Ford Fusion I facelift (2005-2012) gry/vio Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 TFT SIG RTN TFT LPC VFS 1 2 3 TSS GND TSS TSS PWR ACCELERATOR PEDAL POSITION (APP) SENSOR (LEFT SIDE OF DASH) BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SWITCH (LEFT SIDE OF DASH) BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP OF ENGINE) ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (TOP REAR OF ENGINE) ENGINE CONTROLS SYSTEM FLOOR SHIFTER GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES SMART JUNCTION FUSE 2 BOX (SJB) (LEFT SIDE OF DASH) HOT IN OR RUN BATTERY JUNCTION FUSE 47 BOX (BJB) (LEFT SIDE OF ENGINE COMPT) SOL PWR TCC VFS SSE ON/OFF SOL TRANS- MISSION CONTROL SWITCH TRS TRS/OSS PWR OSS TRS/OSS GND VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE

19 34 44 50 46 11 45 43 10 39 1 25 36 16 49 29 41 3 40 48 TFT LPC VFS 2.5L 67 38 46 13 VPWR PCMRC BPS BPP BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE FUSE 46 COMPT) BLK/GRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE ENGINE CONTROLS SYSTEM ETCREF FUSE 3 FUSE 49 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN HOT AT ALL TIMES HTR-13 INTAKE AIR TEMPERATURE (MAF/IAT) SENSOR (LEFT FRONT OF ENG COMPT) MAF MAFRTN SIGRTNC IAT POWER GND MASS AIR FLOW/ OUTPUT SHAFT SPEED (OSS) SENSOR (2.5L M/T) (TOP OF TRANSMISSION) PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) SIGRTNE HTR 11 TACM + TACM - CHT ETCRTN SOL PWR TCC VFS SSE ON/OFF SOL TCS TFT SIG RTN OSS TRS TRS/OSS PWR OSS TSS/OSS TR GND TSS HTR 12 VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 BATT+ ANT ANT PWR ANTENNA MODULE (EXCEPT HYBRID: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK BLK WIRE BLK/BLU WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BRN WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COAX COAX ANTENNA COAX SAT ANT COMPUTER DATA LINES SYSTEM FRONT DISPLAY INTERFACE MODULE (FDIM) (CENTER OF DASH) FUSE 14 FUSE 28 FUSE 39 GRN WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE HARNESS, NEAR BREAKOUT TO DRIVER DOOR MODULE) (BASE-MILAN, MID-LEVEL) HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT FRONT TWEETER (BASE- MILAN, MID-LEVEL) LEFT REAR SPEAKER LF SPKR+ LR SPKR+ RR SPKR+ RF SPKR+ RF SPKR- PWR GND LF SPKR- LR SPKR- RR SPKR- MS CAN - MS CAN + MS CAN+ MS CANL- NCA WIRE ORG/ WIRE RED WIRE RIGHT FRONT SPEAKER RIGHT FRONT TWEETER (BASE- MILAN, MID-LEVEL) RIGHT REAR SPEAKER SAT ANT SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) STEREO AUDIO SHIELD VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 MS CAN+ MS CAN- PCBLWCTL PBBLWCTL 25 26 MS CAN + MS CAN - BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DBLWR- DBLWR+ DCBLWCTL DBBLWCTL DCSHSENS DCSHSENSRT DBKSENS DBKSENSRT EARLY PRODUCTION FUSE 12 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE HOT AT ALL TIMES HVAC-DATC (CENTER OF DASH) LATE PRODUCTION LEFT FRONT SEAT BACKREST HEATER MAT (DRIVER'S SEAT BACK) LEFT FRONT SEAT CUSHION HEATER MAT (SEAT CUSHION) NCA WIRE ORG/ WIRE PBLWR- PBLWR+ PCSHSENS PCSHSENSRT PBKSENS PBKSENSRT RED WIRE RIGHT FRONT SEAT BACKREST HEATER MAT (RIGHT SIDE OF FRONT PASSENGER'S SEAT BACK) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 LOGIC 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 EXT MIRR POT FEED 1 2 V BATT PWR GND BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK/WHT WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE COMPUTER DATA LINES SYSTEM MEMORY MIRRORS CIRCUIT DRIVER SEAT MODULE (DSM) (UNDER DRIVER'S SEAT) DRIVER SEAT RECLINER MOTOR (SEAT BACK) FRONT UP/DOWN FUSE 12 FUSE 32 FWD/BACK GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT POWER SEAT MOTOR ASSEMBLY (UNDER SEAT BOTTOM) MEMORY MIRRORS CIRCUIT ORG/ WIRE PASS MIRR MTR HORZ PASS MIRR MTR VERT PASS MIRR MTR MS CAN- MS CAN+ MIRR POT RET PASS MIRR VERT POT FEEDBACK PASS MIRR HORZ POT FEEDBACK REAR/UP/DOWN RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRY WIRE YEL/ORG WIRE

1 19 7 16 17 24 V BATT MS CAN+ MS CAN- MEM RECALL 1 SW MEM RECALL 2 SW GND AFT BASE BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN/GRN WIRE COMPUTER DATA LINES SYSTEM DOWN DRIVER SEAT LUMBAR MOTOR (DRIVER'S SEAT BACK) DRIVER SIDE FRONT SEAT CONTROL SWITCH DRIVER'S DOOR MODULE (FRONT OF DRIVER'S DOOR) FORE/ FRONT GRN/BLU WIRE GRN/RED WIRE GRN/WHT WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE LUMBAR MEMORY 1 MEMORY 2 MEMORY MIRROR CIRCUIT MEMORY SET SWITCH OUT REAR RECLINE TILT DOWN TILT UP VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE YEL WIRE YEL/ORG WIRE

1 2 3 4 B+ MS CAN+ MS CAN- GND ANT PWR ANT SAT ANT COAX COAX ANTENNA MODULE (EXCEPT HYBRID: BASE OF RIGHT "C" PILLAR) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK BLK/BLU WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMERA COAX COAX COMPUTER DATA LINES SYSTEM DISPLAY ENABLE DISPLAY RX DISPLAY TX DVD VIDEO - DVD VIDEO+ DISPLAY ENABLE DISPLAY RX FRONT CONTROLS INTERFACE MODULE (FCIM) (CENTER OF DASH) FRONT DISPLAY INTERFACE MODULE (FDIM) (CENTER OF DASH) FUSE 14 FUSE 19 FUSE 28 FUSE 38 FUSE 39 GRN/BRN WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LF+ LR+ RR+ RF+ RF- PWR GND NAV VOICE- LF- LR- RR- AUDIO SHLD GND MIC - MIC IN+ MIC IN- MIC SHD- MS CAN - MS CAN + MULTIMEDIA INTERIOR MIRROR UNIT NAVIGATION SYSTEM NCA WIRE PWR GND REAR VIEW CAMERA DISPLAY MIRROR REVERSE IN SAT ANT ANTENNA BATT + NAV VOICE+ AUDIO SHIELD GND SHIELD SHIELD DVD VIDEO- SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) STEREO AUDIO SHLD SWC 2 + SWC 1 + SWC 1 RTN VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE W/ REAR VIEW CAMERA W/O REAR VIEW CAMERA WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 PWR B+ AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) BLK/GRY WIRE BLK/VIO WIRE BLU WIRE BLU/ORG WIRE BRN WIRE BRN/RED WIRE BRN/VIO WIRE CAMERA GND CAMERA PWR DISPLAY ENABLE DISPLAY RX DISPLAY TX DVD VIDEO - FRONT DISPLAY INTERFACE MODULE (FDIM) (CENTER OF DASH) FUSE GRN WIRE GRY WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN NCA WIRE ORG/ WIRE REAR VIEW CAMERA (CENTER OF DECK LID) REAR VIEW CAMERA DISPLAY MIRROR RED WIRE RR CAM + RR CAM + DISPLAY TX DISPLAY ENABLE DVD VIDEO + GNDV 1 RR CAM - DISPLAY RX SHIELD DVD VIDEO - RR CAM SHILD- SHIELD SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO WIRE W/ NAVIGATION W/O NAVIGATION WHT WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/GRY WIRE

1 2 3 4 1 3 4 2 B+ MS CAN+ MS CAN- GND ANT PWR ANT SAT ANT COAX COAX ANTENNA MODULE (EXCEPT HYBRID: BASE OF RIGHT "C" PILLAR) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK BLK/BLU WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMERA COAX COAX SAT ANT ANTENNA BATT + NAV VOICE+ AUDIO SHIELD GND COMPUTER DATA LINES SYSTEM DISPLAY ENABLE DISPLAY RX DISPLAY TX DVD VIDEO - DVD VIDEO+ DISPLAY ENABLE DISPLAY RX FRONT CONTROLS INTERFACE MODULE (FCIM) (CENTER OF DASH) FRONT DISPLAY INTERFACE MODULE (FDIM) (W/ NAVIGATION) (CENTER OF DASH) FRONT DISPLAY INTERFACE MODULE (FDIM) (W/O NAVIGATION) (CENTER OF DASH) FUSE 14 FUSE 19 FUSE 28 FUSE 38 FUSE 39 GRN/BRN WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LF+ LR+ RR+ RF+ RF- PWR GND NAV VOICE- LF- LR- RR- AUDIO SHLD GND MIC - MIC IN+ MIC IN- MIC SHD- MS CAN - MS CAN + MULTIMEDIA REAR VIEW INTERIOR CAMERA MIRROR UNIT DISPLAY MIRROR NAVIGATION SYSTEM NCA WIRE PWR GND REVERSE IN SHIELD SHIELD DVD VIDEO- SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) STEREO AUDIO SHLD SWC 2 + SWC 1 + SWC 1 RTN VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE W/ NAVIGATION W/O REAR W/ REAR VIEW VIEW CAMERA CAMERA W/O W/ NAV NAV WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/GRN WIRE

14 15 26 25 HS CAN- HS CAN+ 2.5L EXCEPT HYBRID 2.5L HYBRID ANTI-LOCK BRAKES SYSTEM BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE CASE GROUND COMPUTER DATA LINES SYSTEM DRIVER SAFETY BELT BUCKLE SWITCH (UNDER RIGHT SIDE OF SEAT) DRV AIR BAG FEED 2 DRV AIR BAG RTN 2 PASS AIR BAG RTN 2 PASS AIR BAG FEED 2 ENGINE CONTROLS SYSTEM ENS FCS FEED DRV FCS RTN DRV FCS RTN PASS FCS FEED PASS FUSE 32 FUSE 46 GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/VIO WIRE GRY/YEL WIRE HOT IN RUN OR START INSTRUMENT CLUSTER (IC) LEFT FRONT IMPACT SENSOR (EXCEPT HYBRID: LEFT FRONT OF ENGINE COMPT) LEFT SEAT TRACK POSITION SENSOR (FRONT OF SEAT TRACK) LEFT SIDE AIR CURTAIN SENSOR 1 (BASE OF LEFT "B" PILLAR) LEFT SIDE AIR CURTAIN SENSOR 2 (BASE OF LEFT "C" PILLAR) PAD INDICATOR PASSENGER AIR BAG DEACTIVATION (PAD) INDICATOR PASSENGER SAFETY BELT BUCKLE SWITCH (LOWER LEFT SIDE OF SEAT TRACK) RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) RIGHT FRONT IMPACT SENSOR (EXCEPT HYBRID: RIGHT SIDE OF ENGINE COMPT) RUN/START SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE