONTROL 2 TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA TFT IAT TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

608 649 INDICATOR DRIVER GROUND AIR BAG INDICATOR AIR BAG SLIDING CONTACT BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DRIVER AIR BAG FUSE 22 FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PASSENGER AIR BAG PASSENGER AIR BAG DEACTIVATION SWITCH PNK WIRE PNK/BLK WIRE RED WIRE RED/LT GRN WIRE RESTRAINTS CONTROL MODULE (BEHIND CENTER OF DASH) SHORTING BAR TAN WIRE TONE REQUEST VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE

13 4 16 IGN BAT BAT 875 875 14 26 GROUND GROUND BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX FUSE 30 DK BLU/WHT WIRE DK GRN/LT GRN WIRE FUSE 15 FUSE 18 FUSE 20 FUSE 6 FUSE 8 HEAD OFF PARK (1999) (2000) HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START IGN IGNITION KEY WARNING SWITCH (INSIDE STEERING ASSEMBLY) INSTRUMENT CLUSTER FASTEN BELTS INDI- CATOR LEFT DOOR AJAR SWITCH RIGHT DOOR AJAR SWITCH LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH NCA WIRE PNK WIRE RED WIRE RUN WIRE SEAT BELT WARNING SWITCH (IN SEAT BELT BUCKLE) WHT/RED WIRE YEL WIRE

820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF ACCEL SIG AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP- CKP+ DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DLC ELECTRONIC SUSPENSION SYSTEM FUSE 30 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 29 IAT FUEL PUMP MON ACCS TP OUT PCM DATA OUT IGNITION COILS 1, 2 IGNITION COILS 3, 4 INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD COMMUNICATOR (IMCC) CONTROL (ON RIGHT SIDE OF ENGINE) INTAKE MANIFOLD EVR CTRL KS SENSOR LT BLU/BLK WIRE LT GRN WIRE MAF TFT NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY FUSE 2 PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND CASE GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RADIO NOISE CAPACITOR 1 RADIO NOISE CAPACITOR 2 RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SPARK PLUGS TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

820 OHMS AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE CASE GND IGN COIL 1 IGN COIL 5 CCS CKP(+) CKP(-) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK (-) DATA LINK (+) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/YEL WIRE FUSE 2 FUSE 29 FUSE 30 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON A/C ON SIG IMCC LT BLU WIRE LT BLU/BLK WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT NCA WIRE NGV TIMER (LEFT REAR OF ENGINE COMPT) OD OFF ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/WHT WIRE TCIL IND DLC TCS TO DTR SENSOR (DIAGRAM 5 OF 5) TRANSMISSION CONTROL INDICATOR LAMP TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE YEL/BLK WIRE

5 6 7 8 PNK WIRE 820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CCS CKP(+) CKP(-) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 29 IAT FUEL PUMP MON ACCS IGNITION COILS INTAKE MANIFOLD COMMUNICATOR (IMCC) CONTROL (ON RIGHT SIDE OF ENGINE) INTAKE MANIFOLD EVR CTRL KS SENSOR LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT LT LT DK LT LT LT LT MAF TFT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY FUSE 2 PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (ON TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (ON TOP LEFT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL TC SPD SENS PNK WIRE SHIFT SOL TRANS CTRL IND DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE