Ford Explorer IV (2005-2010) fuse 24 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 MS CAN- PWR GND RUN/START 3 2 1 4 5 6 VAC 2 VAC 1 GND VAC 3 VAC 4 VAC 5 4 3 2 1 5 MTR SINK HBR SW IN VAR SPD IN FB OUT GROUND ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLOWER CTRL VAC 5 HCWV BLOWER MOTOR RELAY 1 BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BREAKOUT TO ENGINE COMPT BULKHEAD) BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE (BEHIND LOWER CENTER OF DASH) DIMMING IN DRIVER TEMPERATURE BLEND DOOR ACTUATOR (REAR LEFT SIDE OF HVAC UNIT) EXPLORER, MOUNTAINEER FRONT BLOWER MOTOR (RIGHT SIDE OF HVAC UNIT) FRONT BLOWER MOTOR SPEED CONTROLLER (CENTER OF HVAC UNIT) FUSE 16 FUSE 24 FUSE 28 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT CENTER OF DASH) INSTRUMENT CLUSTER LEFT BD FEEDBACK RIGHT BD FEEDBACK MS CAN+ PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (FRONT LEFT SIDE OF HVAC UNIT) RED WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SENSE A/D VBC FB SN GND IN CAR TEMP VBC OUT RIGHT SUNLOAD AMB TEMP LEFT SUNLOAD VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BPS BOO HS CAN + BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE CLOCKSPRING (AT TOP OF COMPUTER DATA LINES SYSTEM DEACTIVATOR SWITCH (ON BRAKE PEDAL SUPPORT) DIGITAL TRANSMISSION RANGE (DTR) SENSOR FUSE FUSE 24 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES HOT W/ PCM POWER RELAY ENERGIZED HS CAN+ HS HS CAN+ CAN- INSTRUMENT CLUSTER OFF SET- ORG/ WIRE OSS + OUTPUT SHAFT SPEED (OSS) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) RED WIRE RES ON SCCS SCCS RTN SENSOR SET- SIGRTNT SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SOLID STATE STEERING COLUMN) STEERING WHEEL/ SPEED CONTROL SWITCH TACM N TACM P THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 HAT RUN/START 1 3 2 4 DIMMER 14 15 16 17 18 19 20 21 22 23 24 25 26 KEY IN 3 1 2 4 PWR COMPASS+ COMPASS- GND 39 7 12 13 LVL SW LVL SW RTN HI CAN + HI CAN - ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) ANTI-THEFT SYSTEM BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/VIO WIRE BLK/WHT WIRE BLU WIRE BLU/BRN WIRE BLU/GRY WIRE COMPUTER DATA LINES SYSTEM DRIVER SIDE FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (AT REAR OF LEFT REAR DOOR) ELECTRONIC COMPASS EPATS GND EPATS RX EPATS TX FUEL LEVEL ANALOG GND OIL PRESS MESSAGE CNTR+ FUEL TANK LEVEL SENDER FUSE 18 FUSE 24 GND P GRN WIRE GRN/BLK WIRE GRN/BLU WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED HS CAN+ HS CAN- WASHER LEVEL COMPASS- COMPASS+ ANTI THEFT MD GND IGNITION SWITCH INSTRUMENT CLUSTER KEY-IN IGNITION SWITCH LIFTGATE AJAR SWITCH (LOWER CENTER OF LIFTGATE) LIFTGATE GLASS AJAR SWITCH MESSAGE CENTER SWITCH MS CAN + MS CAN - MS CAN + OFF ORG/ WIRE OUTSIDE AIR TEMP PARK BRAKE SWITCH (BEHIND TOP OF LEFT KICK PANEL) PASSENGER SIDE FRONT DOOR AJAR SWITCH (AT REAR OF RIGHT FRONT DOOR) PASSENGER SIDE REAR DOOR AJAR SWITCH (AT REAR OF RIGHT REAR DOOR) RUN WIRE SENSE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM EPATS GND EPATS RX EPATS TX FUSE 24 HOT AT ALL TIMES HS CAN+ IGNITION SWITCH INSTRUMENT CLUSTER (IC) OFF ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) RED WIRE RF GND RF PWR RUN WIRE RUN/ST RX SIG SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TX SIG VIO WIRE VIO/GRY WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE

4.6L 4.0L ANTI-LOCK BRAKE SYSTEM MODULE AUXILIARY RELAY BOX 1 (RIGHT REAR OF ENGINE COMPT) BATTERY BATTERY FUSE 27 CHARGE TRAILER TOW RELAY BLK WIRE BLOWER MOTOR RELAY 1 FUSE 15 BLU WIRE BRN WIRE CONSOLE 1 POWER POINT CONSOLE 2 POWER POINT FROM FUSE 17 BATTERY FUSE 16 JUNCTION BOX (BJB) (DIAGRAM 1 OF 6) FUEL PUMP RELAY FUSE 1 FUSE 2 FUSE 10 FUSE 12 FUSE 11 FUSE 13 FUSE FUSE 21 FUSE 22 FUSE 23 FUSE 24 FUSE 25 FUSE 3 FUSE 4 FUSE 5 FUSE 6 FUSE 33 FUSE 7 FUSE 8 FUSE 9 FUSIBLE LINK A FUSIBLE LINK B GENERATOR GRN WIRE GRY WIRE LEFT HEATED WINDSHIELD RELAY LEFT POWER SEAT SWITCH LEFT THIRD ROW FOLDING SEAT RELAY PCM POWER RELAY POWERTRAIN FUEL CONTROL VAPOR MODULE VENT (PCM) VALVE REAR DEFROST RELAY REAR RIGHT WINDOW POWER MOTOR SEAT SWITCH RED WIRE RIGHT HEATED WINDSHIELD RELAY RIGHT THIRD ROW FOLDING SEAT RELAY SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) STARTER MOTOR STARTER RELAY SUBWOOFER AMPLIFIER CONTROL MODULE TO ACC/ DELAY RELAY SMART JUNCTION BOX (SJB) (DIAGRAM 2 OF 6) TO FUSE 16 FUSE 17 BATTERY JUNCTION BOX (BJB) (DIAGRAM 1 OF 6) TO FUSE 26 BATTERY JUNCTION BOX (BJB) (DIAGRAM 2 OF 6) TO HORN RELAY SMART JUNCTION BOX (SJB) (DIAGRAM 3 OF 6) TO REVERSE LAMP RELAY SMART JUNCTION BOX (SJB) (DIAGRAM 4 OF 6) TRAILER DRIVER BRAKE SEAT CONTROL MODULE (TBC) (DSM) MODULE TRANSMISSION CONTROL MODULE (TCM) VIO WIRE W/ MEMORY W/ MEMORY W/O MEMORY W/O MEMORY WHT WIRE YEL WIRE

AUTOLAMP/ SUNLOAD SENSOR BAT SAVER BLU WIRE BRN WIRE CONTROL DRIVER SIDE EXTERIOR REAR VIEW MIRROR FROM FUSE 2 BATTERY JUNCTION BOX (BJB) (DIAGRAM 1 OF 6) FROM FUSE 23 SMART JUNCTION BOX (SJB) (DIAGRAM 3 OF 6) FRONT INTERIOR/ FUSE 22 TO HSD SMART JUNCTION BOX (SJB) (DIAGRAM 5 OF 6) FUSE 23 FUSE 24 FUSE 27 FUSE 28 GLOVE BOX LAMP) GRN WIRE GRY WIRE HAT HAT HAT HORN RELAY HSD INTERIOR LAMPS HSD LEFT FRONT TURN HVAC CLIMATE MODULE CONTROL (DATC) ASSEMBLY (MANUAL A/C) INSTRUMENT CLUSTER (IC) LEFT FRONT PARK/ TURN LAMP LEFT REAR PARK/STOP TURN LAMP LEFT REAR TURN/ STOP LEFT VANITY MIRROR LAMP MAP LAMP ASSEMBLY NCA WIRE PARK LAMP RELAY PASSENGER CARGO SIDE LAMP EXTERIOR ASSEMBLY REAR VIEW MIRROR PUDDLE LAMP RELAY REAR INTERIOR LAMP RED WIRE RIGHT VANITY MIRROR LAMP SIDE OF DASH) SMART JUNCTION BOX (SJB) SMART JUNCTION BOX (SJB) (BEHIND LEFT TO FUSE 28 SMART JUNCTION BOX (SJB) (DIAGRAM 3 OF 6) TO HSD SMART JUNCTION BOX (SJB) (DIAGRAM 4 OF 6) TRICOLOR STOP VIO WIRE W/ MOON- ROOF W/O (IN MOON- INTERIOR LIGHT ROOF FEED HARNESS, NEAR BREAKOUT TO FRONT OF ROOF) W/O MOON- ROOF YEL WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH) ACPT SCCS AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) BLK/YEL WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/WHT WIRE BPS CSGND HS CAN+ FPC VAPVNT ACCR ACCS BRN/GRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DEACTIVATOR SWITCH (ON BRAKE PEDAL SUPPORT) FEPS KAPWR ISP-R GROUND GROUND GROUND GROUND FPM ILC HS CAN- FTPREF SIGRTNC FUEL PUMP DIODE FUEL TANK PRESSURE (FTP) SENSOR (UNDER RIGHT SIDE OF VEHICLE) FUSE 24 FUSE 9 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT IN START OR RUN OD CANCEL SCCS RTN POWER STEERING PRESSURE SWITCH (TOP LEFT FRONT OF ENGINE) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE ENGINE) PSPSW RED/WHT WIRE SHIFT INTERLOCK SYSTEM CRUISE CONTROL SYSTEM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE SNS OF DASH) SMR/START STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM ANTI-LOCK BRAKES SYSTEM VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE VPWR VPWR RLY CTRL SMCS WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM STARTING/CHARGING SYSTEM YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH) ACPT SCCS AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT BLK/YEL WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/WHT WIRE BPS CSGND HS CAN + FPC VAPNT ACCR BRN/GRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) 14 13 DEACTIVATOR SWITCH (ON BRAKE PEDAL SUPPORT) FENDER APRON) FEPS KAPWR ISP-R GROUND GROUND GROUND GROUND FPM ILC HS CAN- FTPREF SIGRTNC FUEL TANK PRESSURE (FTP) SENSOR (UNDER RIGHT SIDE OF VEHICLE) FUSE 24 FUSE 9 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT IN START OR RUN OD CANCEL SCCS RTN POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) RED/WHT WIRE RLY CTRL SMCS SHIFT INTERLOCK SYSTEM CRUISE CONTROL SYSTEM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SMR/START SNS FUEL PUMP DIODE STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM ANTI-LOCK BRAKES SYSTEM VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM STARTING/CHARGING SYSTEM YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE