Ford Pickup F150 (1996-2012) engine compt) Wiring diagrams

2 1 3 BST GND BST SIG BST PWM ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/YEL WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE VACUUM PUMP (LEFT FRONT CORNER OF ENGINE COMPT) BRN WIRE BRN/GRN WIRE BST GND BST SIG COMPUTER DATA LINES SYSTEM ENGINE COMPT) EVP HS CAN YAW + LOGIC GND FUSE 47 FUSE 52 FUSE 54 FUSE 36 FUSE 64 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN HS CAN YAW - VALVE B+ HS CAN + LEFT FRONT WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LEFT REAR WHEEL SPEED SENSOR (LEFT REAR WHEEL HUB ASSEMBLY) LR SENS HIGH LF SENS LOW MOTOR GND HS CAN - NCA WIRE ORG/ WIRE RED WIRE RF SENS HIGH RR SENS HIGH LR SENS LOW LF SENS HIGH RF SENS LOW RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) RIGHT REAR WHEEL SPEED SENSOR (RIGHT REAR WHEEL HUB ASSEMBLY) RR SENS LOW RUN WIRE VACUUM PUMP RELAY (3.5L) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE

10 9 MS CAN + MS CAN - 15 64 CHT E SIG RTN 2 4 3 6 5 VPWR FSS VBPWR FC V FSS GND 34 1 12 2 38 FC V VBPWR FSS ACCR PCMRC 4.6L 2V 43 59 31 52 58 HS CAN - HS CAN + ACPT VREF SIG RTN A/C CLUTCH DIODE A/C CLUTCH RELAY A/C PRESSURE TRANSDUCER SENSOR AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) AUTOLAMP/SUNLOAD SENSOR (CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/GRY WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRY WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION ELECTRONIC FAN CLUTCH (TOP RIGHT FRONT OF ENGINE) ENGINE COMPT) ENGINE CONTROLS SYSTEM FUSE FUSE 30 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HARNESS, NEAR HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) INSTRUMENT CLUSTER MICROPROCESSOR ORG/ WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

12 13 HS CAN + HS CAN - 3.5L 6.2L A/C CLUTCH RELAY A/C COMPRESSOR A/C COMPRESSOR CLUTCH FIELD COIL AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK/GRY WIRE BLU WIRE BLU/GRY WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM ENGINE COMPT) ENGINE CONTROLS SYSTEM EXCEPT 6.2L FUSE FUSE 30 FUSE 34 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE HOT AT ALL TIMES IN-VEHICLE TEMPERATURE/ HUMIDITY SENSOR (LEFT SIDE OF DASH) INSTRUMENT CLUSTER ORG/ WIRE PCM POWER RELAY RED WIRE VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE

10 9 MS CAN + MS CAN - 15 64 CHT E SIG RTN 2 4 3 6 5 VPWR FSS VBPWR FC V FSS GND 34 1 12 2 38 FC V VBPWR FSS ACCR PCMRC 4.6L 2V 43 59 31 52 58 HS CAN - HS CAN + ACPT VREF SIG RTN A/C CLUTCH DIODE (EARLY PRODUCTION) A/C CLUTCH RELAY A/C COMPRESSOR A/C COMPRESSOR CLUTCH FIELD COIL A/C PRESSURE TRANSDUCER SENSOR AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/GRY WIRE BLU WIRE BLU/BLK WIRE BLU/GRY WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION ELECTRONIC FAN CLUTCH (TOP RIGHT FRONT OF ENGINE) ENGINE COMPT) ENGINE CONTROLS SYSTEM EVAPORATIVE TEMPERATURE SENSOR (RIGHT SIDE OF DASH) FUSE FUSE 30 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER MICROPROCESSOR ORG/ WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE

3/4 1/2 7/8 5/6 9/10 AJAR ANTENNA/RECEIVER INTERNAL ANTI-THEFT HOOD SWITCH (LEFT SIDE OF BLK WIRE BLK/GRN WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BRN WIRE COMPUTER DATA LINES SYSTEM ENGINE COMPT) GRN WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE HOOD AJAR HOT AT ALL TIMES BODY CONTROL MODULE (RIGHT KICK PANEL) MICRO FUSE 18 KEYLESS ENTRY KEYPAD KEYPAD ILLUM (FET) KEYPAD PAD LEFT FRONT DOOR LATCH LF KEYPAD DOOR PAD AJAR MS CAN + ORG/ WIRE RED WIRE TIRE PRESSURE MONITOR (TPM) MODULE (RIGHT END OF DASH) VIO WIRE VIO/ORG WIRE WHT WIRE YEL WIRE

3.5L 3.7L AAT AMBIENT AIR TEMPERATURE (AAT) SENSOR (FRONT OF ENGINE COMPT) BLK/GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SWITCH (BRAKE FLUID RESERVOIR) C-SIGRTN COMPUTER DATA LINES SYSTEM ENGINE COMPT) ENGINE CONTROLS SYSTEM GRN WIRE GRN/BLU WIRE GRN/VIO WIRE GRY WIRE GRY/VIO WIRE HS CAN+ LEFT FRONT DOOR LATCH LEFT LEFT REAR DOOR AJAR SWITCH (LEFT REAR DOOR) REAR DOOR LATCH OPS PARKING BRAKE SWITCH POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF RIGHT FRONT DOOR LATCH RIGHT REAR DOOR AJAR SWITCH (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH SUPER CAB SUPER CREW W/ POWER EQUIPMENT SUPER CREW W/ POWER SUPER CAB EQUIPMENT W/ POWER EQUIPMENT W/O POWER EQUIPMENT WHT WIRE WHT/BLU WIRE WHT/VIO WIRE YEL WIRE YEL/GRY WIRE YEL/VIO WIRE

10 9 MS CAN + MS CAN - 15 64 CHT E SIG RTN 2 4 3 6 5 VPWR FSS VBPWR FC V FSS GND 34 1 12 2 38 FC V VBPWR FSS ACCR PCMRC 43 59 31 52 58 HS CAN - HS CAN + ACPT VREF SIG RTN A/C CLUTCH DIODE A/C CLUTCH RELAY A/C PRESSURE TRANSDUCER SENSOR BATTERY JUNCTION BOX (BJB) (FRONT OF BLK WIRE BLK/GRN WIRE BLK/GRY WIRE BLU WIRE BLU/BLK WIRE BLU/GRY WIRE BLU/RED WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION ELECTRONIC FAN CLUTCH (TOP RIGHT FRONT OF ENGINE) ENGINE COMPT) EVAPORATIVE TEMPARATURE SENSOR (RIGHT SIDE OF DASH) FUSE FUSE 30 FUSE FUSE GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER MICROPROCESSOR PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE

3/4 1/2 7/8 5/6 9/10 AJAR ANTENNA/RECEIVER INTERNAL ANTI-THEFT HOOD SWITCH (LEFT SIDE OF BLK WIRE BLK/GRN WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BRN WIRE COMPUTER DATA LINES SYSTEM ENGINE COMPT) GRN WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE HOOD AJAR HOT AT ALL TIMES BODY CONTROL MODULE (RIGHT KICK PANEL) MICRO FUSE 18 KEYLESS ENTRY KEYPAD KEYPAD ILLUM (FET) KEYPAD PAD LEFT FRONT DOOR LATCH LF KEYPAD DOOR PAD AJAR MS CAN + ORG/ WIRE RED WIRE TIRE PRESSURE MONITOR (TPM) MODULE (RIGHT END OF DASH) VIO WIRE VIO/ORG WIRE WHT WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE COMPT) FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (ON THROTTLE BODY) INSTRUMENT CLUSTER SYSTEM LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/WHT WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (LEFT REAR CORNER OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE COMPT) FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (ON THROTTLE BODY) INSTRUMENT CLUSTER SYSTEM LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/WHT WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (LEFT REAR CORNER OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE