Ford Fusion I facelift (2005-2012) fuse Wiring diagrams

13 46 46 47 BOO BPS 21 5 26 25 18 B+ PWR GND HS CAN- HS CAN+ TRACTION CTL ON/OFF 3.5L 2.5L, 3.0L 42 43 44 45 46 47 RR SENSOR- RR SENSOR+ 7 8 TRACTION CTL ON/OFF 9 10 19 20 HS CAN - HS CAN + TC CAN STAT- TC CAN STAT+ ANTI-LOCK BRAKE SYSTEM (ABS) MODULE BATTERY JUNCTION FUSE BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK/GRY WIRE BLK/VIO WIRE BLU/ORG WIRE BLU/WHT WIRE BOO OF DASH) INPUT BRAKE BOOSTER VACUUM SENSOR (3.0L AWD, 3.5L) (ON BRAKE BOOSTER) BRAKE PEDAL POSITION SWITCH (LEFT SIDE OF DASH) BRN WIRE BRN/GRN WIRE BRN/VIO WIRE COMPUTER DATA LINES SYSTEM CONTROL MODULE EXCEPT MKZ MKZ FRONT CONTROL INTERFACE MODULE (FCIM) (CENTER OF DASH) FUSE FUSE 2 FUSE 26 FUSE 42 GRN WIRE GRN/ORG WIRE GRY/BLU WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT W/ PCM POWER RELAY ENERGIZED HS CAN + HS CAN - INSTRUMENT CLUSTER (IC) IVD PWR IVD RTN SAS A LEFT FRONT WHEEL SPEED SENSOR (LEFT FRONT HUB ASSEMBLY) LEFT REAR WHEEL SPEED SENSOR (LEFT REAR HUB ASSEMBLY) LF SENSOR+ LF SENSOR- LR SENSOR+ LR SENSOR- MTR GND NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT HUB ASSEMBLY) RIGHT REAR WHEEL SPEED SENSOR (RIGHT REAR HUB ASSEMBLY) RUN/START SAS B SMART JUNCTION BOX (SJB) (LEFT SIDE STEERING ANGLE SENSOR MODULE (SASM) TC CAN STAT + TC CAN STAT - TRACTION CONTROL/ AMBIENT LIGHTING SWITCH VAC PWR VAC GND VAC SIG VALVE PWR RF SENSOR- RF SENSOR+ VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

2.5L/3.0L 2.5L/3.0L 3.5L 26 12 13 25 HS CAN- MS CAN+ MS CAN- HS CAN+ 3.5L 55 2 3 63 59 58 FEPS HS CAN+ HS CAN- 6 SPEED TRANSMISSION (3.5L) ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (RIGHT FRONT OF ENGINE COMPT) B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BLK/VIO WIRE BRN WIRE FEPS HS CAN- FUSE GRN/RED WIRE GRY/ORG WIRE HEADLAMP CONTROL MODULE (W/ HID) (LEFT REAR OF ENGINE COMPT) HOT AT ALL TIMES HS CAN+ INSTRUMENT CLUSTER (IC) MODULE (IF EQUIPPED) (LEFT SIDE OF DASH) MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ OCCUPANT CLASSIFICATION SYSTEM MODULE (OCSM) (UNDER RIGHT FRONT SEAT CUSHION) POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SMART JUNCTION BOX (SJB) (LEFT SIDE MS OF DASH) CAN- VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

2 1 14 15 MS CAN+ MS CAN- HS CAN- HS CAN+ 63 59 43 FEPS HS CAN+ HS CAN- AIR CONDITIONING COMPRESSOR MODULE (ACCM) (LEFT FRONT OF ENGINE) ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BATTERY ENERGY CONTROL MODULE (BECM) (BEHIND LEFT SIDE OF REAR SEAT) BLK/VIO WIRE BRN WIRE DC/DC CONVERTER MODULE (RIGHT FRONT OF ENGINE COMPT) FEPS HS CAN- FUSE GRN/RED WIRE GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ INSTRUMENT CLUSTER (IC) MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ OCCUPANT CLASSIFICATION SYSTEM MODULE (OCSM) (UNDER RIGHT FRONT SEAT CUSHION) POWERTRAIN CONTROL MODULE (PCM) RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SMART JUNCTION BOX (SJB) (LEFT SIDE MS OF DASH) CAN- TRANSAXLE CONTROL MODULE (ON TRANSAXLE) VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

2.5L HYBRID 2.5L, 3.0L 3.5L 2.5L, 3.0L 3.5L 3.5L, 2.5L HYBRID BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLU WIRE BLU/GRY WIRE CHT COMPUTER DATA LINES SYSTEM ENGINE COOLING FAN MOTOR (LEFT FRONT OF ENGINE COMPT) EXCEPT 3.5L, 2.5L HYBRID FC-V FUSE GRN WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HS CAN+ POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE SIGRTNE WHT WIRE WHT/BLU WIRE YEL WIRE

