Ford Explorer IV (2005-2010) hat Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 MS CAN- PWR GND RUN/START 3 2 1 4 5 6 VAC 2 VAC 1 GND VAC 3 VAC 4 VAC 5 4 3 2 1 5 MTR SINK HBR SW IN VAR SPD IN FB OUT GROUND ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLOWER CTRL VAC 5 HCWV BLOWER MOTOR RELAY 1 BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BREAKOUT TO ENGINE COMPT BULKHEAD) BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE (BEHIND LOWER CENTER OF DASH) DIMMING IN DRIVER TEMPERATURE BLEND DOOR ACTUATOR (REAR LEFT SIDE OF HVAC UNIT) EXPLORER, MOUNTAINEER FRONT BLOWER MOTOR (RIGHT SIDE OF HVAC UNIT) FRONT BLOWER MOTOR SPEED CONTROLLER (CENTER OF HVAC UNIT) FUSE 16 FUSE 24 FUSE 28 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT CENTER OF DASH) INSTRUMENT CLUSTER LEFT BD FEEDBACK RIGHT BD FEEDBACK MS CAN+ PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (FRONT LEFT SIDE OF HVAC UNIT) RED WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SENSE A/D VBC FB SN GND IN CAR TEMP VBC OUT RIGHT SUNLOAD AMB TEMP LEFT SUNLOAD VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

4.OL BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE FUSE JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) FUSIBLE LINK A (8 GA- FUSIBLE LINK B (20 GA- GENERATOR GRN WIRE GRY WIRE HAT HOT AT ALL TIMES HS CAN+ ILC INSTRUMENT CLUSTER POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) RED WIRE SMART STARTING CIRCUIT VIO WIRE VIO/RED WIRE WHT WIRE WHT/BLU WIRE YEL WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BPS BOO HS CAN + BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE CLOCKSPRING (AT TOP OF COMPUTER DATA LINES SYSTEM DEACTIVATOR SWITCH (ON BRAKE PEDAL SUPPORT) DIGITAL TRANSMISSION RANGE (DTR) SENSOR FUSE FUSE 24 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES HOT W/ PCM POWER RELAY ENERGIZED HS CAN+ HS HS CAN+ CAN- INSTRUMENT CLUSTER OFF SET- ORG/ WIRE OSS + OUTPUT SHAFT SPEED (OSS) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) RED WIRE RES ON SCCS SCCS RTN SENSOR SET- SIGRTNT SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SOLID STATE STEERING COLUMN) STEERING WHEEL/ SPEED CONTROL SWITCH TACM N TACM P THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/VIO WIRE BLU WIRE BRN WIRE ELECTRONICS FRONT WASHER RELAY FRONT WIPER RELAY FRONT WIPER SWITCH FUSE 20 GRN WIRE GRY WIRE HAT HIGH/LOW SPEED RELAY HOT AT ALL TIMES HOT AT ALL TIMES FUSE 24 HOT IN RUN OR ACC FUSE 10 INSTRUMENT CLUSTER ORG/ WIRE PARK REAR WASHER RELAY REAR WIPER MODULE (CENTER OF LIFTGATE) RED WIRE RUN WIRE RUN/PARK RELAY SENSE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TWO-WAY WASHER PUMP MOTOR (RIGHT FRONT CORNER OF ENGINE COMPT) VIO WIRE VIO/RED WIRE WASH LEVEL WASHER FLUID LEVEL SWITCH (RIGHT FRONT CORNER OF ENGINE COMPT) WASHER SWITCH WHT WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) YEL WIRE

14 15 16 41 18 ACCR ACCS 5 2 3 4 6 GND VPWR VBPWR FSS FC V 7 24 20 58 18 57 FC V FSS VBPWR SIGRTNE ECT VREF A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C PRESSURE TRANSDUCER (LEFT FRONT OF ENGINE COMPT) ACPT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY 1 BLOWER MOTOR RELAY 2 (FRONT OF HVAC UNIT) BLU/BLK WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/RED WIRE CLIMATE CONTROL ASSEMBLY ELECTRONIC FAN CLUTCH (CENTER FRONT OF ENGINE) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ECT) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (FRONT OF HVAC UNIT) FUSE FUSE 13 FUSE 16 FUSE 28 FUSE 35 GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/BRN WIRE GRY/VIO WIRE GRY/YEL WIRE HAT HOT AT ALL TIMES HOT W/ PCM RELAY ENERGIZED HOT W/ REAR DEFROST RELAY ENERGIZED LOW HIGH BLOWER SWITCH MED HIGH MED LOW MODE SWITCH OFF PANEL/FLOOR FLOOR MIX PANEL MAX DEF POTENTIOMETER POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) SENSE SIG RTN SIGRTNC ACPT TEMPERATURE POTENTIOMETER VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE VREF WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

AUTOLAMP/ SUNLOAD SENSOR BAT SAVER BLU WIRE BRN WIRE CONTROL DRIVER SIDE EXTERIOR REAR VIEW MIRROR FROM FUSE 2 BATTERY JUNCTION BOX (BJB) (DIAGRAM 1 OF 6) FROM FUSE 23 SMART JUNCTION BOX (SJB) (DIAGRAM 3 OF 6) FRONT INTERIOR/ FUSE 22 TO HSD SMART JUNCTION BOX (SJB) (DIAGRAM 5 OF 6) FUSE 23 FUSE 24 FUSE 27 FUSE 28 GLOVE BOX LAMP) GRN WIRE GRY WIRE HAT HAT HAT HORN RELAY HSD INTERIOR LAMPS HSD LEFT FRONT TURN HVAC CLIMATE MODULE CONTROL (DATC) ASSEMBLY (MANUAL A/C) INSTRUMENT CLUSTER (IC) LEFT FRONT PARK/ TURN LAMP LEFT REAR PARK/STOP TURN LAMP LEFT REAR TURN/ STOP LEFT VANITY MIRROR LAMP MAP LAMP ASSEMBLY NCA WIRE PARK LAMP RELAY PASSENGER CARGO SIDE LAMP EXTERIOR ASSEMBLY REAR VIEW MIRROR PUDDLE LAMP RELAY REAR INTERIOR LAMP RED WIRE RIGHT VANITY MIRROR LAMP SIDE OF DASH) SMART JUNCTION BOX (SJB) SMART JUNCTION BOX (SJB) (BEHIND LEFT TO FUSE 28 SMART JUNCTION BOX (SJB) (DIAGRAM 3 OF 6) TO HSD SMART JUNCTION BOX (SJB) (DIAGRAM 4 OF 6) TRICOLOR STOP VIO WIRE W/ MOON- ROOF W/O (IN MOON- INTERIOR LIGHT ROOF FEED HARNESS, NEAR BREAKOUT TO FRONT OF ROOF) W/O MOON- ROOF YEL WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/VIO WIRE BLU WIRE BRN WIRE ELECTRONICS ENGINE COMPT) FRONT WASH SWITCH FRONT WASHER RELAY FRONT WIPER RELAY FRONT WIPER SWITCH FUSE 20 GRN WIRE GRY WIRE HAT HIGH/LOW SPEED RELAY HOT AT ALL TIMES HOT AT ALL TIMES FUSE 24 HOT IN RUN OR ACC FUSE 10 INSTRUMENT CLUSTER ORG/ WIRE PARK RED WIRE RUN WIRE RUN/PARK RELAY SENSE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/RED WIRE WASH LEVEL WASHER FLUID LEVEL SWITCH (RIGHT FRONT CORNER OF ENGINE COMPT) WASHER PUMP MOTOR (ON WASHER RESERVOIR TANK) WHT WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF YEL WIRE