Ford Explorer IV (2005-2010) grn/red Wiring diagrams

11 12 MS CAN + MS CAN - 3 11 MS CAN + MS CAN - 4 8 7 5 MS CAN + HS CAN - HS CAN + MS CAN - 9 18 HS CAN - HS CAN + ABS TEST CONNECTOR (LEFT SIDE OF ENGINE COMPT) ACCESSORY PROTOCOL INTERFACE MODULE (APIM) (LATE PRODUCTION) ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) AUDIO CONTROL MODULE (ACM) BLK/WHT WIRE BLU WIRE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) FEPS FUSE 4 GRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ INSTRUMENT CLUSTER MODULE MS CAN + OCCUPANT CLASSIFICATION SYSTEM MODULE(OCSM) (UNDER FRONT PASSENGER'S SEAT) ORG/ WIRE PARKING AID MODULE (PAM) (AT RIGHT "D" PILLAR) POWER RUNNING BOARD (PRB) MODULE (ABOVE RIGHT WHEELWELL) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) REAR ENTERTAINMENT MODULE (RETM) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (BELOW CENTER FLOOR CONSOLE) SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (BEHIND RIGHT KICK PANEL) SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

2 6 HS CAN - HS CAN + 4 8 7 5 MS CAN + HS CAN - HS CAN + MS CAN - 9 18 HS CAN - HS CAN + ABS TEST CONNECTOR (LEFT SIDE OF ENGINE COMPT) ACCESSORY PROTOCOL INTERFACE MODULE (APIM) (LATE PRODUCTION) ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) AUDIO CONTROL MODULE (ACM) BLK/WHT WIRE BLU WIRE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) FEPS FUSE 4 GRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ HVAC MODULE (DATC) (BEHIND LOWER CENTER OF DASH) INSTRUMENT CLUSTER MODULE MS CAN + OCCUPANT CLASSIFICATION SYSTEM MODULE(OCSM) (UNDER FRONT PASSENGER'S SEAT) ORG/ WIRE PARKING AID MODULE (PAM) (AT RIGHT "D" PILLAR) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) REAR ENTERTAINMENT MODULE (RETM) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (BELOW CENTER FLOOR CONSOLE) SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (BEHIND RIGHT KICK PANEL) SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TRANSMISSION CONTROL MODULE (TCM) (RIGHT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 MS CAN- PWR GND RUN/START 3 2 1 4 5 6 VAC 2 VAC 1 GND VAC 3 VAC 4 VAC 5 4 3 2 1 5 MTR SINK HBR SW IN VAR SPD IN FB OUT GROUND ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLOWER CTRL VAC 5 HCWV BLOWER MOTOR RELAY 1 BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BREAKOUT TO ENGINE COMPT BULKHEAD) BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE (BEHIND LOWER CENTER OF DASH) DIMMING IN DRIVER TEMPERATURE BLEND DOOR ACTUATOR (REAR LEFT SIDE OF HVAC UNIT) EXPLORER, MOUNTAINEER FRONT BLOWER MOTOR (RIGHT SIDE OF HVAC UNIT) FRONT BLOWER MOTOR SPEED CONTROLLER (CENTER OF HVAC UNIT) FUSE 16 FUSE 24 FUSE 28 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT CENTER OF DASH) INSTRUMENT CLUSTER LEFT BD FEEDBACK RIGHT BD FEEDBACK MS CAN+ PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (FRONT LEFT SIDE OF HVAC UNIT) RED WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SENSE A/D VBC FB SN GND IN CAR TEMP VBC OUT RIGHT SUNLOAD AMB TEMP LEFT SUNLOAD VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 FUSE 13 OR CIRCUIT BREAKER AIR CONDITIONING SYSTEM ALL EXCLUDING DRV GND FUSE 23 OR CIRCUIT BREAKER DOOR LOCK ALL LOCK ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM INSTRUMENT CLUSTER SYSTEM BACKUP LAMPS RELAY ILLUM BATTERY SAVER RELAY BLK WIRE BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM ANTI-THEFT SYSTEM DR LOCK DRV UNLOCK CTRL MOD ILLUM EXTERIOR LIGHTS SYSTEM (NOT USED) EXTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS, MIRRORS SYSTEMS FUSE 1 OR CIRCUIT BREAKER FUSE 18 OR CIRCUIT BREAKER FUSE 5 OR CIRCUIT BREAKER FUSE 1 OR CIRCUIT BREAKER GRN WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HORNS SYSTEM IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM MIRRORS SYSTEM DOOR LOCKS SYSTEM NAVIGATION, MIRRORS, INSTRUMENT CLUSTER, AIR CONDITIONING SYSTEMS OFF POWER WINDOWS SYSTEM POWER TOPS, SEATS SYSTEMS RED WIRE RUN WIRE SEATS, MEMORY SYSTEMS SHIFT INTERLOCK SYSTEM COMPUTER DATA LINES SYSTEM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SOUND SYSTEMS SOUND SYSTEMS INTERIOR LIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TRANSMISSIONS, SEATS SYSTEMS ANTI-LOCK BRAKES SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/VIO WIRE

14 15 16 41 18 ACCR ACCS 5 2 3 4 6 GND VPWR VBPWR FSS FC V 7 24 20 58 18 57 FC V FSS VBPWR SIGRTNE ECT VREF A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C PRESSURE TRANSDUCER (LEFT FRONT OF ENGINE COMPT) ACPT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY 1 BLOWER MOTOR RELAY 2 (FRONT OF HVAC UNIT) BLU/BLK WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/RED WIRE CLIMATE CONTROL ASSEMBLY ELECTRONIC FAN CLUTCH (CENTER FRONT OF ENGINE) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ECT) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (FRONT OF HVAC UNIT) FUSE FUSE 13 FUSE 16 FUSE 28 FUSE 35 GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/BRN WIRE GRY/VIO WIRE GRY/YEL WIRE HAT HOT AT ALL TIMES HOT W/ PCM RELAY ENERGIZED HOT W/ REAR DEFROST RELAY ENERGIZED LOW HIGH BLOWER SWITCH MED HIGH MED LOW MODE SWITCH OFF PANEL/FLOOR FLOOR MIX PANEL MAX DEF POTENTIOMETER POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) SENSE SIG RTN SIGRTNC ACPT TEMPERATURE POTENTIOMETER VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE VREF WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

1 1 1 1 1 1 SIG RTN SIG FEED SIG FEED SIG RTN SIG RTN SIG FEED 1 1 1 1 SIG FEED SIG RTN SIG RTN SIG FEED 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 RUN/START 5-6, 3-4, 8-7, 9-10, BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE EXCEPT EXPLORER SPORT TRAC EXPLORER SPORT TRAC FUSE 17 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOT IN RUN OR START LEFT REAR SIDE IMPACT SENSOR (OVER LEFT REAR WHEELWELL) (IN LEFT "C" PILLAR) LEFT SIDE AIR BAG MODULE (LEFT SIDE OF DRIVER'S SEAT BACK) NCA WIRE ORG/ WIRE PAD LAMP PASSENGER AIR BAG DEACTIVATION (PAD) INDICATOR PAD IND PASSENGER AIR BAG MODULE (BEHIND RIGHT SIDE OF DASH) PASSENGER SAFETY BELT BUCKLE PRETENSIONER (UNDER FRONT PASSENGER'S SEAT) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (BELOW CENTER FLOOR CONSOLE) RIGHT REAR SIDE IMPACT SENSOR (OVER RIGHT REAR WHEELWELL) (IN RIGHT "C" PILLAR) RIGHT SAFETY CANOPY (AT RIGHT "C" PILLAR) RIGHT SIDE AIR BAG MODULE (RIGHT SIDE OF FRONT PASSENGER'S SEAT BACK) SHORTING BAR SIG RTN SIG FEED SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

A/C CLUTCH RELAY BATTERY JUNCTION BLK WIRE BLK/GRN WIRE BLK/ORG WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BRN/WHT WIRE BRN/YEL WIRE CDA CDB CDC ECT EVAP EXCEPT SPORT TRAC FC-V FP PWR FPC FPM FPM RTN FRT FUEL PUMP DRIVER MODULE FUEL PUMP MOTOR (UNDER RIGHT SIDE OF VEHICLE) FUEL PUMP RELAY FUEL TANK LEVEL SENSOR (UNDER RIGHT SIDE OF VEHICLE) FUSE 4 FUSE 40 FUSE 38 FUSE 42 FUSE 43 FUSE 39 FUSE 44 FUSE 7 GRN WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HEATED POSITIVE CRANKCASE HOT AT ALL TIMES IGNITION TRANSFORMER CAPACITOR (AT TOP LEFT OF ENGINE) INERTIA FUEL SHUTOFF (IFS) SWITCH (BEHIND RIGHT KICK PANEL) INSTRUMENT CLUSTER SYSTEM MD GND NCA WIRE PCM POWER RELAY PCV HC PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) SPORT TRAC VBPWR VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE YEL/WHT WIRE

A/C CLUTCH RELAY BATTERY JUNCTION BLK WIRE BLK/GRN WIRE BLK/ORG WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BRN/WHT WIRE BRN/YEL WIRE CDA CDB CDC CDD CDE CDF CDG CDH EVAP EXCEPT SPORT TRAC FC-V FP PWR FPC FPM FPM RTN FRT FUEL PUMP DRIVER MODULE FUEL PUMP MOTOR (UNDER RIGHT SIDE OF VEHICLE) FUEL PUMP RELAY FUEL TANK LEVEL SENSOR (UNDER RIGHT SIDE OF VEHICLE) FUSE 39 FUSE 43 FUSE 40 FUSE 4 FUSE 42 FUSE 44 FUSE 7 GRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/VIO WIRE HOT AT ALL TIMES INERTIA FUEL SHUTOFF (IFS) SWITCH (BEHIND RIGHT KICK PANEL) INSTRUMENT CLUSTER SYSTEM MD GND NCA WIRE PCM POWER RELAY PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) SPORT TRAC VBPWR VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE YEL/WHT WIRE