1 2 3 HS CAN H HS CAN L RUN/START 1 2 BATT GND BATTERY JUNCTION BOX (BJB) FUSE (LEFT SIDE OF ENGINE COMPT) BLK/GRN WIRE COMPUTER DATA LINES SYSTEM EPAS MOTOR PART OF MODULE/ ASSEMBLY EXCEPT HYBRID FUSE FUSE BOX (SJB) (LEFT SIDE OF DASH) GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN RED WIRE SMART JUNCTION WHT WIRE WHT/BLU WIRE YEL WIRE YEL/RED WIRE

2.5L 3.5L A/C CLUTCH FIELD COIL (FRONT OF A/C COMPRESSOR) A/C CLUTCH RELAY ACCR ACPT BATTERY JUNCTION BOX (BJB) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/GRY WIRE BRN WIRE CHT COMPUTER DATA LINES SYSTEM E-SIGRTN ENGINE CONTROLS SYSTEM ENGINE COOLING FAN MOTOR (LEFT FRONT OF ENGINE COMPT) FC-V FUSE FUSE 3 FUSE 25 GRN WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HS CAN+ INSTRUMENT CLUSTER (IC) ORG/ WIRE PCM CONTROL PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) RED WIRE SIGRTN VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VREF WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

1 2 3 4 GND AIR INLET MODE DOOR ACTUATOR (RIGHT SIDE OF DASH) AMP BACKLIGHTING BATT POWER DEFROST REQ BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF HVAC HOUSING) BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC HOUSING) BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC HOUSING) EVAPORATOR DISCHARGE AIR TEMPERATURE SENSOR (LEFT SIDE OF HVAC HOUSING) FUSE FUSE 15 FUSE 45 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HIGH M HIGH M LOW HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR ACC HVAC-EMTC (CENTER OF DASH) MODE DOOR 1 CW MODE DOOR 1 CCW MODE DOOR 1 FDBK DVR TEMP FDBK ACTET MODE DOOR ACTUATOR (LEFT SIDE OF HVAC HOUSING) ORG/ WIRE RECIR DOOR CCW RECIR DOOR CW RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) THERMAL LIMITER VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREF RET WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BRN WIRE COMPUTER DATA LINES SYSTEM EXCEPT HYBRID HYBRID FUSE GROUND GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN HS CAN+ INSTRUMENT CLUSTER (IC) MOD GND MS CAN + PASSIVE ANTI-THEFT TRANSCEIVER MODULE (TOP OF STEERING COLUMN) PATS RX PATS TX POWER RED WIRE RUN/START RX OUTPUT SMART JUNCTION FUSE BOX (SJB) (LEFT SIDE OF DASH) TX INPUT VIO WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/VIO WIRE YEL WIRE YEL/ORG WIRE YEL/RED WIRE

A/C PRESSURE TRANSDUCER (RIGHT REAR OF ENGINE COMPT) ACCELERATOR PEDAL POSITION (APP) SENSOR (ON ACCELERATOR PEDAL BRACKET) ACCR ACLPCS FC V ACPSW ACPT AIR CONDITIONING SYSTEM BLK/GRN WIRE BLU WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BOO FPM BPS IAT SCCSRTN BRN WIRE BRN/BLU WIRE BRN/WHT WIRE CANV INJPWRM CGND COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM AIR CONDITIONING SYSTEM COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CTO TGAC FPC FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) FUSE FVVV VSOUT TMAC GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR IGNITION SWITCH KAPWR FEPS SCCS FTP FTPREF VPWR VPWR GND GND OFF LOCK RUN/ RUN/ PCMRC ISP-R/S MAF MAFRTN ISP-R HS CAN+ POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RUN WIRE SIGRTN HS CAN+ SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VREF WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE WIPER/WASHER SYSTEM YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

A/C CLUTCH RELAY A/C PRESSURE TRANSDUCER AIR CONDITIONING SYSTEM APP 1 APP 2 APP 3 BATTERY JUNCTION BOX (BJB) (LEFT BLK/GRN WIRE BLU WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BPP BPS BRN WIRE BRN/BLU WIRE BRN/YEL WIRE C VREF SMC PCM CONTROL C-SIGRTN CANVNT FPC ACPT ACCR CASE GND PWR GND 1 PWR GND 2 PWR GND 3 COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM EVAP CANISTER VENT CONTROL SOLENOID (REAR OF VEHICLE CHASSIS) EVAPORATIVE EMISSION (EVAP) CANISTER PURGE VALVE (RIGHT REAR OF ENGINE COMPT) FC-V FLOOR SHIFTER FTPTREF FPM FUSE FUSE 3 FUSE 46 FUSE 47 FUSE 48 FUSE 49 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/VIO WIRE HARNESS, NEAR BREAKOUT HOT AT ALL TIMES HOT IN START OR RUN SMART JUNCTION FUSE BOX (SJB) (LEFT SIDE OF DASH) HS CAN + HS CAN - EVMV IAT IGNITION KAPWR FEPS SCCS SCCSRTN C SIGRTN MAF MAF MAFRTN IAT FTPT INJPWRM MAFRTN O/D PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PWR PWR GND REVERSE LAMP RELAY SDC SIDE OF ENGINE COMPT) SMR STARTING/CHARGING SYSTEM TRSW-PN VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR VPWR VPWR WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE