Ford Pickup F150 (1996-2012) a/c system Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LEFT SIG(+) LEFT SIG(-) 1 2 3 4 5 6 7 8 9 10 ENABLE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER(+) SUBWOOFER(-) SHIELD ENABLE 154 OHMS 19 57 INTERIOR LIGHTS SYSTEM 226 OHMS 4010 OHMS 736 OHMS 422 OHMS 53.6 OHMS 130 OHMS 931 OHMS 931 OHMS 2940 OHMS A/C SYSTEM AIR BAG SLIDING CONTACT (ON STEERING COLUMN) ANTENNA AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN/ORG WIRE BRN/PNK WIRE CAN-BUS CAN-BUS CENTRAL JUNCTION BOX (BJB) (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE CONTROLS SYSTEM FAN FUSE 1 FUSE 22 FUSE 31 FUSE 38 FUSE 7 GRD GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT W/ ACC DELAY RELAY ENERGIZED ILLUM INTERIOR LIGHTS SYSTEM (NEAR BREAKOUT TO IGNITION SWITCH) L+ R+ MS CAN- LARIAT LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR (+) LR SPKR (+) RR SPKR (+) RF SPKR (+) RF SPKR (-) GROUND VSS FUSE IGN LF SPKR- LR SPKR- RR SPKR- LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MEDIA NEXT MS CAN + NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE POWER POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG(+) RIGHT SIG(-) SATELLITE AUDIO RECEIVER SIG RTN SIGNAL SIGNAL RETURN SUBWOOFER SUBWOOFER (-) SUBWOOFER (+) SHIELD TAN WIRE TAN/YEL WIRE TEMP TEMP FAN TWISTED PAIR TWISTED PAIR (MAIN WIRING HARN, NEAR BREAKOUT TO AUDIO UNIT) 167 168 57 173 TWISTED PAIR 690 799 TWISTED PAIR 832 833 TWISTED PAIR 856 798 VIO WIRE VIO/LT BLU WIRE VOL (-) VPWR GRD L- R- WHT/LT GRN WIRE XL, STX YEL WIRE

820 OHMS O/D OFF A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP- CKP+ DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DLC EVR CTRL FUSE 2 FUSE 29 FUSE 30 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS IMRC IGNITION COIL IGNITION TRANSFORMER CAPACITOR 1 IMRC INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD RUNNER CONTROL (IMRC) (ON RIGHT SIDE OF ENGINE) KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE MAF TFT NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND CASE GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP TRANSMISSION CONTROL SWITCH (A/T) TRANSMISSION SYSTEM VIO WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL/BLK WIRE

13 14 6 DATA LINK CONNECTOR (NEAR CENTER OF DASH) A/C SYSTEM ACCR ACCS ANTI-THEFT SYSTEM AUDIO UNIT BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/WHT WIRE CAN-H- CAN-L- CASE GND PWR GND PWR GND PWR GND PWR GND CENTRAL JUNCTION BOX (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE ETC REF BVREF FPM ETCREF GEN RC GEN LI RDI EVAP CANISTER VENT CONTROL SOLENOID (VEHICLE UNDERBODY) FPC VSOUT FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK) FUSE FUSE 32 FUSE 34 FUSE 33 GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MAF MAF RTN IAT FTPT TCS BOO BPS MASS AIR FLOW SENSOR (LEFT SIDE OF ENGINE) NCA WIRE ORG/ WIRE ORG/RED WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SMC LED OUT TX OUT RX IN CPP TT CPP BT STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/LT BLU WIRE TAN/WHT WIRE TO FUEL PUMP RELAY (DIAGRAM 5 OF 6) VIO WIRE VIO/WHT WIRE VPWR VPWR VPWR KAPWR FEPS SCCS SCCSRTN SIG RTN ETCRTN VSS WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WINDSHIELD WIPER MOTOR (LEFT REAR OF ENGINE COMPT) YEL/BLK WIRE

13 14 6 DATA LINK CONNECTOR (NEAR CENTER OF DASH) A/C SYSTEM ANTI-THEFT SYSTEM AUDIO UNIT BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CAN-H- CAN-L- CASE GND PWR GND PWR GND PWR GND PWR GND CENTRAL JUNCTION BOX (NEAR RIGHT "A" PILLAR) CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE ETC REF BVREF FPM ETCREF GEN RC GEN LI RDI EVAP CANISTER VENT CONTROL SOLENOID (VEHICLE UNDERBODY) FPC VSOUT FUEL TANK PRESSURE TRANSDUCER SENSOR (AT FUEL TANK) FUSE FUSE 32 FUSE 34 FUSE 33 GRY WIRE GRY/BLK WIRE GRY/DK GRN WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW ACCR ACCS LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MASS AIR FLOW/ INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) NCA WIRE ORG/ WIRE ORG/RED WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/LT BLU WIRE TAN/WHT WIRE TO FUEL PUMP RELAY (DIAGRAM 5 OF 6) VIO WIRE VIO/WHT WIRE VPWR VPWR VPWR KAPWR FEPS SCCS SCCSRTN SIG RTN ETCRTN VSS WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

820 OHMS O/D OFF A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP- CKP+ COOLING FANS SYSTEM DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DLC EVR CTRL FUSE 2 FUSE 29 FUSE 30 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS IMRC IGNITION COIL IGNITION TRANSFORMER CAPACITOR 1 IMRC INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD RUNNER CONTROL (IMRC) (ON RIGHT SIDE OF ENGINE) KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE MAF TFT NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND CASE GND IGN COIL 1 SHIFT SOL A SCP BUS + TCS PWR GND IGN COIL 2 RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE SCP BUS (+) TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP TRANSMISSION CONTROL SWITCH (A/T) TRANSMISSION SYSTEM VIO WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL/BLK WIRE

A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) PCM POWER DIODE BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 30 CIRCUIT COIL ON PLUG CSS CKP(+) CKP(-) DATA LINK (-) DATA LINK (+) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT FUEL PUMP RELAY FUSE 10 FUSE 18 FUSE 16 FUSE 23 FUSE 29 GRN WIRE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS IMTV EVR CTRL KS SENSOR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY FUSE 2 PNK 1 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 3 IGN COIL 4 PWR GND TCSS PNK WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE EVR CTRL FUEL H/L RLY CSS CKP(+) CKP(-) FUSE 18 FUSE 2 FUSE 23 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANS- FORMER CAPACITOR 1 (TOP LEFT SIDE OF ENGINE) IGNITION TRANS- FORMER CAPACITOR 2 (TOP RIGHT SIDE OF ENGINE) IND INSTRUMENT CLUSTER SYSTEM KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT IAT IAT FUEL PUMP MON ACCS SOL CTRL AIR COOL RLY NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL DLC SUPERCHARGER BYPASS SOLENOID (REAR OF ENGINE) TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE EVR CTRL FUEL H/L RLY CSS CKP(+) CKP(-) FUSE 18 FUSE 2 FUSE 23 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANS- FORMER CAPACITOR 1 (TOP RIGHT SIDE OF ENGINE) IGNITION TRANS- FORMER CAPACITOR 2 (TOP LEFT SIDE OF ENGINE) IND INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR 2 (TOP OF ENGINE) KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT IAT IAT FUEL PUMP MON ACCS SOL CTRL NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL DLC SUPERCHARGER BYPASS SOLENOID (REAR OF ENGINE) TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE