Ford Pickup F150 (1996-2012) blower motor relay Wiring diagrams

1 2 3 4 5 6 7 15 16 17 18 19 20 SCP- VBATT GND SIG RTN 2 10 DATA LINK CONNECTOR (DLC) (NEAR CENTER OF DASH) 23 24 25 26 SPEED CTRL 41 69 SIG RTN A/C RLY GND A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR OF ENGINE COMPT) A/C CLUTCH FIELD COIL A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 4 (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (IN LEFT SIDE OF ENGINE COMPT) BLEND DOOR CTRL ILLUM VEH TEMP INPUT REAR WINDOW DEF CTRL BLEND DR ACT CTRL BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER BLOWER MOTOR RELAY BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX BOX (CJB) (UNDER LEFT SIDE OF DASH) DEFOGGER SYSTEM DK BLU/LT GRN WIRE DK BLU/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) FUSE 105 FUSE 13 FUSE 2 FUSE 23 FUSE 24 GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-VEHICLE TEMPERATURE SENSOR LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/ORG WIRE ORG/ WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPT) RED/WHT WIRE RED/YEL WIRE SIG RTN SUNLOAD SENSOR (ON TOP RIGHT SIDE OF DASH) TAN/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) VIO WIRE VPWR VREF TEMP INPUT SCP+ VPWR BLOWER RLY CTRL TEMP INPUT ILLUM SUNLOAD SEN INPT WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE

1 2 3 4 MTR CTRL GND VBC VPWR 1250 1551 1255 SEATS SYSTEM 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 VBATT AIR INLET MODE DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) ANTI-THEFT SYSTEM AUTOLAMP/SUNLOAD SENSOR (TOP LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (BEHIND DASH) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROLLER (RIGHT "A" PILLAR) BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (NEAR RIGHT "A" PILLAR) CONTROL SOLID STATE DEFOGGER SYSTEM DEFROST REQ FEED B FEED A FEED B FEED A VREF RLY SW PWR DEFROST/PANEL/FLOOR MODE ACTUATOR (BEHIND CENTER OF DASH) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DRV HI STATUS DRV LO STATUS DRV HEATED SEAT REQ FEED B FEED A SIG FEEDBACK VREF RTN VPWR FUSE 116 FUSE 13 FUSE 5 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN HVAC MODULE (EATC) IN-CAR TEMP SENS RTN IN-VEHICLE TEMPERATURE SENSOR (BEHIND DASH PANEL) LIGHT SENSOR (-) LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/RED WIRE PATS IND PNK WIRE PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/WHT WIRE RLY CTRL SEATS SYSTEM SENS SUN SENSOR TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) VEHICLE SECURITY MODULE (SUPER CAB/SUPER CREW: LEFT REAR OF CAB) VIO WIRE VIO/WHT WIRE VPWR GND WHT WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE

2 1 4 3 MOTOR - GND MOTOR + PWM AMBIENT TEMP SEN AUTOLAMP SENSOR IN BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLK WIRE BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF DASH) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE ACTUATOR (CENTER OF DASH) DOOR CCW DOOR CW GND BLOWER RELAY MS CAN+ MS CAN- EVAPORATIVE TEMPERATURE SENSOR (RIGHT SIDE OF DASH) FUSE FUSE 15 FUSE 51 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HVAC MODULE (EATC) IN CAR TEMP SEN LEFT TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF DASH) ORG/ WIRE PASS DOOR CCW PASS DOOR CW PASS SEAT REQ DRV SEAT REQ EVAP TEMP SENSOR ACT FDBK MODE 1 ACT FDBK PASS SUNLOAD LOW STATUS HIGH STATUS DRIVER SUNLOAD LOW STATUS HIGH STATUS PASS TEMP ACT RED WIRE RETURN VREF DEFROST REQ VBATT BLOWER CONTROL RECIRC CW RECIRC CCW RIGHT TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) SEATS SYSTEM SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) TEMPERATURE SENSOR VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

2 1 4 3 MOTOR - GND MOTOR + PWM AIR BAG MODULE AUTOLAMP SENSOR IN AUTOLAMP/SUNLOAD SENSOR (CENTER OF DASH) BLK WIRE BLK/WHT WIRE BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF DASH) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE ACTUATOR (CENTER OF DASH) DOOR CCW DOOR CW GND BLOWER RELAY MS CAN+ MS CAN- EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF DASH) FUSE 46 FUSE 52 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE FUSE 51 COMPT) HOT IN RUN OR START HS CAN CAN HUMIDITY SENS TEMP SENS LEFT TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF DASH) ORG/ WIRE PASS DOOR CCW PASS DOOR CW PASS SUNLOAD LOW STATUS HIGH STATUS DRIVER SUNLOAD LOW STATUS HIGH STATUS PASS TEMP ACT RED WIRE RIGHT TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) SEATS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

2 1 4 3 MOTOR - GND MOTOR + PWM AMBIENT TEMP SEN AUTOLAMP SENSOR IN AUTOLAMP/SUNLOAD SENSOR (CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLK WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF DASH) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE ACTUATOR (CENTER OF DASH) DOOR CCW DOOR CW GND BLOWER RELAY MS CAN+ MS CAN- FUSE FUSE 51 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HVAC MODULE (EATC) IN CAR TEMP SEN LEFT TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF DASH) ORG/ WIRE PASS DOOR CCW PASS DOOR CW PASS SEAT REQ DRV SEAT REQ EVAP TEMP SEN ACT FDBK MODE 1 ACT FDBK PASS SUNLOAD LOW STATUS HIGH STATUS DRIVER SUNLOAD LOW STATUS HIGH STATUS PASS TEMP ACT RED WIRE RIGHT TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) RLY SW PWR VREF DEFROST REQUEST VBATT SEATS SYSTEM SMART JUNCTION BOX (SJB) (RIGHT KICK PANEL) VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

2 1 4 3 MOTOR - GND MOTOR + PWM AUTOLAMP SENSOR IN AUTOLAMP/SUNLOAD SENSOR (CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF DASH) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE DEFOGGER SYSTEM DEFROST/PANEL/FLOOR MODE ACTUATOR (CENTER OF DASH) DOOR CCW DOOR CW GND BLOWER RELAY MS CAN+ MS CAN- FUSE FUSE 51 FUSE 52 GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START HS CAN CAN HUMIDITY SENS TEMP SENS LEFT TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF DASH) ORG/ WIRE PANEL/FLOOR MODE DOOR ACTUATOR PASS DOOR CCW PASS DOOR CW PASS SUNLOAD LOW STATUS HIGH STATUS DRIVER SUNLOAD LOW STATUS HIGH STATUS PASS TEMP ACT RED WIRE RIGHT TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) SEATS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR OF ENGINE COMPARTMENT) A/C CLUTCH FIELD COIL A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE AUXILIARY RELAY BOX 4 (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (IN LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (IN LEFT SIDE OF ENGINE COMPARTMENT) FUSE 105 BLK WIRE BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR (NEAR BLOWER MOTOR) BLOWER MOTOR SWITCH HI BRN WIRE EXCEPT 4.2L,5.4L NGV 4.2L,5.4L NGV FLOOR/ VENT OFF VENT FLOOR MIX NORMAL DEF MAX FRONT BLOWER MOTOR FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 13 FUSE 23 FUSE 24 FUSE 5 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) HOT IN RUN OR START ILLUMI- NATION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MED HI MED LO OFF FLOOR/VENT VENT FLOOR NORMAL MIX MAX DEFROST ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPT) RED WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE WHT WIRE YEL WIRE YEL/RED WIRE

62 62 3.7L 5.0L, 6.2L ACC/RUN BATTERY CHARGE TRAILER TOW RELAY (7-PIN TRAILER TOW) BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLOWER MOTOR RELAY BLU WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) BRAKE SHIFT INTERLOCK BRN WIRE EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (EXCEPT 3.5L) EXCEPT 3.5L 3.5L FLOOR SHIFTER FROM BODY CONTROL MODULE (BCM) (DIAGRAM 1 OF 7) FROM FUSE 65 (DIAGRAM 1 OF 7) FUEL PUMP RELAY FUSE FUSE 21 FUSE 26 FUSE 27 FUSE 30 FUSE 13 FUSE 32 FUSE 34 FUSE 43 FUSE 45 FUSE 49 FUSE 51 FUSE 73 GRN WIRE GRY WIRE IGNITION SWITCH KEY IN KEY-IN IGNITION SWITCH LEFT TURN TRAILER TOW RELAY LOCK MICRO - NCA WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) REAR WINDOW DEFROST RELAY RED WIRE REVERSING LAMPS RELAY RIGHT TURN TRAILER TOW RELAY RUN WIRE START/RUN STARTER A/C RELAY CLUTCH RELAY TO BATTERY JUNCTION BOX (BJB) (DIAGRAM 7 OF 7) TO FUSE 18 (DIAGRAM 5 OF 7) VACUUM PUMP RELAY (3.5L) VIO WIRE W/ COLUMN SHIFTER W/ FLOOR SHIFTER WHT WIRE WIPER RELAY YEL WIRE

ANTI-LOCK BRAKE SYSTEM (ABS) MODULE BATTERY JUNCTION BOX (BJB) (FRONT OF ENGINE COMPT) BLOWER MOTOR RELAY BLU WIRE BODY CONTROL MODULE (RIGHT KICK PANEL) MICRO BRN WIRE CAMERA SWITCHING MODULE CAMERA WASHER RELAY (DIAGRAM 5 OF 7) FLOOR SHIFTER FROM FUSE 31 (DIAGRAM 5 OF 7) FROM FUSE 42 (DIAGRAM 5 OF 7) FRONT VIDEO CAMERA FUSE 33 FUSE 35 FUSE 36 FUSE 37 FUSE 41 FUSE 42 FUSE 53 FUSE 54 FUSE 52 GRN WIRE GRY WIRE HAZARD/ PAD/ TRACTION SWITCH HEATED SEAT MODULE (IF EQUIPPED) HILL DESCENT CONTROL SWITCH (W/ SVT RAPTOR) LEFT REAR HEATED SEAT MODULE (SUPER CREW) NCA WIRE NEAR BREAKOUT TO OCCUPANT CLASSIFICATION SYSTEM MODULE (OCSM) OFF-ROAD MODE SWITCH (W/ SVT RAPTOR) ORG/ WIRE PARKING AID MODULE (PAM) POWER STEERING CONTROL MODULE (PSCM) POWERTRAIN CONTROL MODULE (PCM) RAPTOR REAR WINDOW DEFROST RELAY RED WIRE RELAY RESTRAINTS CONTROL MODULE (RCM) RUN/ RUN/ FUSE 34 (FET) TELEMATICS MODULE (CREW CHIEF) TO FRONT TO UPFITTER SWITCH (DIAGRAM 5 OF 7) TOW HAUL SWITCH (W/ COLUMN SHIFTER) TRAILER BRAKE CONTROL (TBC) MODULE TRANSFER CASE CONTROL MODULE (TCCM) (W/ ELECTRONIC SHIFT ON THE FLY) VIDEO CAMERA (W/ REAR VIEW CAMERA) VIO WIRE VIO/ORG WIRE W/ COLUMN SHIFTER W/ FLOOR SHIFTER W/ FRONT CAMERA W/ REAR VIEW CAMERA WHT WIRE YEL WIRE