Ford Pickup F150 (1996-2012) engine controls system Wiring diagrams

43 59 38 HS CAN+ HS CAN+ PCMRC BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPARTMENT) BLK WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/GRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) ENGINE CONTROLS SYSTEM FLOOR SHIFTER FUSE 26 FUSE 34 FUSE 77 FUSE 79 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN HEATED OXYGEN SENSOR HOT AT ALL TIMES NCA WIRE OSS TSS T-SIGRTN OUTPUT SHAFT SPEED (OSS) SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH (STEERING COLUMN) PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) STARTING/ CHARGING SYSTEM TCCS EPCS TFT TCS TFT EPCS TCCS TURBINE SHAFT SPEED (TSS) SENSOR (LEFT SIDE OF TRANSMISSION) VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE W/ COLUMN SHIFTER W/ FLOOR SHIFTER WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/WHT WIRE BRN/GRN WIRE BRN/RED WIRE BU RELAY + COMPUTER DATA LINES SYSTEM ENGINE CONTROLS SYSTEM FLOOR SHIFTER FUSE 26 FUSE 53 FUSE 76 GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HEATED OXYGEN HEATED OXYGEN SENSOR HOT AT ALL TIMES HOT IN RUN OR START HOT W/ PCM POWER RELAY ENERGIZED HS CAN+ NCA WIRE OVERDRIVE CANCEL SWITCH (STEERING COLUMN) PARK/ NEUTRAL POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) SIGRTN TCS TRANSMISSION (LEFT REAR OF TRANSMISSION) VBATT VPWR WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL/GRN WIRE YEL/RED WIRE

10 9 MS CAN + MS CAN - 15 64 CHT E SIG RTN 2 4 3 6 5 VPWR FSS VBPWR FC V FSS GND 34 1 12 2 38 FC V VBPWR FSS ACCR PCMRC 4.6L 2V 43 59 31 52 58 HS CAN - HS CAN + ACPT VREF SIG RTN A/C CLUTCH DIODE A/C CLUTCH RELAY A/C PRESSURE TRANSDUCER SENSOR AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) AUTOLAMP/SUNLOAD SENSOR (CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/GRY WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRY WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION ELECTRONIC FAN CLUTCH (TOP RIGHT FRONT OF ENGINE) ENGINE COMPT) ENGINE CONTROLS SYSTEM FUSE FUSE 30 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HARNESS, NEAR HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) INSTRUMENT CLUSTER MICROPROCESSOR ORG/ WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

12 13 HS CAN + HS CAN - 3.5L 6.2L A/C CLUTCH RELAY A/C COMPRESSOR A/C COMPRESSOR CLUTCH FIELD COIL AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK/GRY WIRE BLU WIRE BLU/GRY WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM ENGINE COMPT) ENGINE CONTROLS SYSTEM EXCEPT 6.2L FUSE FUSE 30 FUSE 34 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE HOT AT ALL TIMES IN-VEHICLE TEMPERATURE/ HUMIDITY SENSOR (LEFT SIDE OF DASH) INSTRUMENT CLUSTER ORG/ WIRE PCM POWER RELAY RED WIRE VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE

10 9 MS CAN + MS CAN - 15 64 CHT E SIG RTN 2 4 3 6 5 VPWR FSS VBPWR FC V FSS GND 34 1 12 2 38 FC V VBPWR FSS ACCR PCMRC 4.6L 2V 43 59 31 52 58 HS CAN - HS CAN + ACPT VREF SIG RTN A/C CLUTCH DIODE (EARLY PRODUCTION) A/C CLUTCH RELAY A/C COMPRESSOR A/C COMPRESSOR CLUTCH FIELD COIL A/C PRESSURE TRANSDUCER SENSOR AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/GRY WIRE BLU WIRE BLU/BLK WIRE BLU/GRY WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION ELECTRONIC FAN CLUTCH (TOP RIGHT FRONT OF ENGINE) ENGINE COMPT) ENGINE CONTROLS SYSTEM EVAPORATIVE TEMPERATURE SENSOR (RIGHT SIDE OF DASH) FUSE FUSE 30 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER MICROPROCESSOR ORG/ WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE GROUND GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE 130 OHMS 154 OHMS 93.1 OHMS 2940 OHMS 931 OHMS 4010 OHMS 736 OHMS 422 OHMS 226 OHMS 53.6 OHMS AIR BAG SLIDING CONTACT (ON STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BJB) (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE CONTROLS SYSTEM FAN- TEMP+ FUSE 1 FUSE 22 FUSE 31 FUSE 38 FUSE 7 GRY/BLK WIRE GRY/LT BLU WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT W/ ACC DELAY RELAY ENERGIZED ILLUM LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS FUSE IGN LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE MEDIA NEXT NAVIGATION SYSTEM NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE POWER POWER SUBWOOFER(+) SUBWOOFER(-) SHIELD POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SIG RTN SIGNAL SIGNAL RETURN MUTE SIGNAL LF SPKR (-) LR SPKR (-) RR SPKR (-) SUBWOOFER TAN WIRE TAN/YEL WIRE TEMP FAN TWISTED PAIR VIO WIRE VIO/LT BLU WIRE VOL VOL WHT/LT GRN WIRE XL, STX YEL WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE 130 OHMS 154 OHMS 93.1 OHMS 2940 OHMS 931 OHMS 4010 OHMS 736 OHMS 422 OHMS 226 OHMS 53.6 OHMS AIR BAG SLIDING CONTACT (ON STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BJB) (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE CONTROLS SYSTEM FAN- TEMP+ FUSE 1 FUSE 22 FUSE 31 FUSE 38 FUSE 7 GRY/BLK WIRE GRY/LT BLU WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT W/ ACC DELAY RELAY ENERGIZED ILLUM LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS FUSE IGN LF SPKR- LR SPKR- RR SPKR- LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE MEDIA NEXT NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE POWER POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SIG RTN SIGNAL SIGNAL RETURN SUBWOOFER SUBWOOFER (-) SUBWOOFER (+) SHIELD TAN WIRE TAN/YEL WIRE TEMP FAN TWISTED PAIR VIO WIRE VIO/LT BLU WIRE VOL VOL WHT/LT GRN WIRE XL, STX YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LEFT SIG(+) LEFT SIG(-) 1 2 3 4 5 6 7 8 9 10 ENABLE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE 154 OHMS 19 57 INTERIOR LIGHTS SYSTEM 226 OHMS 4010 OHMS 736 OHMS 422 OHMS 53.6 OHMS 130 OHMS 931 OHMS 931 OHMS 2940 OHMS A/C SYSTEM AIR BAG SLIDING CONTACT (ON STEERING COLUMN) ANTENNA AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN/ORG WIRE BRN/PNK WIRE CAN-BUS CAN-BUS CENTRAL JUNCTION BOX (BJB) (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE CONTROLS SYSTEM FAN FUSE 1 FUSE 22 FUSE 31 FUSE 38 FUSE 7 GRD GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT W/ ACC DELAY RELAY ENERGIZED ILLUM INTERIOR LIGHTS SYSTEM (NEAR BREAKOUT TO IGNITION SWITCH) L+ R+ MS CAN- LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS FUSE IGN LF SPKR- LR SPKR- RR SPKR- LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MEDIA NEXT MS CAN + NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE POWER POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG(+) RIGHT SIG(-) SATELLITE AUDIO RECEIVER SIG RTN SIGNAL SIGNAL RETURN SUBWOOFER SUBWOOFER (-) SUBWOOFER (+) SHIELD TAN WIRE TAN/YEL WIRE TEMP TEMP FAN TWISTED PAIR TWISTED PAIR (MAIN WIRING HARN, NEAR BREAKOUT TO AUDIO UNIT) 167 168 57 173 TWISTED PAIR 690 799 TWISTED PAIR 832 833 TWISTED PAIR 856 798 VIO WIRE VIO/LT BLU WIRE VOL (-) VPWR GRD L- R- WHT/LT GRN WIRE XL, STX YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 CDDJL (+) CDDJL (-) ILLUM (+) 1 2 3 4 5 6 7 8 9 10 ENABLE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE 19 57 INTERIOR LIGHTS SYSTEM AUDIO CONTROL MODULE (ACM) (BEHIND CENTER OF DASH) AUDIO INPUT JACK AUXILIRY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (NEAR RIGHT "A" PILLAR) DIODE DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM FUSE 1 FUSE 22 FUSE 38 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT W/ ACCESSORY DELAY RELAY ENERGIZED IGNITION SWITCH LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS LF SPKR- LR SPKR- RR SPKR- LOCK LR SPKR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PARKING AID MODULE (UNDER LEFT END OF DASH) PNK RR SPKR (-) MS CAN (+) MS CAN (-) WIRE PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE REVERSE IN RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RR SPKR RR SPKR (+) LR SPKR (+) LR SPKR (-) CDDJR (+) CDDJR (-) RUN WIRE SIGNAL SIGNAL RETURN SUBWOOFER SUBWOOFER(+) SUBWOOFER(-) TAN WIRE TAN/YEL WIRE TWISTED PAIR WIRES VBATT VIO WIRE VIO/LT BLU WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE XL, STX YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 CDDJL (+) CDDJL (-) ILLUM (+) 1 2 3 4 5 6 7 8 9 10 ENABLE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE AUDIO CONTROL MODULE (BEHIND CENTER OF DASH) AUDIO INPUT JACK AUXILIARY RELAY BOX 1 (LEFT SIDE OF BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BJB) (NEAR RIGHT "A" PILLAR) DIODE DK BLU WIRE DK BLU/ORG WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE CONTROLS SYSTEM FUSE 1 FUSE 22 FUSE 38 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT W/ ACCESSORY DELAY RELAY ENERGIZED IGNITION SWITCH LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS LF SPKR- LR SPKR- RR SPKR- LOCK LR SPKR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PARKING AID MODULE (UNDER LEFT END OF DASH) PNK RR SPKR (-) MS CAN (+) MS CAN (-) WIRE PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RR SPKR RR SPKR (+) LR SPKR (+) LR SPKR (-) CDDJR (+) CDDJR (-) RUN WIRE SIGNAL SIGNAL RETURN SUBWOOFER SUBWOOFER(+) SUBWOOFER(-) TAN WIRE TAN/YEL WIRE TWISTED PAIR WIRES VBATT VIO WIRE VIO/LT BLU WIRE WHT WIRE WHT/LT GRN WIRE XL, STX YEL WIRE