Ford Freestyle I (2004-2009) brn/org Wiring diagrams

1 2 LOGIC GND VBATT ADJUSTABLE PEDAL MOTOR (LEFT SIDE OF DASH) ADJUSTABLE PEDAL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) FUSE 32 BLK WIRE BLK/ORG WIRE BRN/LT GRN WIRE BRN/ORG WIRE DK GRN WIRE DRIVER SEAT MODULE (IN DRIVER'S SEAT BOTTOM) FUSE 10 FUSE 4 HALL SENSOR HOT AT ALL TIMES LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MEMORY 1 MEMORY 2 MEMORY SET SWITCH ORG/ WIRE ORG/LT GRN WIRE RED WIRE RED/LT BLU WIRE RWD SET- SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) WHT WIRE WHT/ORG WIRE

11 3 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) 2 1 3 4 MTR RET GND SPD CTRL VPWR 579 580 1255 SEATS SYSTEM AMBIENT AIR TEMPERATURE SENSOR (BEHIND LEFT SIDE OF FRONT GRILLE) AUTOLAMP SENSOR AUTOLAMP/SUNLOAD SENSOR (TOP CENTER OF DASH) AUXILIARY COOLANT PUMP MOTOR AUXILIARY MODE ACTUATOR (LEFT "C" PILLAR) AUXILIARY TEMPERATURE ACTUATOR (LEFT SIDE OF TRUNK) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DEFOGGER SYSTEM DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (CENTER OF DASH) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT SIDE OF DASH) FUSE 20 FUSE 36 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) IND CTRL IND CTRL TEMP REQ LT BLU/BLK WIRE LT BLU/WHT WIRE NCA WIRE NEAR BREAKOUT TO ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SEATS SYSTEM SENS SIG SENS SIG SIG RET SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SPD CTRL TEMP SW SENS SIG SENS SIG SUNLOAD SENSOR TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

ACTUATOR AIR INLET DOOR ACTUATOR (RIGHT SIDE OF DASH) AUXILIARY BLOWER MOTOR (LEFT SIDE OF TRUNK) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (LEFT SIDE OF TRUNK) AUXILIARY RELAY BOX 1 (LEFT SIDE OF TRUNK) AUXILIARY RELAY BOX 2 (LEFT SIDE OF TRUNK) AUXILIARY RELAY BOX 3 (LEFT SIDE OF TRUNK) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DK BLU WIRE DK GRN/YEL WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT CENTER OF DASH) FUSE 22 FUSE 31 GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN ACC OR RUN LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MODE DOOR ACTUATOR (LEFT SIDE OF DASH) ORG/ WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) PNK WIRE PNK/BLK WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

11 3 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) 2 1 3 4 MTR RET GND SPD CTRL VPWR AUTOLAMP SENSOR AUTOLAMP/SUNLOAD SENSOR (TOP CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DEFOGGER SYSTEM ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (CENTER OF DASH) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT SIDE OF DASH) FUSE 20 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) IND CTRL IND CTRL TEMP REQ LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/RED WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SEATS SYSTEM SENS SIG SENS SIG SIG RET SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SPD CTRL IND CTRL IND CTRL TEMP REQ SENS SIG SENS SIG RLY CTRL SUNLOAD SENSOR TAN/LT BLU WIRE VIO WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

AIR INLET DOOR ACTUATOR (RIGHT SIDE OF DASH) BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT CENTER OF DASH) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (RIGHT SIDE OF DASH) RED/LT GRN WIRE RED/WHT WIRE VIO WIRE WHT/LT BLU WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

14 21 40 41 MTR CTRL REF VOLTAGE REF VOLTAGE SIG RET 14 38 41 26 RLY CTRL SENS SIG SIG RET SW SIG A/C CLUTCH DIODE A/C CLUTCH FIELD COIL (LEFT FRONT OF ENGINE) A/C CLUTCH RELAY A/C PRESSURE TRANSDUCER SENSOR BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BRN/ORG WIRE BRN/WHT WIRE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP REAR OF ENGINE) ENGINE COOLING FAN MOTOR (FIVE HUNDRED/MONTEGO: BEHIND RADIATOR) EVAPORATOR DISCHARGE AIR TEMPERATURE SENSOR (LEFT CENTER OF DASH) FUSE 24 FUSE 48 FUSE 7 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN ON OR START LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE ORG/ WIRE ORG/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE

