Ford Pickup F150 (1996-2012) hot at all times Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 INTERIOR LIGHTING (FET) FOG LAMP RELAY AIR CONDITIONING, HEADLIGHTS SYSTEMS ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) BRN/RED WIRE BRN/YEL WIRE BSI (FET) COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES, ELECTRONIC POWER STEERING SYSTEMS GRN WIRE GRN/RED WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/VIO WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM OFF POWER DISTRIBUTION SYSTEM RED WIRE RUN WIRE SHIFT INTERLOCK SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM EXTERIOR LIGHTS, NAVIGATION, SOUND SYSTEMS VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WARNING SYSTEMS POWER DISTRIBUTION SYSTEM WHT WIRE WHT/ORG WIRE WHT/RED WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 RIGHT LOW BEAM (FET) LEFT LOW BEAM (FET) HORN RLY BATTERY PLUS BLK WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) BRN WIRE BRN/BLU WIRE BRN/VIO WIRE BRN/YEL WIRE DOOR LOCKS, ANTI THEFT SYSTEMS INTERIOR LIGHTS SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS INTERIOR LIGHTS SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS NAVIGATION SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS NAVIGATION, SOUND SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS POWER WINDOWS SYSTEM DRIVER DOOR LOCK, ALL LOCK/UNLOCK RLY DRIVER DOOR UNLOCK RLY BATTERY SAVER RELAY FOG LAMP RELAY FUSIBLE LINK A FUSIBLE LINK B (12 GA- GRN WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/RED WIRE GRY/VIO WIRE HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS INTERIOR LIGHTS SYSTEMS LOGIC GND ALL LOCK/UNLOCK RELAY NOT USED NOT USED POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM EXTERIOR LIGHTS SYSTEM POWER WINDOWS SYSTEM MEMORY SYSTEMS RED WIRE RIGHT HI BEAM (FET) LEFT HI BEAM (FET) SIGRTN BRAKE FLUID SW HS CAN + HS CAN - RUN/START FET VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREF BCS ENERGY MGT (FET) SECURITY HORN (FET) BATTERY SAVER RELAY WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/RED WIRE YEL/VIO WIRE

ABS CONTROL MODULE (IN LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) CENTRAL TIMER MODULE (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FUSE 3 GENERIC ELECTRONIC MODULE (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE PNK(OR PNK) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPT) RADIO REAR INTEGRATED CONTROL PANEL (RICP) RESTRAINTS CONTROL MODULE (BEHIND LOWER CENTER OF DASH) TAN WIRE TAN(OR WIRE TAN/ORG WIRE VIO WIRE W/ RSE HARLEY DAVIDSON W/ RSE PNK WIRE W/O CENTRAL TIMER MODULE WHT LT BLU/ WIRE WHT WIRE

5.4L CNG 5.4L NGV ABS CONTROL MODULE (IN LEFT SIDE OF ENGINE COMPT) ALTERNATIVE FUEL CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) CENTRAL TIMER MODULE (BEHIND LEFT SIDE OF DASH) COMPUVALVE MODULE (CNG/LPG) (IN RIGHT REAR OF ENGINE COMPT) DATA LINK CONNECTOR (NEAR CENTER OF DASH) FUSE 3 GENERIC ELECTRONIC MODULE (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE NATURAL GAS VEHICLE (NGV) MODULE (ON RIGHT FRONT OF ENGINE COMPT) PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPT) RESTRAINTS CONTROL MODULE (BEHIND LOWER CENTER OF DASH) TAN/ORG WIRE VIO WIRE W/O CENTRAL TIMER MODULE WHT WIRE

AUTOMATIC A/C BATTERY JUNCTION BOX (BJB) BLK WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/YEL WIRE DEFROST DRIVER EXTERIOR REAR VIEW MIRROR EMTC HVAC MODULE FUSE 32 FUSE 54 (FRONT OF ENGINE COMPT) FUSE 56 GRY WIRE HIGH CURRENT SWITCH HOT AT ALL TIMES HOT IN START OR RUN HVAC MODULE MANUAL A/C ORG/ WIRE PASSENGER EXTERIOR REAR VIEW MIRROR REAR WINDOW DEFROST GRID REAR WINDOW DEFROST RELAY RED WIRE REQUEST STATUS VIO WIRE W/ NAVIGATION W/ REAR WINDOW DEFROST GRID W/ REAR WINDOW SLIDER W/O NAVIGATION WHT WIRE WHT/ORG WIRE YEL WIRE

1 999 140 HORNS SYSTEM 1/2 1/2 3/4 7/8 9/0 3 9 AJAR OUT ILLUM IN 3/4 5/6 7/8 8 7 LFT RT DOOR AJAR 9/0 AUTOLAMPS BATTERY JUNCTION BOX (BJB) (IN LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) DIAGNOSTIC DK BLU WIRE DOORS LOCK DRIVER SIDE DOOR LOCK SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH EXCEPT SUPERCREW FUSE 115 FUSE 15 FUSE 29 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GROUND 15 HORN DR AJAR SW REVERSE HOT AT ALL TIMES HOT IN START OR RUN KEY PAD SWITCH ASSEMBLY KEYPAD ILLUM LEFT FRONT DOOR AJAR SWITCH LEFT FRONT DOOR LOCK ACTUATOR LEFT REAR DOOR LOCK ACTUATOR LOCK LOCK IN/OUT LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT PNK WIRE NCA WIRE ORG/ WIRE PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH PNK PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT FRONT DOOR LOCK ACTUATOR RIGHT REAR DOOR LOCK ACTUATOR SUPERCREW UNLK UNLOCK IN/OUT ILLUM ENTRY DOORS UNLOCK BATTERY GROUND VPWR BPP SW IN WHT WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

820 OHMS O/D OFF A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP- CKP+ DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DLC EVR CTRL FUSE 2 FUSE 29 FUSE 30 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS IMRC IGNITION COIL IGNITION TRANSFORMER CAPACITOR 1 IMRC INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD RUNNER CONTROL (IMRC) (ON RIGHT SIDE OF ENGINE) KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE MAF TFT NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND CASE GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP TRANSMISSION CONTROL SWITCH (A/T) TRANSMISSION SYSTEM VIO WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL/BLK WIRE

21 22 23 24 25 26 27 PNK WIRE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/WHT WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CHECK FUEL CAP INDICATOR CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (RIGHT SIDE OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK) FUSE 10 FUSE 18 GENERIC ELECTRONIC MODULE/ CENTRAL TIMER MODULE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (AT FUEL TANK) LT BLU/ORG WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSFER CASE SPEED SENSOR VIO WIRE VIO/ORG WIRE VSS INPUT WHT/LT GRN WIRE

A/C CLUTCH RELAY A/T M/T BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CPP (M/T) DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY IND LP CTRL VPWR DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL TANK PRESS FUSE 15 FUSE 2 FUSE 20 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES HOT IN IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK 30 31 32 33 34 35 WIRE PNK SPEED SENSOR WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE REF VOLTAGE BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) VAPOR VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

3 4 5 PNK WIRE AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CAPACITOR 2 (LEFT FRONT OF ENGINE) CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK PNK WIRE FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS IGNITION TRANS- FORMER IGNITION TRANS- FORMER CAPACITOR 1 (RIGHT FRONT OF ENGINE) IMCC EVR CTRL (4.6L) IND INSTRUMENT CLUSTER SYSTEM KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE NOT USED NOT USED CKP(+) CKP(-) OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 3 PWR GND TCSS PNK WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) TRANSMISSION SYSTEM VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE