Ford Pickup F150 (1996-2012) air conditioning system Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 VREF GND UBP BUS VREF VREF 1/2 3/4 5/6 7/8 9/0 AIR CONDITIONING SYSTEM AUTOLAMPS ON BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/ORG WIRE DRIVER SIDE DOOR LOCK SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH (SUPER CREW) (IN LEFT REAR DOOR) FUSE 107 FUSE 18 JUNCTION BOX (CJB) (NEAR RIGHT "A" PILLAR) FUSE 40 FUSE 6 HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION KEYPAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH (IN LEFT FRONT DOOR) LEFT FRONT DOOR LOCK ACTUATOR (IN LEFT FRONT DOOR) LEFT REAR DOOR LOCK ACTUATOR (IN LEFT REAR DOOR) LOCK UNLOCK LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE ORG/ WIRE PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH (SUPER CREW) (IN RIGHT REAR DOOR) PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH (IN RIGHT FRONT DOOR) RIGHT FRONT DOOR LOCK ACTUATOR (IN RIGHT FRONT DOOR) RIGHT REAR DOOR LOCK ACTUATOR (IN RIGHT REAR DOOR) SUPER CAB/ SUPER CREW) TAN WIRE TAN/WHT WIRE VIO WIRE VIO/ORG WIRE VPWR VREF VREF VREF VREF VREF W/ SUPER CREW WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE

820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CKP- CKP+ CONTROL MONITOR 2 (RIGHT SIDE OF ENGINE) CONTROL MONITOR 1 (REAR OF ENGINE) DATA LINK (-) DATA LINK (+) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ECT GAUGE TUNING VALVE EVR CTRL TACH OUT ENGINE FUSE MODULE (LEFT SIDE OF ENGINE COMPT) FUSE 1 FUSE 24 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL (TOP OF ENGINE) IMRC 1 IMRC 2 INDICATOR SWITCH, GENERIC ELECTRONIC MODULE INTAKE MANIFOLD RUNNER CONTROL (TOP FRONT OF ENGINE) INTAKE MANIFOLD RUNNER INTAKE MANIFOLD RUNNER JUNCTION BOX FUSE/RELAY PANEL (UNDER LEFT SIDE OF I/P) LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT ECT IAT FUEL PUMP MON ACCS TUNING VALVE NCA WIRE NOT USED FEPS (EPROM) PPL ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE POWER DISTRIBUTION BOX (LEFT SIDE OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENGINE COMPT) PPL/ORG WIRE PWR GND CASE GND IGN COIL 1 SHIFT SOL 1 (A/T) PWR GND IGN COIL 2 RADIO NOISE CAPACITOR RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS (A/T) OCTANE ADJUST TRANSMISSION CONTROL SWITCH (A/T) VSS WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CKP- CKP+ CONTROL MONITOR 2 (RIGHT SIDE OF ENGINE) CONTROL MONITOR 1 (REAR OF ENGINE) DATA LINK (-) DATA LINK (+) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ECT GAUGE TUNING VALVE EVR CTRL TACH OUT ENGINE FUSE MODULE (LEFT SIDE OF ENGINE COMPT) FP SENDING UNIT FEPS (EPROM) PPL FUSE 1 FUSE 24 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL (TOP OF ENGINE) IMRC 1 IMRC 2 INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD RUNNER CONTROL (TOP FRONT OF ENGINE) INTAKE MANIFOLD RUNNER INTAKE MANIFOLD RUNNER JUNCTION BOX FUSE/RELAY PANEL (UNDER LEFT SIDE OF I/P) LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT ECT IAT FUEL PUMP MON ACCS TUNING VALVE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE POWER DISTRIBUTION BOX (LEFT SIDE OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENGINE COMPT) PPL/ORG WIRE PWR GND CASE GND IGN COIL 1 SHIFT SOL 1 (A/T) PWR GND IGN COIL 2 RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SPARK PLUGS RADIO NOISE CAPACITOR SPARK PLUGS SPARK PLUGS TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS (A/T) OCTANE ADJUST TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VSS WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CKP- CKP+ DATA LINK (-) DATA LINK (+) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ECT GAUGE TUNING VALVE EVR CTRL TACH OUT ENGINE FUSE MODULE (LEFT SIDE OF ENGINE COMPT) FUSE 1 FUSE 24 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS 1, 2 IGNITION COILS 3, 4 INDICATOR SWITCH, GENERIC ELECTRONIC MODULE INTAKE MANIFOLD TUNING VALVE (TOP FRONT OF ENGINE) JUNCTION BOX FUSE/RELAY PANEL (UNDER LEFT SIDE OF I/P) LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT ECT IAT FUEL PUMP MON ACCS TUNING VALVE NCA WIRE NOT USED FEPS (EPROM) PPL NOT USED NOT USED ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE POWER DISTRIBUTION BOX (LEFT SIDE OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENGINE COMPT) PPL/ORG WIRE PWR GND CASE GND IGN COIL 1 SHIFT SOL 1 (A/T) PWR GND IGN COIL 2 RADIO NOISE CAPACITOR 1 RADIO NOISE CAPACITOR 2 RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS (A/T) OCTANE ADJUST TRANSMISSION CONTROL SWITCH (A/T) VSS WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CKP- CKP+ DATA LINK (-) DATA LINK (+) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ECT GAUGE TUNING VALVE EVR CTRL TACH OUT ENGINE FUSE MODULE (LEFT SIDE OF ENGINE COMPT) FP SENDING UNIT FEPS (EPROM) PPL FUSE 1 FUSE 24 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS 1, 2 IGNITION COILS 3, 4 INDICATOR SWITCH, GENERIC ELECTRONIC MODULE INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD TUNING VALVE (TOP FRONT OF ENGINE) JUNCTION BOX FUSE/RELAY PANEL (UNDER LEFT SIDE OF I/P) LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT ECT IAT FUEL PUMP MON ACCS TUNING VALVE NCA WIRE NOT USED NOT USED ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE POWER DISTRIBUTION BOX (LEFT SIDE OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENGINE COMPT) PPL/ORG WIRE PWR GND CASE GND IGN COIL 1 SHIFT SOL 1 (A/T) PWR GND IGN COIL 2 RADIO NOISE CAPACITOR 1 RADIO NOISE CAPACITOR 2 RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS (A/T) OCTANE ADJUST TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VSS WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE COIL DATA LINK CONNECTOR DISTRIBUTOR (LEFT FRONT OF ENGINE) DISTRIBUTOR IGNITION SHIELD DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 22 FUSE 9 GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN IDM (FTO) IGNITION COIL (LEFT FRONT OF ENGINE, FORWARD OF DISTRIBUTOR) IGNITION CONTROL MODULE (LEFT REAR SIDE OF ENGINE COMPARTMENT, ON FENDER APRON) INDICATOR SWITCH LT BLU/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIP PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWER POWERTRAIN CONTROL MODULE (TOP LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PWR GRD RADIO CAPACITOR (LEFT FRONT OF ENGINE, NEAR COIL) RED WIRE RED/ LT GRN WIRE RED/LT GRN WIRE SPARK OUTPUT CHECK CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, NEAR ICM) SPOUT TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM 784 915 WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE COIL DATA LINK CONNECTOR DISTRIBUTOR (TOP FRONT OF ENGINE) DISTRIBUTOR IGNITION SHIELD DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 22 FUSE 9 GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN IDM (FTO) IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR SIDE OF ENGINE COMPARTMENT, ON FENDER APRON) INDICATOR SWITCH LT BLU/BLK WIRE LT GRN RED/ WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIP PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWER POWERTRAIN CONTROL MODULE (TOP LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PWR GRD RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR COIL) RED WIRE RED/LT GRN WIRE SPARK OUTPUT CHECK CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, NEAR ICM) SPOUT TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM 784 915 WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE COIL DATA LINK CONNECTOR DISTRIBUTOR (TOP FRONT OF ENGINE) DISTRIBUTOR IGNITION SHIELD DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 22 FUSE 9 GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN IDM (FTO) IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR SIDE OF ENGINE COMPARTMENT, ON FENDER APRON) INDICATOR SWITCH LT BLU/BLK WIRE LT GRN RED/ WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIP PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWER POWERTRAIN CONTROL MODULE (TOP LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PWR GRD RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR COIL) RED WIRE RED/LT GRN WIRE SPARK OUTPUT CHECK CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, NEAR ICM) SPOUT TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM 784 915 WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

5 6 7 8 PNK WIRE 820 OHMS TRANSMISSION CONTROL INDICATOR LAMP O/D OFF AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CCS CKP(+) CKP(-) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 29 IAT FUEL PUMP MON ACCS IGNITION COILS INTAKE MANIFOLD COMMUNICATOR (IMCC) CONTROL (ON RIGHT SIDE OF ENGINE) INTAKE MANIFOLD EVR CTRL KS SENSOR LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT LT LT DK LT LT LT LT MAF TFT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY FUSE 2 PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (ON TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (ON TOP LEFT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL TC SPD SENS PNK WIRE SHIFT SOL TRANS CTRL IND DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE COIL DATA LINK CONNECTOR DISTRIBUTOR (TOP FRONT OF ENGINE) DISTRIBUTOR IGNITION SHIELD DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 22 FUSE 9 GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN IDM (FTO) IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR SIDE OF ENGINE COMPARTMENT, ON FENDER APRON) INDICATOR SWITCH LT BLU/BLK WIRE LT GRN RED/ WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PIP PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWER POWERTRAIN CONTROL MODULE (TOP LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PWR GRD RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR COIL) RED WIRE RED/LT GRN WIRE SPARK OUTPUT CHECK CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, NEAR ICM) SPOUT TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM WHT/PNK WIRE YEL WIRE YEL/BLK WIRE