Ford Explorer V (2010-2015) vio/gry Wiring diagrams

AFT FWD BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM DN UP DRIVER SIDE FRONT SEAT CONTROL SWITCH FOLD FRONT HEIGHT GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEATER HORI- ZONTAL INFLATE DEFLATE LEFT/RIGHT LUMBAR PASSENGER SIDE EXTERIOR REAR VIEW MIRROR POSITION SENSORS PUDDLE REAR HEIGHT RECLINE RECLINE INCLINE TURN UP/DOWN VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE W/ HEATED SEATS WHT/BRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

BLK WIRE BLU/GRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE DRIV L/R DRIV U/D DRIVER SEAT FRONT HEIGHT MOTOR DRIVER SEAT HORIZONTAL MOTOR DRIVER SEAT LUMBAR MOTOR DRIVER SEAT REAR HEIGHT MOTOR DRIVER SEAT RECLINER MOTOR DRIVER SIDE DOOR LOCK CONTROL SWITCH EXTERIOR REAR VIEW MIRROR SWITCH FOLD FOLD OUT FOLD SW FOLD-IN GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE MASTER WINDOW CONTROL SWITCH (LIMITED) MEMORY SET SWITCH NOT USED PASS L/R PASS U/D PWR RETURN SET 1 SET 2 SET 3 VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE YEL WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 BATT ANTENNA PWR 21 22 23 24 LR SPKR + LF SPKR + RF SPKR + RR SPKR + 6 5 4 3 2 1 GND ACCESSORY PROTOCOL INTERFACE MODULE ALERT - AUDIO CONTROL MODULE (ACM) BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BRN WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE COAXIAL CABLE COAXIAL CABLE COAXIAL CABLE COAXIAL CABLE SDARS AM/FM COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM (UNDER RIGHT FRONT OF CENTER CONSOLE) GLOBAL POSITIONING SYSTEM MODULE GRN WIRE GRN/ORG WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES BODY CONTROL MODULE (LEFT END OF DASH) FUSE 29 INSTRUMENT PANEL SPEAKER IP SPKR + LEFT FRONT SPEAKER LEFT FRONT TWEETER LEFT REAR SPEAKER MS CAN - MS CAN + VBATT NCA WIRE POLICE SDL H SDL L STARTING/ CHARGING SYSTEM STATE SOLID STEREO L- STEREO R- VIO WIRE VIO/GRY WIRE W/ SATELLITE RADIO W/ SYNC GEN 1 W/ SYNC GEN 2 WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 VBATT 1 2 3 4 5 6 VBATT I CAN + I CAN - HAZARD 13 10 14 15 2 5 1 14 LOGIC GND VBATT HS CAN+ HS CAN- A/D CHANNEL 2 A/D CHANNEL 3 A/D CHANNEL 4 A/D RETURN BLK WIRE BLK/BLU WIRE BLU/GRY WIRE BLU/RED WIRE BODY CONTROL MODULE (LEFT END OF DASH) BRN WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CLOCKSPRING (TOP OF STEERING COLUMN) COMPUTER DATA LINES SYSTEM FRONT CONTROL/ DISPLAY INTERFACE MODULE (FCDIM) FRONT CONTROLS INTERFACE MODULE (FCIM) FUSE 23 FUSE 9 GRN/RED WIRE GRY/ORG WIRE HAZARD SWITCH HOT AT ALL TIMES I CAN + I CAN - LEFT STEERING WHEEL SWITCH NCA WIRE ORG/ WIRE PHONE MUTE PNK WIRE POLICE POLICE EXCEPT POLICE PTT MEDIA RED WIRE RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH SEEK VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VOL (-) W/ SYNC W/O SYNC WHT BRN WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 I CAN + 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SUBW 1+ SUBW 2+ 3 4 21 SYNC ALERT+ SYNC ALERT- SHIELD 6 5 4 3 2 1 GND AUDIO CONTROL MODULE AUDIO DIGITAL SIGNAL PROCESSING MODULE (BASE OF RIGHT "C" PILLAR) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BODY CONTROL MODULE (LEFT END OF DASH) BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE COAXIAL CABLE COAXIAL CABLE COAXIAL CABLE COAXIAL CABLE SDARS AM/FM BATT ANTENNA PWR COMPUTER DATA LINES SYSTEM ENABLE FUSE 29 FUSE 5 GLOBAL POSITIONING SYSTEM MODULE GND GND GND I CAN + I CAN - GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES I CAN - LEFT FRONT INSTRUMENT SPEAKER PANEL SPEAKER LEFT FRONT TWEETER LEFT REAR SPEAKER LF SPKR LF SPKR + RF SPKR + MS CAN - MS CAN + VBATT NCA WIRE RF SPKR RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT REAR SPEAKER SHIELD SOLID STATE STARTING/ CHARGING SYSTEM STEREO SHIELD SUBW 1- SUBW 2- SUBWOOFER SYNC ALERT - V BATT V BATT VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE W/ SATELLITE RADIO WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 VBATT 1 2 3 4 5 6 VBATT I CAN + I CAN - HAZARD 13 10 14 15 2 5 1 14 LOGIC GND VBATT HS CAN+ HS CAN- 8 5 7 10 A/D CHANNEL 2 A/D CHANNEL 3 A/D CHANNEL 4 A/D RETURN ALERT - AUDIO CONTROL MODULE AUDIO INPUT JACK (W/O SYNC) BLK WIRE BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/RED WIRE BODY CONTROL MODULE (LEFT END OF DASH) BRN WIRE BRN/YEL WIRE CLOCKSPRING (TOP OF STEERING COLUMN) COMPUTER DATA LINES SYSTEM ENABLE SDL L EXCEPT POLICE FRONT CONTROLS INTERFACE MODULE (FCIM) FUSE 23 FUSE 9 GRN WIRE GRN/BRN WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HAZARD SWITCH HOT AT ALL TIMES I CAN + I CAN - LEFT REAR D-PILLAR TWEETER LEFT STEERING WHEEL SWITCH NCA WIRE ORG/ WIRE PNK WIRE POLICE PTT MEDIA PHONE MUTE RED WIRE RIGHT REAR D-PILLAR TWEETER RIGHT STEERING WHEEL SWITCH SDL H SEEK + SEEK - STEERING COLUMN CONTROL MODULE (TOP OF STEERING COLUMN) STEREO L- STEREO R- SYNC RADIO CIRCUIT VIO WIRE VIO/GRY WIRE VIO/RED WIRE VOL VOL W/ SYNC W/O SYNC WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/RED WIRE

AUTO PARK AUTP PARK BLK/GRN WIRE BLK/GRY WIRE BLU/GRN WIRE BLU/WHT WIRE BODY CONTROL MODULE (BCM) (LEFT END OF DASH) BRN WIRE BRN/BLU WIRE CENTER STACK SWITCH ASSEMBLY COMPUTER DATA LINES SYSTEM FUSE 34 GRN/BRN WIRE GRN/WHT WIRE GRY/ORG WIRE HOT IN RUN OR START HS CAN+ ICE BLUE LEFT ACTIVE PARK ASSIST SENSOR LEFT INNER PARKING AID SENSOR (LEFT SIDE OF REAR BUMPER) LEFT OUTER PARKING AID SENSOR (LEFT SIDE OF REAR BUMPER) LF SIDE SN PARKING AID MODULE (RIGHT QUARTERPANEL) PARKING AID SPEAKER (LEFT SIDE OF DASH) REAR SOUNDER - RF SIDE SN RIGHT ACTIVE PARK ASSIST SENSOR RIGHT INNER PARKING AID SENSOR (RIGHT SIDE OF REAR BUMPER) RIGHT OUTER PARKING AID SENSOR (RIGHT SIDE OF REAR BUMPER) RIL SENS RIR SENS ROL SENS ROR SENS SENS GND SENS PWR SOLID STATE VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VPWR W/ REAR VIEW CAMERA WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE

2.0L TURBO 3.5L 3.5L TURBO 3.5L 3.5L TURBO CRUISE CONTROL MODULE 3.5L (CCM) (W/ ADAPTIVE CRUISE) A/C CLUTCH RELAY ANTI-LOCK BRAKE SYSTEM (ABS) MODULE AUXILIARY BLOWER MOTOR RELAY BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK/GRY WIRE BLOWER MOTOR RELAY BODY CONTROL MODULE (BCM) (LEFT END OF DASH) BRN WIRE BRN/RED WIRE BRN/VIO WIRE BRN/WHT WIRE CRUISE CONTROL MODULE (CCM) (W/ ADAPTIVE CRUISE) EVAPORATIVE EMISSION (EVAP) CANISTER PURGE VALVE EVAPORATIVE EMISSION (EVAP) CANISTER VENT VALVE EXCEPT 3.5L 3.5L FROM FUSE 61 (DIAGRAM 1 OF 5) FROM PCM POWER RELAY FUSE FUSE (DIAGRAM 2 OF 5) FUEL PUMP (FP) RELAY FUSE FUSE 79 FUSE 86 FUSE 87 FUSE 21 FUSE FUSE FUSE FUSE FUSE GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRY/BRN WIRE JUNCTION BOX JUNCTION WIRING ASSEMBLY, NEAR BREAKOUT TO BRAKE FLUID LEVEL SWITCH) LEFT GATE RELEASE RELAY (POLICE) LEFT SIDE STOP LAMP (POLICE) NCA WIRE ORG YEL/ WIRE PARKING LAMP TRAILER TOW RELAY PCM POWER RELAY POLICE POWERTRAIN CONTROL MODULE (PCM) REAR WASHER RELAY REAR WINDOW DEFROST RELAY FUSE REAR WINDOW WIPER MOTOR RED WIRE RED/ WHT WIRE REVERSING TRAILER TOW RELAY RIGHT HEADLAMP ASSEMBLY (W/ HID) RIGHT TURN LEFT TURN TRAILER TRAILER TOW RELAY TOW RELAY RUN/START POWER (FET) STEERING CONTROL MODULE (PSCM) RUN/START RELAY SOLENOID SOLENOID SOLENOID (EXCEPT 2.0L (3.5L) TURBO) THIRD ROW POWER POINT (W/ CONSOLE, EXCEPT POLICE) TO FUSE 67 (DIAGRAM 2 OF 5) TO FUSE 68 (NOT (DIAGRAM USED) 3 OF 5) TRANSMISSION CONTROL MODULE (TCM) (2.0L TURBO) UNIVERSAL HEATED OXYGEN VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT RED/ WIRE WHT/RED WIRE WHT/VIO WIRE YEL/ORG WIRE YEL/RED WIRE

2.0L 2.0L (EXCEPT TURBO 2.0L TURBO) 3.5L TURBO 2.0L TURBO A/C CLUTCH RELAY ACC/RUN START/RUN ALL WHEEL DRIVE (AWD) RELAY MODULE (EXCEPT 2.0L TURBO) AUDIO CONTROL MODULE (ACM) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK/BLU WIRE BLU WIRE BLU/ WHT WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BRN/ WHT WIRE COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 2 (COP) 1 (COP) 3 COIL ON COIL ON PLUG PLUG (COP) 3 (COP) 4 COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 4 COIL ON PLUG (COP) 5 COIL ON PLUG (COP) 6 COIL ON PLUG (COP) 1 COLUMN 3.5L SHIFTER TURBO 2.0L FLOOR SHIFTER TURBO 3.5L EXTERNALLY CONTROLLED VARIABLE DISPLACEMENT COMPRESSOR (EVDC) (EXCEPT 3.5L) FLOOR SHIFTER FROM FUSE 69 (DIAGRAM FUSE FUSE 2 OF 5) FROM HIGH CURRENT BATTERY JUNCTION BOX (BJB) (DIAGRAM 1 OF 5) FUSE FUSE 1 FUSE 3 FUSE 11 FUSE 2 FUSE 21 FUSE 7 FUSE FUSE FUSE FUSE 6 FUSE FUSE LIFTGATE RELEASE GLOBAL POSITIONING SYSTEM MODULE (GPSM) (W/ SYNC) GRN/RED WIRE GRY WIRE GRY/RED WIRE HEAD UP DISPLAY (HUD) MODULE (W/ ADAPTIVE CRUISE) HIGH FAN COOLING (HFC) RELAY 1 HIGH FAN COOLING (HFC) RELAY 2 IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) KEY IN KEY-IN IGNITION SWITCH KEYLESS DRIVER ENTRY SEAT KEYPAD MODULE (DSM) LOCK LOW FAN COOLING (LFC) RELAY MICRO BODY CONTROL MODULE (BCM) (LEFT END OF DASH) NCA WIRE OFF POLICE POLICE LIFTGATE/ TRUNK MODULE EXCEPT POLICE (LTM) RED WIRE RED/ BLU WIRE RELAY REMOTE FUNCTION ACTUATOR (RFA) MODULE (W/ INTELLIGENT ACCESS) RIGHT FRONT LEFT FRONT POWER POWER WINDOW WINDOW MOTOR MOTOR ROW SEAT (DIAGRAM 5 OF 5) RUN WIRE SPORT, XLT, LIMITED START/ STOP 1 (ACTIVE HIGH) START/ STOP 2 (ACTIVE LOW) START/STOP SWITCH TAPED TO HARNESS TO BATTERY JUNCTION BOX (BJB) DIAGRAM 5 OF 5) TURBOCHARGER (TC) WASTEGATE REGULATING VALVE SOLENOID (EXCEPT 3.5L) TURBOCHARGER BYPASS VALVE (TCBY) (EXCEPT 3.5L) TURBOCHARGER BYPASS VALVE 2 VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE W/O INTELLIGENT ACCESS W/ INTELLIGENT ACCESS WHT BRN WIRE WHT WIRE WHT/ BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL RED/ WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 K LINE 2 4 3 5 VBATT CLOCK DATA GND ACCESSORY DELAY RELAY AJAR BACKUP TRANSCEIVER (UNDER CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BODY CONTROL MODULE (LEFT END OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DOOR LOCK DOOR UNLOCK DRIVER SIDE DOOR LOCK CONTROL SWITCH FUSE FUSE 21 FUSE 28 FUSE 23 FUSE 27 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/VIO WIRE HOOD AJAR HOOD SWITCH (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES INTERNAL ANTENNA RKE RECEIVER K LINE MS MS CAN + CAN - LEFT FRONT DOOR LATCH LEFT REAR DOOR LATCH LF DOOR AJAR LOCK LR DOOR AJAR MEMORY SET SWITCH SET 3 MEMORY SYSTEMS MICRO - MS CAN + MS CAN - MS CAN + ORG/ WIRE POWER DISTRIBUTION SYSTEM PWR GND PWR GND ALL LOCK DOOR UNLOCK NOT USED DR DOOR UNLOCK REMOTE FUNCTION ACTUATOR (RFA) MODULE (UNDER GLOVE BOX) RF DOOR AJAR RIGHT FRONT DOOR LATCH RIGHT REAR DOOR LATCH RR DOOR AJAR SET 1 SET 2 TIRE PRESSURE MONITOR MODULE (UNDER CENTER CONSOLE) TRUNK, TAILGATE, FUEL DOORS SYSTEM UNLOCK VBATT VBATT KEYPAD ILLM(FET) VBATT CLOCK DATA GND GND VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE W/ MEMORY W/O MEMORY WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRY WIRE YEL/VIO WIRE