Ford Explorer IV (2005-2010) wht/org Wiring diagrams

3 4 15 8 22 24 16 21 MEM SET SW MEM RECALL 2 SW MEM RECALL 1 SW MEM IND LED ADJUSTABLE PEDAL MOTOR (ON PEDAL ASSEMBLY, LEFT OF BRAKE PEDAL) ADJUSTABLE PEDAL SWITCH BACK BLK/BLU WIRE BLK/ORG WIRE BLK/VIO WIRE BLK/WHT WIRE BLU/BRN WIRE BRN WIRE BRN/BLU WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DRIVER SEAT MODULE (IN DRIVER'S SEAT) EXPLORER, MOUNTAINEER FRONT FUSE 1 GRN WIRE GRY/ORG WIRE HOT AT ALL TIMES LOGIC MEMORY SEATS CIRCUIT MEMORY SET SWITCH PEDAL MTR FORE PEDAL HALL EFF SNS RET PEDAL HALL EFF FEED PEDAL MTR AFT RED WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO/ORG WIRE VIO/WHT WIRE WHT/ORG WIRE YEL WIRE YEL/BLU WIRE YEL/GRY WIRE

1 2 B + R/ACC AUDIO CONTROL MODULE (ACM) AUDIO JACK AUDIO SHLD BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BRN WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM FUSE 11 FUSE 12 FUSE 3 GRN/WHT WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START L FRONT SPKR + L REAR SPKR + R REAR SPKR + R FRONT SPKR + R FRONT SPKR - GND L FRONT SPKR - L REAR SPKR - R REAR SPKR - 22 23 LEFT FRONT SPEAKER LEFT REAR SPEAKER NCA WIRE R + L + L - R - MS CAN + MS CAN - RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SMART JUNCTION BOX (SJB) TWISTED PAIR WIRES VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/GRN WIRE

2 1 VBATT PWR GND ADJUSTABLE PEDAL CIRCUIT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/ORG WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DN UP DRIVER SEAT LUMBAR COMPRESSOR MOTOR (IN DRIVER'S SEAT BACK) DRIVER SEAT MODULE (IN DRIVER'S SEAT) DRIVER SEAT RECLINER MOTOR (RIGHT SIDE OF DRIVER'S SEAT BACK) ENTIRE SEAT EXPLORER, MOUNTAINEER FRONT OF SEAT FRONT UP/DOWN FRT TILT DN SW HORZ BASE FORE SW REAR TILT DN SW FRT TILT HALL EFECT SN REAR TILT MTR UP FRT TILT MTR UP FRT TILT UP SW HORZ BASE AFT SW REAR TILT UP SW FUSE 1 FUSE 14 FWD RWD FWD/RWD GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HORIZONTAL HORZ BASE AFT RECLINE MTR UP HORZ BASE FORE HOT AT ALL TIMES IN OUT LEFT POWER SEAT MOTOR ASSEMBLY (UNDER DRIVER'S SEAT) LEFT POWER SEAT SWITCH LUMBAR OF SEAT MEM IND LED MEMORY SET SWITCH MS CAN - MS CAN + ORG/ WIRE PEDAL HALL EFF FEED PEDAL HALL EFF SNS RET PEDAL MTR AFT PEDAL MTR FORE REAR OF SEAT REAR UP/DOWN RECLINE DN SW RECLINE HALL EFFECT SN RECLINE OF SEAT RED WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE

1 LO AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRY WIRE BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EXPLORER, MOUNTAINEER FOG LAMP IND FOG LAMP RELAY FTP FTP/HIGH FULL LEFT FUSE 29 FUSE 31 FUSE 34 GRN WIRE GRN/BRN WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HSD INSTRUMENT CLUSTER (IC) INTERIOR (BASE OF RIGHT "B" PILLAR) LIGHTS SYSTEM LAMPS FOG LANE CHANGE FULL RIGHT LANE CHANGE NEUTRAL LEFT FRONT FOG LAMP (LATE PRODUCTION) LEFT HEADLAMP HI MAIN LIGHT SWITCH MS CAN + MULTI- FUNCTION SWITCH OFF OFF PARK LOW AUTO ORG/ WIRE PARK BRAKE SWITCH RED WIRE RIGHT FRONT FOG LAMP (LATE PRODUCTION) RIGHT HEADLAMP HI SENSE SENSE A/D SENSE SENSE SENSE SENSE SENSE MED CAN SENSE SENSE SENSE SENSE SIG PWM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SOLID STATE CONTROL SPORT TRAC VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) YEL WIRE

1 LO BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRY WIRE BLK/VIO WIRE BLU WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EXPLORER, MOUNTAINEER FOG LAMP IND FOG LAMP RELAY FTP FTP/HIGH FULL LEFT FUSE 29 FUSE 31 FUSE 34 GRN WIRE GRN/BRN WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HSD INSTRUMENT CLUSTER (IC) INTERIOR (BASE OF RIGHT "B" PILLAR) LIGHTS SYSTEM LAMPS FOG LANE CHANGE FULL RIGHT LANE CHANGE NEUTRAL LEFT FRONT FOG LAMP (LATE PRODUCTION) LEFT HEADLAMP HI MAIN LIGHT SWITCH MS CAN + MULTI- FUNCTION SWITCH OFF OFF PARK LOW AUTO ORG/ WIRE PARK BRAKE SWITCH RED WIRE RIGHT FRONT FOG LAMP (LATE PRODUCTION) RIGHT HEADLAMP HI SENSE SENSE SENSE SENSE MED CAN SENSE SENSE SENSE SENSE SIG PWM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SPORT TRAC VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 HAT RUN/START 1 3 2 4 DIMMER 14 15 16 17 18 19 20 21 22 23 24 25 26 KEY IN 3 1 2 4 PWR COMPASS+ COMPASS- GND 39 7 12 13 LVL SW LVL SW RTN HI CAN + HI CAN - ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) ANTI-THEFT SYSTEM BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/VIO WIRE BLK/WHT WIRE BLU WIRE BLU/BRN WIRE BLU/GRY WIRE COMPUTER DATA LINES SYSTEM DRIVER SIDE FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (AT REAR OF LEFT REAR DOOR) ELECTRONIC COMPASS EPATS GND EPATS RX EPATS TX FUEL LEVEL ANALOG GND OIL PRESS MESSAGE CNTR+ FUEL TANK LEVEL SENDER FUSE 18 FUSE 24 GND P GRN WIRE GRN/BLK WIRE GRN/BLU WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED HS CAN+ HS CAN- WASHER LEVEL COMPASS- COMPASS+ ANTI THEFT MD GND IGNITION SWITCH INSTRUMENT CLUSTER KEY-IN IGNITION SWITCH LIFTGATE AJAR SWITCH (LOWER CENTER OF LIFTGATE) LIFTGATE GLASS AJAR SWITCH MESSAGE CENTER SWITCH MS CAN + MS CAN - MS CAN + OFF ORG/ WIRE OUTSIDE AIR TEMP PARK BRAKE SWITCH (BEHIND TOP OF LEFT KICK PANEL) PASSENGER SIDE FRONT DOOR AJAR SWITCH (AT REAR OF RIGHT FRONT DOOR) PASSENGER SIDE REAR DOOR AJAR SWITCH (AT REAR OF RIGHT REAR DOOR) RUN WIRE SENSE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PWR ST OR RUN SNDR+ MS CAN+ GND BLK/BLU WIRE BLU/GRN WIRE BLU/WHT WIRE BRN/BLU WIRE COMPUTER DATA LINES SYSTEM FUSE 18 GRN/WHT WIRE GRY WIRE GRY/ORG WIRE HOT IN START OR RUN LEFT INNER PARKING AID SENSOR (AT LEFT SIDE OF REAR BUMPER) LEFT OUTER PARKING AID SENSOR (AT LEFT SIDE OF REAR BUMPER) MS CAN- SEN GND IR SEN IN IL SEN IN OL SEN IN OR SEN IN ORG/ WIRE PARKING AID MODULE (PAM) (AT RIGHT "D" PILLAR) RIGHT INNER PARKING AID SENSOR (AT RIGHT SIDE OF REAR BUMPER) RIGHT OUTER PARKING AID SENSOR (AT RIGHT SIDE OF REAR BUMPER) SEN PWR SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SNDR GND SOLID STATE VIO/ORG WIRE WHT/ORG WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE

ACC/DELAY RELAY BLK WIRE BLU/GRY WIRE BLU/ORG WIRE BRN WIRE BRN/GRN WIRE BRN/YEL WIRE CIRCUIT BREAKER 1 CONTROL DRIVER SIDE FRONT POWER WINDOW MOTOR (IN CENTER OF LEFT FRONT DOOR) ELECT FRONT GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/VIO WIRE LEFT REAR LEFT REAR POWER WINDOW MOTOR (IN CENTER OF LEFT REAR DOOR) LEFT REAR WINDOW ADJUST SWITCH LOCKOUT MASTER WINDOW ADJUST SWITCH ONE SHOT PASSENGER SIDE FRONT POWER WINDOW MOTOR (IN CENTER OF RIGHT FRONT DOOR) PASSENGER SIDE WINDOW ADJUST SWITCH RED WIRE RIGHT RIGHT REAR RIGHT REAR POWER WINDOW MOTOR (IN CENTER OF RIGHT REAR DOOR) RIGHT REAR WINDOW ADJUST SWITCH SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE

11 12 MIC + MIC - 12 11 21 8 R FRONT SPKR - R FRONT SPKR + L FRONT SPKR - L FRONT SPKR + 22 9 23 10 L REAR SPKR - L REAR SPKR + R REAR SPKR - R REAR SPKR + 3 4 2 1 SHIELD DETECT SW + SW - 4 5 MONO + MONO - 9 10 1 2 STEREO R + STEREO R - STEREO L + STEREO L - AUDIO CONTROL MODULE (ACM) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE DETECT FUSE 22 GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT REAR SPEAKER NCA WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SW+ TWISTED PAIR WIRES VIO WIRE VIO/GRN WIRE VIO/RED WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE CAMSHAFT POSITION SENSOR 1 (FRONT RIGHT CYLINDER HEAD) CHT CKP- CKP+ FRP FSS MAF MAFRTN EOT GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BRN WIRE GRY/VIO WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR HTR-11 HTR 21 IAT IMRC TACM N INJ 5 POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) TACM P VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREFE SIGRTNE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE