Ford Fusion I facelift (2005-2012) hot in run or acc Wiring diagrams

24 25 26 BLOWER RQST MS CAN+ MS CAN- AMP BATTERY JUNCTION BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF HVAC HOUSING) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF HVAC HOUSING) BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BRN/GRN WIRE BRN/WHT WIRE CMD COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST REQ BATT BLOWER CMD RECIRC CW RECIRC CCW FUSE 15 FUSE 35 FUSE 45 LOGIC GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) HOT IN RUN OR ACC HVAC-DATC (CENTER OF DASH) IN CAR TEMP SENS IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) MODE DR 1 CCW MODE DR 1 CW DRV TEMP DR CCW DRV TEMP DR CW GND MOT- PASS TEMP DR CCW PASS TEMP DR CW PASS TEMP DR FDBK PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF HVAC HOUSING) SEATS SYSTEM VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VPWR VREF RET WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

24 25 26 BLOWER RQST MS CAN+ MS CAN- AMP BATTERY JUNCTION BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF HVAC HOUSING) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROL (RIGHT SIDE OF HVAC HOUSING) BLU/BRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BRN/GRN WIRE BRN/WHT WIRE CMD COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST REQ BATT BLOWER CMD RECIRC CW RECIRC CCW FUSE 15 FUSE 35 FUSE 37 FUSE 45 LOGIC GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) HOT IN RUN OR ACC HOT IN RUN OR START HUMIDITY SENS IN CAR TEMP SENS HVAC-DATC (CENTER OF DASH) IN-VEHICLE TEMPERATURE/ HUMIDITY SENSOR (LEFT SIDE OF DASH) MODE DR 1 CCW MODE DR 1 CW DRV TEMP DR CCW DRV TEMP DR CW GND MOT- PASS TEMP DR CCW PASS TEMP DR CW PASS TEMP DR FDBK PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF HVAC HOUSING) SEATS SYSTEM VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VPWR VREF RET WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

ANTENNA REAR DEF MODULE WINDOW PWR (RIGHT DEFROST REAR OF GRID TRUNK) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLU WIRE BRN WIRE BRN/YEL WIRE DEFROST DEFROST REQUEST REQUEST DEFROST RELAY FUSE 38 FUSE 45 FUSE 6 FUSION, MILAN GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HVAC HVAC MODULE MODULE (DATC) (EMTC) (CENTER (CENTER OF DASH) OF DASH) LEFT SIDE RIGHT SIDE EXTERIOR EXTERIOR REAR REAR VIEW VIEW MIRROR MIRROR 6 7 6 7 MANUAL AUTOMATIC A/C A/C ORG/ WIRE RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) W/O MEMORY W/ MEMORY WHT WIRE YEL WIRE

AUXILIARY RELAY BOX (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLU WIRE BRN WIRE BRN/YEL WIRE DEFROST RELAY DEFROST REQUEST FUSE 38 FUSE 45 (LEFT SIDE OF DASH) FUSE 6 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HVAC-DATC (CENTER OF DASH) LEFT SIDE EXTERIOR REAR VIEW MIRROR ORG/ WIRE REAR WINDOW DEFROST GRID RED WIRE RIGHT SIDE EXTERIOR REAR VIEW MIRROR SMART JUNCTION BOX (SJB) WHT WIRE YEL WIRE

1 2 3 4 GND AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) AMP BACKLIGHTING BATT POWER DEFROST REQ BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF HVAC HOUSING) BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC HOUSING) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC HOUSING) EVAPORATOR DISCHARGE AIR TEMPERATURE SENSOR (LEFT SIDE OF HVAC HOUSING) FUSE FUSE 15 FUSE 45 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HIGH M HIGH M LOW HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR ACC HVAC-EMTC (CENTER OF DASH) MODE DOOR 1 CW MODE DOOR 1 CCW MODE DOOR 1 FDBK DVR TEMP FDBK ACTET MODE DOOR ACTUATOR (LEFT SIDE OF HVAC HOUSING) ORG/ WIRE RECIR DOOR CCW RECIR DOOR CW RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) THERMAL LIMITER VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREF RET WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 GND SPEED IN BATTERY JUNCTION BOX BLK/GRY WIRE BLK/VIO WIRE BLK/YEL WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/WHT WIRE CAN+ CAN- VS OUT COMPUTER DATA LINES SYSTEM ENGINE COMPT) (2.5L: BEHIND RIGHT FRONT HEADLIGHT) FRONT WIPER SWITCH FUSE 43 FUSE 45 FUSE 9 GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE HOT AT ALL TIMES HOT IN RUN OR ACC MICRO - MIST OFF INT 1 INT 2 INT 3 INT 4 1) 2) 3) 4) 5) MULTIFUNCTION SWITCH OFF ON 6) 7) 8) 9) FRONT INT 5 LOW HIGH WASH SWITCH POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RAIN SENSOR MODULE (EXCEPT HYBRID) RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SPEED IN VIO/ORG WIRE VIO/WHT WIRE VPWR W/O RAIN SENSOR W/ RAIN SENSOR WHT WIRE WHT/BLU WIRE WINDSHIELD WASHER PUMP MOTOR (EXCEPT 2.5L: RIGHT FRONT OF WINDSHIELD WIPER MODULE (LEFT SIDE OF DASH) WINDSHIELD WIPER MOTOR (LEFT REAR OF ENGINE COMPT) YEL WIRE