ACCESSORY DELAY RLY OUT VOLT SPLY IN START OR RUN VOLT SPLY IN START OR RUN AIR CONDITIONING SYSTEM SOUND SYSTEMS ANTI-THEFT SYSTEM BATTERY JUNCTION FUSE 18 BOX (BJB) (LEFT FRONT OF ENGINE COMPARTMENT) BATTERY VOLT BATTERY VOLT VOLT SPLY IN START OR RUN VOLT IN RUN OR ACC BATTERY VOLT VOLT SUPPLY START OR RUN VOLT SUPPLY START OR RUN BLK/LT BLU WIRE BRAKE PEDAL STATUS HSD SENSE SENSE BRN/ORG WIRE DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM DEFOGGER SYSTEM HEADLIGHTS SYSTEM ANTI-THEFT SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INSTRUMENT CLUSTER SYSTEM GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HEATED BACKLIGHT RLY STATUS VOLT SPLY IN START HIGH BEAM CTRL VOLT SUPPLY IN START HORN CTRL SENSE HORN SW HORNS SYSTEM HORNS SYSTEM WIPER/WASHER SYSTEM INSTRUMENT CLUSTER SYSTEM HOT AT ALL TIMES HSD HSD SENSE IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM HEADLIGHTS SYSTEM STARTING/CHARGING SYSTEM LOGIC LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE OFF ORG/BLK WIRE ORG/YEL WIRE PARK LAMP RLY OUT POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM AIR CONDITIONING, INSTRUMENT CLUSTER SYSTEMS RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SEATS SYSTEM POWER DISTRIBUTION SYSTEM ANTI-LOCK BRAKES SYSTEM SENSE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SOUND SYSTEMS SUPPLEMENTAL RESTRAINTS SYSTEM INSTRUMENT CLUSTER SYSTEM TAN/LT BLU WIRE VBATT GROUND VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VOLT IN RUN OR ACC VOLT SPLY IN START VOLT SPLY IN START, RUN VOLT SPLY IN START, RUN WHT WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE

AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SWITCH BRN/ORG WIRE CAN (-) CAN (+) CENTER STACK SWITCH ASSEMBLY CLOCK CLOCK SPRING (FIVE HUNDRED/ MONTEGO: IN STEERING COLUMN ASSEMBLY) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONIC COMPASS (ON INSIDE REAR VIEW MIRROR ASSEMBLY) FUEL LEVEL FUSE 19 FUSE 20 FUSE 23 FUSE 22 FUSE 33 FUSE 7 GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN IGNITION SWITCH ILLUM GND INFO INSTRUMENT CLUSTER KEY IN IGNITION LOW BRAKE FLUID LEVEL SW SIG BRAKE FLUID LEVEL SW PWR LOW COOLANT LEVEL SWITCH (RIGHT REAR OF ENGINE COMPT) LOW CURRENT BOARD LOW OIL PRESSURE SW LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MESSAGE CENTER SWITCH MS CAN - MS CAN + NCA WIRE OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE, IN EXHAUST) ORG/ WIRE ORG/RED WIRE PARK BRAKE SW PARKING BRAKE SWITCH (FIVE HUNDRED/ MONTEGO: ON PARKING BRAKE ASSEMBLY) PATS-LED PNK WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PWR RED WIRE RED/LT GRN WIRE RED/YEL WIRE RESET+ SENSOR SETUP SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) TAN/BLK WIRE TCS ENABLE TCS IND VIO WIRE VIO/YEL WIRE WASHER FLUID LEVEL SW LOW COOLANT LEVEL SW WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WIPER/ WASHER SYSTEM YEL WIRE YEL/WHT WIRE

1 2 3 4 GND HIGH MEDIUM HIGH MEDIUM LOW 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 VBATT AIR INLET DOOR ACTUATOR (RIGHT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DEACTIVATION INDICATOR) DEFOGGER SYSTEM DRIVER TEMPERATURE BLEND DOOR ACTUATOR (LEFT CENTER OF DASH) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 20 FUSE 7 GRN WIRE HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN START OR RUN LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE LT LT LT LT LT ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK DEFROST CTRL +/- +/- +/- +/- VREF RLY STATUS AC REQ ILLUM GND WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RLY CTRL SENS SIG SENS SIG SIG RTN VPWR SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) TAN/BLK WIRE TAN/LT BLU WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

ACCESSORY DELAY RELAY ACCESSORY DELAY RELAY OUT AUTO OPEN BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BRN/ORG WIRE CIRCUIT BREAKER 25 CLOSE DK BLU WIRE FUSE 15 FUSE 5 GROUND HOT AT ALL TIMES LOGIC LT GRN/ORG WIRE OVERHEAD CONSOLE RED WIRE RED/LT BLU WIRE ROOF OPENING PANEL MODULE (BEHIND HEADLINER, ABOVE REAR VIEW MIRROR) ROOF OPENING PANEL SW CLOSE SIG ROOF OPENING PANEL SW COMMON ROOF OPENING PANEL SW OPEN SIG ROOF OPENING PANEL SW TILT SIG SLIDE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) TAN/RED WIRE VOLT BATT W/ AUXILIARY A/C WHT/RED WIRE